2016 Chevrolet Colorado Technical Service Bulletins

1,597 technical service bulletins (TSBs) are on record for the 2016 Chevrolet Colorado. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10118250Jun 7, 2017Engine. This Preliminary Information communication provides information to the technician about vehicles that have a knock noise, seized engine, lower end squeak or squeal from the engine. Technician will inspect the oil control solenoids for metal debris. Also inspect for damage to the cam caps Journals and camshaft journals on the heads. The check the timing chain idler sprockets for stiffness when turning. If any of…
• 10118248Jun 7, 2017Suspension, Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that may have a vibration at idle in gear or at very low speeds. Technician should inspect for a stray nut or debris such as a rock wedged between the rubber and metal portions of the transmission mount. Technician will need to remove the stray debris.
• 10118238Jun 6, 2017Electrical system. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicle that may have a "Check Trailer Wiring" or "Service Trailer Brake System” message on the Driver Information Center when a trailer is connected to the vehicle. Diagnostic Trouble Code C1114 set in the Chassis Control Module. Chassis Control Module has to determine the type of trailer brake…
• 10118233Jun 2, 2017Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
• 10137668May 24, 2017Electrical system. This technical bulletin provides a procedure to add dielectric grease to the x105 active shutter connector to correct the DTC that sets.
• 10137665May 23, 2017Equipment. This informational bulletin explains the Road Force balancers and what they can do for customer concerns.
• 10137600May 22, 2017Wheels. This informational bulletin provides information on Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels.
• 10137684May 19, 2017Engine cooling. This engineering information bulletin ends the need for information from the field on vehicles that have the condition of a engine overheating and or coolant leak found on vehicle.
• 10137680May 19, 2017Brakes. This preliminary informational bulletin provides information regarding the normal characteristic of instrument panel red brake light intermittently comes on.
• 10137601May 17, 2017Engine. This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on engine surfaces.
• 10137605May 15, 2017Equipment. This informational bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.
• 10137659May 12, 2017Equipment. This informational bulletin provides information for dealers/technicians on the availability of a new spring replacement tonneau latch to replace an original quarter turn latch that has broken.
• 10137653May 10, 2017Engine, Equipment. This informational bulletin explains the difference in oil filters and the possibilities of what may happen using the incorrect filter.
• 10137640May 10, 2017Transmission and drivetrain. This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
• 10137635May 10, 2017Equipment, Fuel system. This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
• 10137602May 4, 2017Equipment. This informational bulletin provides the dealership with how to prep a vehicle for delivery to the customer to aid in higher CSi scores.
• 10137681May 3, 2017Body and structure. This preliminary informational bulletin provides a procedure to Adjust Lower Rear Striker on Extended Cab to correct a condition of Rear Door Ajar Message, Rear Door Hard to Close, and/or Rattle Noise from Lower Rear Door due to the rear door lower striker being out of position.
• 10137603May 2, 2017Equipment. This warranty administration bulletin provide policy information on required operating procedures.
• 10114043Apr 27, 2017Electrical system. This informational bulletin provides information on Wireless Charging Module Diagnosis.
• 10113986Apr 26, 2017Fuel system. This technical bulletin provides a procedure to replace the fuel pump module assembly if the DTC P2635 and/or P018B are set.
• 10113978Apr 26, 2017Equipment. This warranty administration bulletin provides information on Dealer Empowerment Labor Operations and Customer Enthusiasm.
• 10114036Apr 21, 2017Equipment. This bulletin explains the hill decent controls and how it controls speeds when used.
• 10114035Apr 21, 2017Equipment. This informational bulletin explains how to check the NOx Catalyst Reductant-Load Adaptive Values using GSD2.
• 10113980Apr 21, 2017Equipment. ?
• 10113983Apr 20, 2017Equipment, Suspension, Engine. This informational bulletin advises the technician not to change the crankshaft balancer if it has the illusion of a wobble or vibration appearance.
• 10114027Apr 19, 2017Wheels. This informational bulletin provides information on Non-Design Intent Wheel Lock Nuts and Lug Nuts.
• 10113985Apr 19, 2017Transmission and drivetrain. This technical bulletin provides a procedure to flush and drain fluids for the transmission to eliminate a shake and/or shudder during a light throttle acceleration between 40 and 128 KM/H (25 and 80 MPH) at a steady state.
