2014 Chevrolet Corvette Technical Service Bulletins

1,986 technical service bulletins (TSBs) are on record for the 2014 Chevrolet Corvette. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10118980Sep 23, 2016Equipment. This preliminary informational bulletin adds the 2015 - 2016 model years to a procedure to correct a customer concern of door rattle noise from outside of vehicle during high radio volume or high bass levels.
• 10099466Sep 23, 2016Engine. This preliminary information communication provides information to the technician about vehicles that may have a service engine soon malfunction indicator lamp on and diagnostic trouble code p0300 - p0308 may set. Technician will inspect for lose sparkplug wire. If a spark plug wire is found lose check for a missing “c” clip on the wire end for the ignition coil. If the clip is missing replace the wire.
• 10118915Sep 22, 2016Equipment. This informational bulletin provides information on Inappropriate Warranty Claims Submitted for Damaged Radios and IPCs
• 10118910Sep 22, 2016Equipment. This informational bulletin provides information on new tools used for the Hem Flanges and how to repair and seal the flanges when the repairs are done.
• 10118908Sep 19, 2016Equipment. This informational bulletin provides information on comebacks prevention information and using customer concern verification sheets (CCVS).
• 10118914Sep 16, 2016Electrical system. This informational bulletin explains the programming method quick reference guide for the IPC Odometer.
• 10098467Sep 16, 2016Equipment. This preliminary information communication provides information to the technician about vehicles that the radio will not save xm favorites. Technician will need to replace the radio to address the concern.
• 10118909Sep 14, 2016Tires. This GM of Canada New Vehicle Tire Warranty Program and GWM Transaction Submission Information Bulletin provides information for the new tires that the vehicle are equipped with and that they are covered by General Motors against defects in material or workmanship under the New Vehicle Warranty (Base Warranty Coverage) and for vehicles within this warranty period, the defective tires will be replaced on a pro rata…
• 10097132Sep 14, 2016Electrical system, Equipment. This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down remove power to the onstar module for five minutes. After the power has been removed for five minutes, if the onstar system is working release the vehicle.
• 10098423Sep 13, 2016Steering. This preliminary information communication provides information to the technician about the media oriented systems transport bus diagnostic tool kit (el-51578) has been released to help diagnose any of the media oriented systems transport bus concerns. The kit contains header connectors that are installed to bypass media oriented systems transport bus modules. The bypass connector also contains a terminal for…
• 10118991Sep 12, 2016Electrical system. This engineering informational bulletin is requesting information from the field of vehicles with the condition of power seat, memory recall, and easy exit recall function seems erratic or seems to operate intermittently.
• 10099252Sep 9, 2016Engine. This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. Technician will need to perform published service information diagnostics. If technician finds carbon, an upper engine and valve cleaning should be performed.
• 10118911Sep 1, 2016Fuel system. This informational Bulletin provides Do's and Don'ts for maximizing gasoline engine fuel economy, other various tips and a list of websites for additional information.
• 10082412Aug 31, 2016Electrical system. This technical bulletin provides a procedure to check the cylinders for damaged pistons and determine if the use of aftermarket calibrations or performance parts may be the cause.
• 10083241Aug 30, 2016Electrical system. This preliminary information communication provides information to the technician about the use of j-35616-64b terminal test probe, replacement terminals, and terminated leads. The j-35616-64b is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (j-38125-620h) located in lear tray 7 part number 963716-2.
• 10082869Aug 29, 2016Engine. This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
• 10082871Aug 23, 2016Wheels. This technical bulletin provides a procedure to clean mating surface of wheels and rotors to correct a customer concern on a clicking noise emanating from either the front or rear wheels location due to interaction between the wheel mounting face and the wheel mounting surface on the brake rotor.
• 10083080Aug 15, 2016Engine cooling. This preliminary information communication provides information to the technician about vehicles that may have low oil pressure message. Technician may also find a diagnostic trouble code p0521 in the engine control module. Technician should follow all published service information diagnosis.
• 10082865Aug 15, 2016Seat belts. This preliminary informational bulletin provides a procedure to reposition the front seat belt latch plate for concerns regarding the seat belt webbing or latch plate coming twisted.
• 10083067Aug 12, 2016Seats. This preliminary information communication provides information to the technician about vehicles that have the base power seat, memory recall, and easy exit recall functions may seem erratic or seem to operate intermittently.
• 10082822Aug 12, 2016Electrical system, Engine. This informational bulletin provides information on how to test a battery and what is needed to warranty a battery.
• 10082363Aug 12, 2016Equipment. This warranty administration bulletin provide policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
• 10082863Aug 9, 2016Equipment, Electrical system. This informational bulletin provides information for ignition key, fob, key tags and key rings configuration for various vehicles and applying a qr code sticker or barcode sticker to the fob.
• 10082862Aug 8, 2016Tires. This informational bulletin provides information on the rubber used in some performance tires loses flexibility and may develop surface cracks in the tire tread/shoulder area at colder temperatures.
