2003 Chevrolet Avalanche Recalls
NHTSA lists 4 recall campaigns for the 2003 Chevrolet Avalanche. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Seat belts › Rear/otherCovers: Chevrolet Avalanche 2003–2005, Silverado 2003–2005, GMC Yukon 2003–2005 +5 more
Reported issue: On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to…
Possible consequence: A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
Remedy: Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at…
- Structure › Body › Tailgate › Hinge and attachmentsCovers: Chevrolet Avalanche 2002–2004, GMC Sierra 2000–2004, Chevrolet Silverado 2000–2004 +3 more
Reported issue: On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. If both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Possible consequence: Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables…
Remedy: Dealers will replace the cables. Interim owner notification began on april 7, 20004. The recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. Owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or…
- Service brakes, hydraulicCovers: Chevrolet Avalanche 2003–2004, Silverado 2003–2004, GMC Yukon 2003–2004 +10 more
Reported issue: Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Possible consequence: Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
Remedy: Dealers are to replace the hydro-boost relief valve. The recall began on june 18, 2004. Owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
- Fuel system, gasoline › Storage › Tank assemblyCovers: Chevrolet Avalanche 2003, GMC Yukon XL 2003, Chevrolet Suburban 2003
Reported issue: On certain pickup trucks and sport utility vehicles, vehicles, during a 30 degree left angle frontal impact of sufficient severity, a tear could develop in the mid-frame cross member at its attachment to the left frame rail. If the mid-frame cross member tears during frontal impact and produces a sharp edge, contact of the sharp edge with the fuel tank could result in a puncture of the fuel tank and possible fuel…
Possible consequence: Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy: Dealers will install a fuel tank shield. Owner notification began february 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
NHTSA investigations
- PE10010Brake line corrosion failureClosed · Mar 30, 2010
- EA04012Hydraulic pump failresClosed · Apr 30, 2004
← All problems reported for the 2003 Chevrolet Avalanche
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.