• 10113993Apr 18, 2017Equipment. this informational bulletin provides Information on Using MyBuick, MyCadillac, MyChevrolet, and MyGMC Phone Applications to Control GM Accessory Remote Start Kits.
• 10114016Apr 13, 2017Engine. This technical bulletin provides a procedure to Tighten the Charge Air Cooler Duct Clamp to correct a condition of an oil leak originating from either the inlet or outlet duct of the turbocharger due to the charge air cooler pipe clamp not being tightened properly.
• 10114048Apr 12, 2017Equipment. This preliminary informational bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.
• 10114053Apr 11, 2017Transmission and drivetrain, Suspension. This PI includes information that helps diagnose tips for P0741 This condition may be caused by a damaged turbine shaft front bushing (218). The turbine shaft may also be damaged in the journal area that is in contact with this bushing.
• 10113977Apr 10, 2017Equipment. This informational bulletin provides information on proper use of floor mats.
• 10114007Apr 7, 2017Electrical system. This technical bulletin provides a procedure to reprogram the ECM for vehicles with the condition of Malfunction Indicator Lamp (MIL) Illuminated with One or Multiple DTCs Set due to a calibration concern within the ECM.
• 10113979Apr 6, 2017Electrical system, Equipment. This informational bulletin provides information on approved warranty part numbers for original equipment batteries
• 10113976Apr 6, 2017Electrical system. This warranty administration bulletin provides policy information on the requirements for battery testing and warranty replacements.
• 10113853Apr 3, 2017Equipment. This Preliminary information communicates to the technician when diagnosing intermittent circuit concerns to look at the connector for missing weather pack seals that could allow water intrusion into the connector and lead to corrosion on the terminals.
• 10138086Mar 29, 2017Suspension. This informational bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operations.
• 10138174Mar 24, 2017Transmission and drivetrain, Engine, Equipment. This Preliminary Information communication provides information to the technician of a complaint of a sag or hesitation when accelerating. The concern is present when coasting at low speeds of less than 15 miles per hour and then aggressively applying the throttle, or after making a hard stop followed by an aggressive throttle.
• 10138015Mar 24, 2017Body and structure. This informational bulletin provides technicians and dealership personnel with spray-in bed liner general information and repair procedures.
• 10138087Mar 17, 2017Steering. This preliminary information bulletin provides information for diagnosing a power steering fluid leak at the fluid reservoir.
• 10138095Mar 16, 2017Engine cooling. This engineering information bulletin ends the need for information from the field on vehicles that have the concern of a noisy water pump.
• 10138063Mar 16, 2017Fuel system. This informational bulletin explains how the DEF filler pipe grommet can possible expand to the filler cap causing the cap not to seal properly.
• 10138060Mar 15, 2017Equipment. This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
• 10116659Mar 15, 2017Transmission and drivetrain. This Preliminary Information communication provides information to the technician on how to repair vehicles with a rattle or clunk noise from the front of vehicle over bumps. Engineering has released a redesigned lower intermediate shaft for this noise concern. Replace the lower intermediate shaft with the new part number.
• 10138026Mar 13, 2017Transmission and drivetrain. This informational bulletin advises the technician not to change the crankshaft balancer if it has the illusion of a wobble or vibration appearance.
• 10138025Mar 13, 2017Steering. This technical bulletin provides a procedure inspecting for excess grease or Sealant on the Exterior of the steering gear due to seeing grease or sealant on certain locations on the gear.
• 10138054Mar 10, 2017Electrical system. This informational bulletin provides information on On rare occasions, a security code input message with SPS error code E5659, M5304, and/or M5530 may be displayed in TIS2web when the technician is programming any module. If this concern is encountered, the technician should start by ensuring that the module being programmed is not a used module and that the VIN matches on VIN plate, TIS2web programming screen…
• 10138053Mar 9, 2017Transmission and drivetrain. This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
• 10138014Mar 7, 2017Equipment. This information bulletin explains the labor operation numbers used for submitting warranty claims and how to setup, and reprogram modules.
• 10138039Mar 3, 2017Equipment. This technical bulletin is providing a procedure to reprogram the HMI module to correct multiple conditions including Waiting for Update Media Message, Voice Command For Calling Bluetooth Phone Contacts Inoperative, Intermittent Loss of Rear Camera Gridlines, Service Rear Vision System Message, Radio Turns On Unwanted At Startup, and/or Navigation Radio Destination State Defaults To WV, Intermittent Radio/display…

← All problems reported for the 2016 Chevrolet Colorado