2013 Chevrolet Express Technical Service Bulletins

1,841 technical service bulletins (TSBs) are on record for the 2013 Chevrolet Express. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10083776Aug 2, 2016Electrical system. This preliminary information communication advises the technician on steps to perform to determine if the customer's battery drain concern is being caused by a known concern with bluetooth call transfer operation when exiting the vehicle. If the concern is duplicated at the dealer with the onstar led is still green after the vehicle is turned off and the bluetooth call was disconnected. Dealer should advises that…
• 10082861Aug 2, 2016Electrical system. This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. And canada.
• 10082823Aug 2, 2016Engine cooling. This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
• 10082814Aug 2, 2016Engine. This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
• 10082820Aug 1, 2016Engine. This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
• 10082423Aug 1, 2016Engine cooling. This informational bulletin provides additional information about the def use and treatment of the fluid.
• 10126063Jul 12, 2016Engine. This informational bulletin provides information on intake manifold inspection/replacement after severe internal engine damage.
• 10126062Jul 11, 2016Brakes. This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
• 10100822Jul 11, 2016Engine. This informational bulletin provides the technician with what may happen to an engine due to lack of maintenance.
• 10089090Jun 30, 2016Brakes. This technical bulletin provides a procedure to replace the power brake booster and fluid cooler inlet and outlet hose to correct a condition of brake hydrobooster leaking power steering fluid.
• 10089322Jun 29, 2016Fuel system. 15823 - customer advisory letter. This communication was to inform dealers that a customer mailing was taking place. The letter informs the customers to inspect for leaks or damage to the fuel filler neck line and/or the cargo tank high pressure flex lines. To address this potential condition, customers are instructed to have a certified cng technician inspect the fuel filler neck line and the cargo tank high…
• 10089121Jun 29, 2016Tires, Equipment. This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
• 10081864Jun 28, 2016Fuel system, Equipment. This informational bulletin provides information on compressed natural gas (cng) fuel line inspection and replacement part identification.
• 10089222Jun 22, 2016Tires, Equipment. This informational provides information on slight or mild tire feathering and recommended practices.
• 10089229Jun 20, 2016Electrical system. This informational bulletin provodes information on the gm of canada onstar cellular communication upgrade.
• 10089253Jun 17, 2016Seat belts. This preliminary informational bulletin provides a procedure to reposition the front seat belt latch plate for concerns regarding the seat belt webbing or latch plate coming twisted.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10089247Jun 10, 2016Equipment. This informational bulletin provides information on the proper use of floor mats.
• 10089227Jun 10, 2016Body and structure, Equipment. This informational bulletin provides information on removing the protective film on bumpers for shipping protection.
• 10089201Jun 8, 2016Equipment. This warranty administration bulletin provides policy information on using gm service policies and procedure manual that represent key gm requirements for service operations.
• 10114105May 31, 2016Engine, Electrical system. This informational bulletin provides information on identifying non-GM (aftermarket) engine calibrations for gasoline engines using Tech 2 or GDS 2.
• 10126060May 27, 2016Electrical system. 15801A - Customer Satisfaction Program. This bulletin is being revised to add a note at the beginning of the Service Information section. The 2016 model year GMC Sierra HD vehicle, and an increase in population has also been added. Vehicles equipped with Duramax Diesel Engine (RPO LGH or LML) and Ambulance Upfitter or Fire Truck Upfitter (RPO YF2 or ANM), may have a condition in which the emission control system as…
• 10114101May 25, 2016Wheels. This informational bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening or re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed.
• 10118547May 20, 2016Tires. This informational bulletin provides information on the temporary tire flat spotting condition.
• 10114107May 20, 2016Electrical system. This informational bulletin provides information on service programming system (SPS) errors.
• 10126051May 16, 2016Engine, Electrical system. 15801 - Customer Satisfaction Program. (2012 model year repair suspended) Vehicles equipped with Duramax Diesel Engine (RPO LGH or LML) and Ambulance Upfitter or Fire Truck Upfitter (RPO YF2 or ANM), may have a condition in which the emission control system as designed will limit speed under certain conditions. The EPA has approved General Motor?s request to remove the emission control system speed limitations on…
• 10118546May 16, 2016Equipment. This informational bulletin provides information on a new U.S. dealer special tool loan program.
• 10118545May 16, 2016Electrical system, Equipment. This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10078876May 11, 2016Brakes. This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
• 10078874May 10, 2016Equipment. This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for non - general motors aftermarket accessories installed on the vehicle that can cause these issues.
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10081221May 2, 2016Fuel system. This technical bulletin provides a procedure to inspect and replace necessary fuel components to correct a customer concern of hard start or a no start and dtcs p0087, p0088, p0191 or p128e set caused by the fuel system being contaminated with debris.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10078568May 1, 2016Transmission and drivetrain, Equipment. This informational bulletin provides information on how to inspect the upper valve body to determine the correct rpo usage to correct a concern that after installation of a replacement upper valve body, the transmission may have no reverse and no 2nd gear due to the installation of the incorrect upper valve body.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10083073Apr 26, 2016Electrical system, Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078743Apr 26, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078561Apr 25, 2016Tires, Suspension. This preliminary information bulletin provides a procedure to replace both front suspension springs to correct a customer concern that the front suspension is too low and/or there is excessive front tire wear.
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.
• 10083587Apr 22, 2016Equipment. This preliminary information communication advises the technician to contact the gm technical assistance center for further instructions. The concern is the radio may be unable to save xm favorite stations.
• 10083509Apr 21, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern. The vehicle's xm radio only has xm preveiw channels.
• 10083482Apr 21, 2016Equipment. This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. The vehicle's xm travel link may be inopertive.
• 10078522Apr 20, 2016Equipment. "this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to customer improperly setting the radio volume high enough when the turn-by-turn navigation messages are played. "
• 10078520Apr 20, 2016Electrical system. This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
• 10137764Apr 19, 2016Wheels. 20890 ? Customer Advisory Letter. On these dual rear-wheel vehicles, the rear-wheel lug nuts and studs may be damaged during the removal and attachment process. Damaged lug nuts and studs could result in a loose or detached wheel. This condition may be noticeable during normal vehicle maintenance and torque checks. Customers are being advised to immediately inspect their vehicle's rear-wheel lug nuts and studs for…
• 10083884Apr 19, 2016Equipment. This preliminary information communication advises the technician on the steps for diagnosing the concern. The vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
• 10083484Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.

← All problems reported for the 2013 Chevrolet Express