• 10082453Aug 8, 2016Transmission and drivetrain. This informational bulletin explains the possiblity of improperly installing the driveline at which it may cause excessive pressure on the crankshaft creating internal damage to the engine.
• 10082447Aug 8, 2016Engine cooling. This informational bulletin explains a possible normal whining noise from the balance shaft chain if the vehicle has less than 10,000 miles on it.
• 10082860Aug 3, 2016Equipment. This informational bulletin provides information on gm does not approve the use of “clipping” to repair collision damage to vehicles. Gm has not tested or validated a “clipped vehicle” repair; therefore, gm cannot endorse this type of repair or confirm the crash performance during a subsequent collision.
• 10083776Aug 2, 2016Electrical system. This preliminary information communication advises the technician on steps to perform to determine if the customer's battery drain concern is being caused by a known concern with bluetooth call transfer operation when exiting the vehicle. If the concern is duplicated at the dealer with the onstar led is still green after the vehicle is turned off and the bluetooth call was disconnected. Dealer should advises that…
• 10083040Aug 2, 2016Equipment, Body and structure. This preliminary information communicates the hard-to-find paint code for the rear hatch area of the vehicle. The technician is to use paint code wa167a to paint these areas.
• 10082861Aug 2, 2016Electrical system. This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. And canada.
• 10082823Aug 2, 2016Engine cooling. This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
• 10082814Aug 2, 2016Engine. This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
• 10082820Aug 1, 2016Engine. This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
• 10126063Jul 12, 2016Engine. This informational bulletin provides information on intake manifold inspection/replacement after severe internal engine damage.
• 10126062Jul 11, 2016Brakes. This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
• 10100822Jul 11, 2016Engine. This informational bulletin provides the technician with what may happen to an engine due to lack of maintenance.
• 10100806Jul 11, 2016Engine cooling. This technical bulletin provides a procedure to replace the valve lifter oil manifold and the lifters to correct the customers concern of engine misfire, tick noise and mil on.
• 10108606Jul 1, 2016Brakes. This technical bulletin provides a procedure to replace either the front or rear rotors for the condition on a pulsation and/or vibration when they apply the brakes.
• 10089121Jun 29, 2016Tires, Equipment. This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
• 10089228Jun 17, 2016Equipment. This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. And canada.
• 10081043Jun 14, 2016Fuel system, Engine. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have rattle or ticking noise that is louder inside the vehicle than outside. The noise may also sound like a lifter tick. If the noise is heard best at the fuel line and the sound will be real loud with a stethoscope. The fuel line will need to be replaced.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10082008Jun 13, 2016Electrical system, Equipment. This technical bulletin provides a procedure to reprogram the radio controller due to a software concern causing the hvac and radio controls to go inoperative.
• 10080702Jun 13, 2016Engine. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have diagnostic trouble code p06dd or no or low oil pressure. Technician will replace timing chain tensioner guide. If oil pump face is damaged and or worn thru replace oil pump. Inspect bearings for damage wear due to debris from oil pump.
• 10089247Jun 10, 2016Equipment. This informational bulletin provides information on the proper use of floor mats.
• 10097195Jun 8, 2016Equipment. This technical bulletin provides a procedure to inspect the air box and air filter seal and replace if necessary to correct a customer concern that the malfunction indicator light (mil) is illuminated due to excessive sand and/or debris entering the air filter box and bypassing the seal of the air filter causing damage to the ho2 sensor and the catalytic converter to become blocked with sand and debris particles.
• 10078432Jun 8, 2016Equipment. This technical bulletin provides a procedure to inspect the air box and air filter seal and replace if necessary to correct a customer concern that the malfunction indicator light (mil) is illuminated due to excessive sand and/or debris entering the air filter box and bypassing the seal of the air filter causing damage to the ho2 sensor and the catalytic converter to become blocked with sand and debris particles.
• 10080682Jun 6, 2016Engine. This preliminary information communication provides information to the technician the some vehicles may have surge misfire feeling sensation during highway steady state driving in manual mode or automatic, typically in 6th, 7th, 8th gear accelerating 1000 to 2500 rpm under load. This is operating as designed. Torque converter clutch slip with condition present, with scan tool technician may monitor plus or minus…
• 10080566Jun 2, 2016Engine. This preliminary information communication provides information to the technician the some vehicles may have surge misfire feeling sensation during highway steady state driving in manual mode or automatic, typically in 6th, 7th, 8th gear accelerating 1000 to 2500 rpm under load. This is operating as designed. Torque converter clutch slip with condition present, with scan tool technician may monitor plus or minus…
• 10081940Jun 1, 2016Brakes. This technical bulletin provides a procedure to replace the brake rotor(s) to correct a customer concern of pulsation and/or vibration when they apply the brakes due to excessive lateral runout.

← All problems reported for the 2014 Chevrolet Corvette