2012 Chevrolet Corvette Technical Service Bulletins

1,379 technical service bulletins (TSBs) are on record for the 2012 Chevrolet Corvette. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10082814Aug 2, 2016Engine. This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
• 10082820Aug 1, 2016Engine. This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
• 10135430Jul 22, 2016Fuel system. 15682 - Special Coverage. Some vehicles may have a condition where a fuel odor is detected, fuel droplets appear below the left-hand fuel tank with fuel gauge level above 1/2, or a malfunction indicator lamp illuminates due to a leak path in the left-hand fuel pump module flange. If the condition occurs within the stated terms dealers are to replace the left hand fuel tank fuel pump module.
• 10126063Jul 12, 2016Engine. This informational bulletin provides information on intake manifold inspection/replacement after severe internal engine damage.
• 10126062Jul 11, 2016Brakes. This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
• 10100822Jul 11, 2016Engine. This informational bulletin provides the technician with what may happen to an engine due to lack of maintenance.
• 10089121Jun 29, 2016Tires, Equipment. This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10089247Jun 10, 2016Equipment. This informational bulletin provides information on the proper use of floor mats.
• 10114105May 31, 2016Engine, Electrical system. This informational bulletin provides information on identifying non-GM (aftermarket) engine calibrations for gasoline engines using Tech 2 or GDS 2.
• 10114101May 25, 2016Wheels. This informational bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening or re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed.
• 10118547May 20, 2016Tires. This informational bulletin provides information on the temporary tire flat spotting condition.
• 10114107May 20, 2016Electrical system. This informational bulletin provides information on service programming system (SPS) errors.
• 10118546May 16, 2016Equipment. This informational bulletin provides information on a new U.S. dealer special tool loan program.
• 10118545May 16, 2016Electrical system, Equipment. This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10078874May 10, 2016Equipment. This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for non - general motors aftermarket accessories installed on the vehicle that can cause these issues.
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10078568May 1, 2016Transmission and drivetrain, Equipment. This informational bulletin provides information on how to inspect the upper valve body to determine the correct rpo usage to correct a concern that after installation of a replacement upper valve body, the transmission may have no reverse and no 2nd gear due to the installation of the incorrect upper valve body.
• 10060318May 1, 2016Equipment. Summary to be provided on a future date.
• 10083898Apr 27, 2016Equipment, Electrical system. This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10137768Apr 26, 2016Electrical system. 15521 ? Customer Advisory Letter. On these vehicles, if the side doors will not open from inside the vehicle due to low or no battery voltage, such as a discharged or disconnected battery, or if the vehicle is entered without the key fob or the fob is not working, customers are being advised that the driver and passenger side doors can still be opened from inside the vehicle by using the manual release levers…
• 10078801Apr 26, 2016Electrical system, Body and structure. 15521 – customer advisory letter. On these vehicles, if the side doors will not open from inside the vehicle due to low or no battery voltage, such as a discharged or disconnected battery, or if the vehicle is entered without the key fob or the fob is not working, customers are being advised that the driver and passenger side doors can still be opened from inside the vehicle by using the manual release levers…
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.
• 10137766Apr 21, 2016Seats, Air bags. 15643 ? Special Coverage. On these vehicles, the wire harness connector from the seat side airbag and buckle tensioner to the body has a design interference between the vertical adjust crossbar and the carpet. When the seat is moved forward or back, the connector may be dragged along the carpet, pulling terminals loose or pulling the connector apart. This will cause a diagnostic trouble code to be set and the…
• 10083509Apr 21, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern. The vehicle's xm radio only has xm preveiw channels.
• 10083482Apr 21, 2016Equipment. This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. The vehicle's xm travel link may be inopertive.
• 10078777Apr 21, 2016Air bags, Electrical system. 15643 – special coverage. On these vehicles, the wire harness connector from the seat side airbag and buckle tensioner to the body has a design interference between the vertical adjust crossbar and the carpet. When the seat is moved forward or back, the connector may be dragged along the carpet, pulling terminals loose or pulling the connector apart. This will cause a diagnostic trouble code to be set and the…
• 10078522Apr 20, 2016Equipment. "this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to customer improperly setting the radio volume high enough when the turn-by-turn navigation messages are played. "
• 10078520Apr 20, 2016Electrical system. This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
• 10083884Apr 19, 2016Equipment. This preliminary information communication advises the technician on the steps for diagnosing the concern. The vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
• 10083484Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078735Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078507Apr 18, 2016Electrical system, Equipment. This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
• 10078506Apr 18, 2016Electrical system. This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
• 10078504Apr 18, 2016Engine. This informational bulletin provides information internal engine noise or damage after oil filter replacement
• 10078502Apr 15, 2016Equipment. This warranty administration bulletin provides information on gm’s policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
• 10078481Apr 12, 2016Equipment. This informational bulletin provides information on the purpose of magnetic drain plugs.
• 10078472Apr 12, 2016Visibility (wipers, defrost, mirrors). This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
• 10083900Apr 8, 2016Equipment, Electrical system. This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
• 10078435Apr 7, 2016Equipment, Body and structure. This preliminary informational bulletin provides information that may be helpful when addressing underbody component corrosion with customers.
• 10083512Apr 5, 2016Visibility (wipers, defrost, mirrors), Equipment. This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078604Apr 5, 2016Electrical system, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078434Apr 1, 2016Transmission and drivetrain. This informational bulletin provide information on the operating characteristics of a manual transmission.
• 10078430Apr 1, 2016Steering. "this technical bulletin provides a procedure to inspect the steering gear for a normal condition of grease or sealant on exterior case of gear due to the manufacturing process."
• 10112831Mar 30, 2016Wheels. This informational bulletin provides information on chemical staining, pitting, and corrosion on wheels and the proper cleaners to use to fix the conditions due to multiple causes.

← All problems reported for the 2012 Chevrolet Corvette