2019 Chevrolet Colorado Technical Service Bulletins

987 technical service bulletins (TSBs) are on record for the 2019 Chevrolet Colorado. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10224278Sep 6, 2022Equipment. This Preliminary information communicates the potential for a wire chafe to cause intermittent communications concerns and multiple MIL's on in the IPC.
• 10224273Sep 1, 2022Transmission and drivetrain. This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an automatic transmission.
• 10220319Sep 1, 2022Transmission and drivetrain. This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.
• 10220308Sep 1, 2022Equipment. This service bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.
• 10219284Aug 25, 2022Equipment. This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
• 10219278Aug 22, 2022Equipment. This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).
• 10219274Aug 16, 2022Engine cooling. This engineering informational bulletin is requesting information from technicians to perform the check list provided and contact the engineer listed in regards to the crankshaft balancer appears to be wobbling and/or vibrating, mounting bolt does not appear to be centered.
• 10219266Aug 15, 2022Engine cooling. This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.
• 10218873Aug 10, 2022Fuel system, Engine cooling. This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
• 10218875Aug 9, 2022Transmission and drivetrain. This technical bulletin provides a procedure to replace the rear axle c-clips if found the cause of the customers concern of rear axle clunk.
• 10217855Aug 2, 2022Equipment. This service bulletin provides repair information to correct a customer concern of Radio Resets or Reboots and May Display myBrand Splash Animation.
• 10217043Jul 22, 2022Equipment. This bulletin provides information on Warranty Administration – Required Operating Procedures - 8 Points (U.S. Only).
• 10217048Jul 18, 2022Equipment. This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
• 10216054Jul 15, 2022Equipment. This service bulletin provides information for dealers/technicians on Handsfree Apple Iphone Call Static conditions equipped with IOB Radio.
• 10217764Jul 5, 2022Equipment, Brakes, Electrical system. This Preliminary information communicates direction and examples when diagnosing multiple DTCs, one of which includes U**** Byte 71 DTC.
• 10217762Jul 1, 2022Tires, Equipment. This Preliminary Information communication provides information to the technician about vehicles with tire sidewall irregularities. This is a visual condition that will not affect durability, reliability or performance of the tires. Dealer should communicate to the customer that slight sidewall indentations are a common characteristic of radial tire construction.
• 10215655Jun 28, 2022Equipment. This warranty admin bulletin covers information on Essential Tools that include Consumable Parts.
• 10215643Jun 27, 2022Equipment, Engine cooling, Visibility (wipers, defrost, mirrors). This service bulletin provides information to dealership personnel on a new refrigerant (R1234yf) for A/C service.
• 10215628Jun 24, 2022Equipment. This service bulletin provides information for replacement parts traceability (RPT) process to aid in tracking part replacements.
• 10216372Jun 22, 2022Visibility (wipers, defrost, mirrors). This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10215626Jun 21, 2022Equipment. This service bulletin provides information for dealers/technicians on accessory all-weather floor liners and flat mats warped or misshapen.
• 10214869Jun 15, 2022Engine cooling. This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
• 10216361Jun 13, 2022Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
• 10214501Jun 6, 2022Wheels. This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
• 10213700Jun 1, 2022Equipment, Steering. This service bulletin provides a procedure inspecting for excess grease or Sealant on the Exterior of the steering gear due to seeing grease or sealant on certain locations on the gear.
• 10213818May 31, 2022Body and structure. This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
• 10213816May 26, 2022Fuel system. This Preliminary information communicates provides information to the technician on the use of R-99 or R-95 Renewable diesel fuel.
• 10213810May 23, 2022Electrical system, Exterior lighting. This Preliminary Information communication advises the technician to inspect for aftermarket accessory lamps for a loss of remote functions.
• 10213809May 23, 2022Electrical system. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have the battery is discharged overnight. Technician will need to inspect X301 for bent pins as shown below. Repair or replace terminals as needed.
• 10213252May 19, 2022Equipment. This service bulletin provides information on GM Canada New Vehicle Tire Warranty Program for Original Equipment (OE) Tires and PDI installed Limited Production Option (LPO) Tires.
• 10213007May 18, 2022Transmission and drivetrain. This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
• 10213036May 16, 2022Fuel system, Engine cooling, Brakes, Wheels. This informational bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
• 10213022May 16, 2022Equipment. This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
• 10212910May 11, 2022Wheels. This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
• 10211684May 6, 2022Transmission and drivetrain. This service bulletin provides information on Transmission Adaptive Functions and Correcting Low Mileage Harsh Shifts, Slips, or Flares.
• 10211692May 2, 2022Engine cooling. This service bulletin provides inspection/diagnosis/correction information on a cold start misfire and/or rough idle and DTC P0300 that may also be set.
• 10211658May 2, 2022Engine, Equipment. This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
• 10211070Apr 28, 2022Transmission and drivetrain. This technical bulletin provides a procedure to clear the codes and test the Tcase if found that the customer has tried to shift the t-case from 4lo to Hi gears while driving.
• 10211778Apr 27, 2022Engine cooling. This preliminary information was released to advise of an alternate means of purging the air from the cooling system.
• 10210841Apr 20, 2022Equipment. This service bulletin provides information for replacement parts traceability (RPT) process to aid in tracking part replacements.
• 10211770Apr 19, 2022Visibility (wipers, defrost, mirrors). This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10211767Apr 14, 2022Transmission and drivetrain, Suspension. This Preliminary Information communication provides information to the technician about vehicles that may have a vibration at idle in gear or at very low speeds. Technician should inspect for a stray nut or debris such as a rock wedged between the rubber and metal portions of the transmission mount. Technician will need to remove the stray debris.
• 10211766Apr 13, 2022Brakes. This Preliminary Information communication provides information to the technician that some vehicle may have a water leak into the cabin. Water staining may be seen in the headliner or water may be on the floor. Technician will inspect these areas for water intrusion roof ditch, rear glass, center high mounted stop light, windshield, cowl seam, heater-vent-air conditioning drain tube, pillar area, and the pressure…
• 10211764Apr 13, 2022Body and structure. This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. Technician should not replace any parts for this concern. Please communicate to the customer this condition is a normal operating characteristic of their vehicle.
• 10210543Apr 13, 2022Equipment. This informational bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
• 10211760Apr 11, 2022Brakes. This preliminary information discusses potential for a code C0010.5A to store in the brake controller which appears to be setting falsely or is induced by the customer.
• 10210441Apr 7, 2022Body and structure. This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.
• 10210194Apr 5, 2022Other or unknown. This informational bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
• 10209980Mar 31, 2022Engine cooling. This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
• 10209977Mar 30, 2022Equipment. This service bulletin provides information for replacement parts traceability (RPT) process to aid in tracking part replacements.

← All problems reported for the 2019 Chevrolet Colorado