2016 Chevrolet Camaro Technical Service Bulletins

1,711 technical service bulletins (TSBs) are on record for the 2016 Chevrolet Camaro. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10088925Jun 28, 2016Equipment, Fuel system. This technical bulletin provides a procedure to replace the fuel feed line for conditions related to lack of power on hard acceleration.
• 10113951Jun 21, 2016Equipment. This Preliminary Information communication provides information to the technician with a diagnostic tip for navigation radios that have inaccurate entries at times when using the voice recognition to input the address. When using the Navigation command "Address" or "Destination" this Allows an address to be stated as a one-shot method. When using the Navigation command "Directed Address" this Allows an address to…
• 10088722Jun 15, 2016Transmission and drivetrain, Electrical system. This technicial bulletin provides a procedure on a revised calibration due to software anomaly to correct check engine light illuminated after using the manual paddle shift levers.
• 10081043Jun 14, 2016Fuel system, Engine. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have rattle or ticking noise that is louder inside the vehicle than outside. The noise may also sound like a lifter tick. If the noise is heard best at the fuel line and the sound will be real loud with a stethoscope. The fuel line will need to be replaced.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10080702Jun 13, 2016Engine. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have diagnostic trouble code p06dd or no or low oil pressure. Technician will replace timing chain tensioner guide. If oil pump face is damaged and or worn thru replace oil pump. Inspect bearings for damage wear due to debris from oil pump.
• 10089247Jun 10, 2016Equipment. This informational bulletin provides information on the proper use of floor mats.
• 10078432Jun 8, 2016Equipment. This technical bulletin provides a procedure to inspect the air box and air filter seal and replace if necessary to correct a customer concern that the malfunction indicator light (mil) is illuminated due to excessive sand and/or debris entering the air filter box and bypassing the seal of the air filter causing damage to the ho2 sensor and the catalytic converter to become blocked with sand and debris particles.
• 10097194Jun 7, 2016Electrical system, Equipment. This technical bulletin provides a procedure to reprogram the radio to correct a customer concern regarding a buzz or static noise caused by internal software.
• 10089393Jun 6, 2016Transmission and drivetrain. 44470 - customer satisfaction program. Certain 2016 model year chevrolet camaro and cadillac ct6 vehicles, equipped with an 8-speed automatic transmission (rpo m5t or m5n), may have been built with an incorrectly machined torque converter pressure plate. Over time, this condition could result in a shudder or vibration, fluctuations on the tachometer and possible torque converter failure. Replace the transmission.
• 10080682Jun 6, 2016Engine. This preliminary information communication provides information to the technician the some vehicles may have surge misfire feeling sensation during highway steady state driving in manual mode or automatic, typically in 6th, 7th, 8th gear accelerating 1000 to 2500 rpm under load. This is operating as designed. Torque converter clutch slip with condition present, with scan tool technician may monitor plus or minus…
• 10080566Jun 2, 2016Engine. This preliminary information communication provides information to the technician the some vehicles may have surge misfire feeling sensation during highway steady state driving in manual mode or automatic, typically in 6th, 7th, 8th gear accelerating 1000 to 2500 rpm under load. This is operating as designed. Torque converter clutch slip with condition present, with scan tool technician may monitor plus or minus…
• 10114105May 31, 2016Engine, Electrical system. This informational bulletin provides information on identifying non-GM (aftermarket) engine calibrations for gasoline engines using Tech 2 or GDS 2.
• 10114103May 27, 2016Engine cooling. This technical bulletin provides a procedure to bond the ceramic pin to the exhaust valve to correct a customer concern on an exhaust rattle originating from the rear of the vehicle caused by to the ceramic pin being loose on the exhaust valve.
• 10114101May 25, 2016Wheels. This informational bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening or re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed.
• 10114099May 24, 2016Electrical system. This technical bulletin provides a procedure to reprogram the radio to correct a customer concern of buzz or static noise from radio audio speakers, android auto connection issues, intermittent black screen or Sirius XM reverts to XM1 channel intermittently caused by to the current software calibration within the radio.
• 10078921May 24, 2016Equipment. This preliminary information communication provides the technician with a diagnostic aid for identifying infotainment components on the vehicles to ensure that the correct component is ordered or replaced and the correct labor code is used for warranty submission.
• 10118547May 20, 2016Tires. This informational bulletin provides information on the temporary tire flat spotting condition.
• 10114107May 20, 2016Electrical system. This informational bulletin provides information on service programming system (SPS) errors.
• 10078916May 20, 2016Equipment. This preliminary information communication advises the technician to replace the radio if the phone icon is pressed and it will highlight, or highlight and spin, but the radio will not change from that screen.
• 10078915May 20, 2016Engine. This preliminary information communication advises the technician that vehicles equipped with an 3.6l engine regular production option code lgx as part of our ongoing quality improvement efforts the engine is being placed on restriction. Dealer will need to call product quality center for assistance.
