2012 Chevrolet Captiva Sport Technical Service Bulletins

648 technical service bulletins (TSBs) are on record for the 2012 Chevrolet Captiva Sport. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10078735Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078507Apr 18, 2016Electrical system, Equipment. This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
• 10078506Apr 18, 2016Electrical system. This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
• 10078504Apr 18, 2016Engine. This informational bulletin provides information internal engine noise or damage after oil filter replacement
• 10078502Apr 15, 2016Equipment. This warranty administration bulletin provides information on gm’s policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
• 10078481Apr 12, 2016Equipment. This informational bulletin provides information on the purpose of magnetic drain plugs.
• 10078472Apr 12, 2016Visibility (wipers, defrost, mirrors). This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
• 10083900Apr 8, 2016Equipment, Electrical system. This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
• 10078435Apr 7, 2016Equipment, Body and structure. This preliminary informational bulletin provides information that may be helpful when addressing underbody component corrosion with customers.
• 10083512Apr 5, 2016Visibility (wipers, defrost, mirrors), Equipment. This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078604Apr 5, 2016Electrical system, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078434Apr 1, 2016Transmission and drivetrain. This informational bulletin provide information on the operating characteristics of a manual transmission.
• 10078430Apr 1, 2016Steering. "this technical bulletin provides a procedure to inspect the steering gear for a normal condition of grease or sealant on exterior case of gear due to the manufacturing process."
• 10075736Jan 22, 2016Engine. Some customers may complain of an engine oil leak that appeared as they were driving the vehicle in extremely cold ambient temperatures (Generally 0 F /-17 C or Colder). They may also comment that they heard a single "pop" noise right before the oil leak started. Upon inspection, the technician will find that the oil leak is coming from the rear main oil seal of the engine as shown below. This may be the result of…
• 10095197Jan 21, 2016Engine. This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have oil mixed in with the engine coolant. Technician will need to inspect the oil cooler if equipped for possible leaking into the cooling system through the radiator. If no issue found replace the engine as well as all rubber coolant hoses.
• 10246963Jan 13, 2016Equipment. Changing Turn-By-Turn Voice Response To Metric Or English Units
• 10246639Jan 1, 2016Steering. Power Steering Noise or Fluid Leak from Power Steering Pump, Gear or High Pressure Hose During Extreme Low Temperature Conditions
• 10201115Dec 1, 2015Equipment, Other or unknown. OnStar Voice Fallback Number Update
• 10201098Dec 1, 2015Transmission and drivetrain, Engine. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
• 10190504Dec 1, 2015Electrical system, Equipment. IPC Odometer Programming Method Quick Reference Guide Season Odometer Programming Methods in Use Today 1. IPC reprogramming and setup using the service programming system (SPS). 2. Odometer setup at the electronic service center (ESC) when using an exchange IPC/DIC. 3. Tech 2® – The Tech 2 is used to set up a replacement BCM, which includes loading the odometer value that is displayed and stored in the IPC.
• 10190503Dec 1, 2015Engine, Transmission and drivetrain. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
• 10115143Nov 30, 2015Engine cooling. This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspect for a poor crimp on the grounds ring terminal at the engine block for the bank with the concern and repair the wire.
• 10075740Nov 23, 2015Engine. If a vehicle comes into the dealership with a knock noise, seized engine, lower end squeak or squeal or any condition that you suspect a rod or main bearing failure.
• 10095317Jan 15, 2015Equipment. This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. General motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10094888Jan 14, 2015Equipment, Electrical system. This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10247716Dec 1, 2014Equipment, Electrical system. J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
• 10247061Dec 1, 2014Electrical system. J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
• 10245938Dec 1, 2014Electrical system. OnStar Module Does Not Support All B101D Symptom Codes.
• 10252163Nov 1, 2014Equipment. XM Audio Traffic And Travel Link Availability And Operation.
• 10250082Nov 1, 2014Transmission and drivetrain. Information on Driveline Clunk Noise
• 10247063Nov 1, 2014Visibility (wipers, defrost, mirrors). A/C Blows Warm Or Poor Performance.
• 10246569Nov 1, 2014Transmission and drivetrain. Information on Driveline Clunk Noise
• 10245951Nov 1, 2014Equipment. Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
• 10056473Sep 1, 2014Engine cooling. Cadillac/buick/chevrolet/gmc: due to cam actuator codes set - dtc p0011, dtc p0014, dtc 20024, dtc p0021 and no other drivability issues, the engine eun sticker should be inspected, before replacing actuator.
• 10056361Aug 1, 2014Engine. Buick/cadillac/chevrolet/saturn/pontiac/ gmc: vehicle experience lower end squeak or squeal, knocking noise or seized engine possibly the main bearing or rod had failed.
• 10052379Aug 1, 2014Steering. Buick/cadillac/chevrolet/gmc: during extreme low temperature conditions, the power steering makes noises or fluid leaks from high pressure hose, power steering pump or gear. *pe updated 9/30/13. *pe updated 11/7/14.
• 10248444Jun 30, 2014Equipment. Vehicle Recalls
• 10246983May 1, 2014Equipment. Checking Smartphone Bluetooth Software Update Status
• 10246599May 1, 2014Electrical system. Implementation of Logistics Fuse - Additional Pre-Delivery Inspection (PDI) Steps and Inventory Considerations
• 10056237May 1, 2014Electrical system. General motors: due to loose ground terminal connections, in some vehicles and trucks experience, accessories malfunctions, dic messages, ipc warning indicators, ses light on.
• 10250013Apr 1, 2014Electrical system. High Voltage Safety ? High Voltage Disabling
• 10246623Apr 1, 2014Vehicle speed control, Electrical system, Exterior lighting, Other or unknown…. Car and Truck Fix it Right the First Time Issues
• 10247681Mar 1, 2014Equipment. Information On Requests To Add OnStar Bluetooth Option.
• 10246982Mar 1, 2014Electrical system. Checking Smartphone Bluetooth Software Update Status
• 10245950Mar 1, 2014Equipment. Canadian Customers Unable To Place Calls In The United States
• 10073396Mar 1, 2014Equipment. Summary to be provided on a future date.
• 10070907Mar 1, 2014Fuel system. Summary to be provided on a future date.
• 10190932Feb 1, 2014Equipment, Wheels. Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes…
• 10190931Feb 1, 2014Equipment, Wheels. Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes…
• 10190934Jan 1, 2014Equipment, Body and structure. Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the…

← All problems reported for the 2012 Chevrolet Captiva Sport