• 10078911May 19, 2016Engine. This preliminary information communication provides information to the technician on how to diagnose and repair a vehicle with engine regular production option code lgx when it has a hollow knock or tap noise coming from the engine compartment. With the vehicle warmed up to 98c or 208f determine if the noise is present. If the noise is present pump the brakes 3-5 times to see if the noise goes away, noise will…
• 10114111May 17, 2016Electrical system. This engineering information bulletin is requesting information from the dealers on a customer concern that one of the USB ports is not charging, allowing data to transfer.
• 10118546May 16, 2016Equipment. This informational bulletin provides information on a new U.S. dealer special tool loan program.
• 10118545May 16, 2016Electrical system, Equipment. This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
• 10134546May 13, 2016Equipment, Back-over prevention (rear camera). This technical bulletin provides a procedure to reprogram the radio to correct a customer concern of radio Inoperative, blue Screen, AM clipping noise, HD on/off status not retained in stations, time lag on transitions, no audio with internal amp, and park assist symbol position wrong in rear view camera.
• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10078878May 11, 2016Engine. This preliminary information communication advises the technician that the e80 engine control module part numbers 12669908 or 12672502 have been placed on part restriction by general motors technical assistance. Dealer will need to call general motors technical assistance center for further assistance.
• 10078877May 11, 2016Electrical system. This preliminary information communication provides the technician with the steps needed to diagnose and repair a vehicle with wi-fi or bluetooth inoperative or poor performance concern. Technician will need to obtain data from global diagnostics services 2 and call general motors technical assistance center for further assistance.
• 10126043May 9, 2016Equipment. 28380 - Service Update. Dealers are to inspect for two Julian dates, inspect for cracks and replace if needed the rear toe links on certain 2016 model year Chevrolet Camaro vehicles. These vehicles may have been built with rear suspension toe links that have small cracks in the area of the pressed-in end bushings or cross axis ball joints. The cracks were formed during the manufacturing process of the toe links…
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10134535May 6, 2016Engine cooling. This technical bulletin provides a procedure to lubricate the exhaust valves to correct a customer on hearing a squeak or chirp noise coming from the rear of the vehicle caused by to the opening/closing of the exhaust values during normal performance.
• 10081365May 6, 2016Electrical system. This informational bulletin provides information on the identification of vehicles that are shipped with the transport mode on and how to turn it off.
• 10078868May 3, 2016Transmission and drivetrain. This preliminary information communication advises the technician that the 8l45 8 speed automatic transmission product quality center transmission exchange has ended.
• 10078584May 1, 2016Electrical system, Engine. This technical bulletin provides a procedure to replace the active noise cancellation (anc) module to correct a customer concern of a notice a noise or disturbance inside the vehicle at low engine speeds due to the interaction between the vehicle's active noise cancellation (anc) microphones (which are located in each interior door panel) and the door speakers themselves.
• 10078583May 1, 2016Equipment. This informational bulletin provides information to advise the customers that have enrolled their vehicle into the onstar advanced diagnostics & real time diagnostic alerts they may receive alerts from their vehicle when it is being serviced.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10078567May 1, 2016Engine. This technical bulletin provides a procedure to replace the valve lifter oil manifold and affected bank of afm lifters to correct a customer concern on a malfunction indicator lamp (mil) on and/or an engine misfire/tick noise with dtc p0300 set due to an active fuel management (afm) lifter that is mechanically collapsed and/or stuck all of the time.
• 10078566May 1, 2016Engine cooling, Equipment. This informational bulletin provides information to not replace any parts for a concern that the crankshaft balancer looks like it is wobbling or vibrating or the mounting bolt does not appear to be centered on the balancer correctly due to the crankshaft balancer bolt being painted silver and the crankshaft balancer being painted black. This gives the illusion that the bolt or balancer is out of round or vibrating.
• 10078705Apr 29, 2016Tires, Equipment. This technical bulletin provides a procedure to what frequency tire pressure indicator sensor should be installed on the car for accessory wheels to correct a concern that the tire pressure indicator sensor tool will read the sensor but unable to learn the sensors to the car due to the incorrect mhz tire pressure indicator sensor being installed in the tire/wheel assembly.
• 10083899Apr 28, 2016Fuel system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a rattle or ticking noise that is louder inside the vehicle than outside. Instructions are provided to inspect the fuel feed line between the high pressure fuel pump and chassis fuel line.
• 10078755Apr 28, 2016Fuel system, Body and structure. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a rattle or ticking noise that is louder inside the vehicle than outside. Instructions are provided to inspect the fuel feed line between the high pressure fuel pump and chassis fuel line.
• 10083893Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of the radio is inopertive. New software has been released to correct this concern.
• 10083782Apr 27, 2016Engine, Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of black smoke when starting the vehicle after sitting.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078749Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of the radio is inopertive. New software has been released to correct this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078744Apr 27, 2016Fuel system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of black smoke when starting the vehicle after sitting.
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.

← All problems reported for the 2016 Chevrolet Camaro