2016 Chevrolet Impala Technical Service Bulletins

1,293 technical service bulletins (TSBs) are on record for the 2016 Chevrolet Impala. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10138007Nov 23, 2016Equipment. This engineering information bulletin is ending the need for information on vehicles with the condition of a waterleak in the rear compartment.
• 10114848Nov 23, 2016Equipment. This Preliminary Information communication advises the technician how determine if the vehicle is equipped with wireless fidelity. Technician should check the Regular Production Option Code list for (VV4).
• 10114842Nov 18, 2016Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
• 10137989Nov 16, 2016Equipment, Seats. This technical bulletin provides a procedure to install a clip on the head rest j-clip to correct a condition of the head rest material coming loose due to the j-clip not being robust enough to retain the material down.
• 10126331Nov 16, 2016Electrical system, Latches, locks and linkages. 26180 Customer Satisfaction. Certain vehicles, equipped with a remote trunk release (RPO AB5), may have an incorrect fuse value specified for fuse F66 (Trunk Release) on the Engine Compartment Fuse Block cover. Dealers will inspect, and if necessary, replace the fuse and/or fuse block cover.
• 10114831Nov 15, 2016Equipment, Fuel system, Engine. This Preliminary Information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, an out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.
• 10137624Nov 14, 2016Equipment. This warranty administration bulletin provide policy information on the change in product field action customer reimbursement procedure.
• 10137953Nov 10, 2016Equipment. This Technical Bulletin provides a fix to reprogram the radio for vehicles that may experience any of the following conditions: DTC U0184 Set, Radio Inoperative, Blue Screen, AM Clipping Noise, HD On/Off Status Not Retained in Stations, Time Lag on Transitions, No Audio with Internal Amp, Park Assist Symbol Position Wrong in Rear View Camera
• 10137622Nov 10, 2016Visibility (wipers, defrost, mirrors), Body and structure. This Informational bulletin describes warranty part reviews where door glass had chips or scratches.
• 10137616Nov 9, 2016Equipment, Tires. This bulletin contains information for the new tires that the vehicle is equipped with and that they are covered by General Motors against defects in material or workmanship under the New Vehicle Warranty (Base Warranty Coverage). For vehicles within this warranty period, defective tires will be replaced on a pro rata adjustment basis according to the published distance-based schedule.
• 10126325Nov 9, 2016Exterior lighting. 16099 Service Update. Certain vehicles may have a condition in which the Impala driver side stop lamp bulb and Enclave passenger stop lamp bulb could burn out earlier than expected. Dealers will replace the bulb.
• 10138010Nov 7, 2016Engine cooling. This engineering information bulletin is requesting information from the field on vehicles that have the concern of a noisy water pump.
• 10137954Nov 7, 2016Electrical system, Equipment. Side Detection System Message Being Displayed on Driver Information Center - DTC B101E-43 Set
• 10137625Nov 7, 2016Electrical system. This technical bulletin provides information on Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing and the procedures to turn the transport mode message on and off.
• 10137615Nov 7, 2016Equipment, Tires. This warranty administration bulletin provides information on The tires supplied with a new vehicle are covered by General Motors against defects in material or workmanship under the Bumper-to-Bumper New Vehicle Limited Warranty.
• 10114824Nov 7, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to contact General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10137621Nov 4, 2016Equipment, Fuel system. This informational bulletin provides information for maintenance cleaning of the fuel injectors.
• 10137620Nov 3, 2016Fuel system, Equipment. This informational bulletin provides information for maintenance cleaning of the fuel injectors.
• 10114821Nov 2, 2016Equipment. This Preliminary Information communication provides the technician with information on vehicles with navigation radio Regular Production Option Code IO6 or UY4 that defaults to West Virginia instead of Virginia on a manual entry. General Motors engineering is currently working on a solution for this concern.
• 10114819Nov 2, 2016Equipment. This Preliminary Information communication provides information to the technician about vehicles that the radio will turn on unwanted after a key cycle when the radio was shut off before the key was turned off. Dealer should communicate to the customer that we apologize for this inconvenience and that General Motors is working on a solution for this concern.
• 10137949Nov 1, 2016Engine cooling. This technical bulletin provides a procedure for installing fan guards on both driver and passenger seat cooling fans due to the ventilation fans coming into contact with the seat cushion pad causing a noise when in use.
• 10135301Oct 27, 2016Engine cooling. This engineering information bulletin is requesting information from the field on vehicles that have the concern of a noisy water pump.
• 10135240Oct 27, 2016Fuel system. This informational bulletin provides information for maintenance cleaning of the fuel injectors.
• 10119062Oct 25, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will use Global Diagnostic System 2 to review the Firmware Over-the-Air version and the OnStar Customer Identifier and contact General Motors Technical Assistance Center for further assistance.
• 10119061Oct 25, 2016Electrical system. This Preliminary Information communication provides the technician with the steps needed to diagnose and repair a vehicle with Wi-Fi or Bluetooth inoperative or poor performance concern. Technician will need to obtain data from Global Diagnostics Services 2 and call General Motors Technical Assistance Center for further assistance. Technician should be advised that concern only applies to OnStar Wi-Fi Regular…
• 10135290Oct 24, 2016Equipment. This technical bulletin provides a procedure to clear the codes and re-evaluate the XM radio channels to correct a condition of audio muting when listening to some Sirius XM channels but if they change channels they will find others that experience normal audio. This could be due to interference from transmitting sources outside of Sirius XM?s frequency range.
• 10135250Oct 24, 2016Electrical system, Equipment. Original Equipment Batteries Part Number and ACDelco Replacement Battery Approved Warranty Part Numbers
• 10135289Oct 21, 2016Equipment. this informational bulletin provides Information on Using MyBuick, MyCadillac, MyChevrolet, and MyGMC Phone Applications to Control GM Accessory Remote Start Kits.
• 10135251Oct 21, 2016Seats. This technical bulletin provides repair information to correct a customer concern of the driver and/or passenger power seat height stuck in the full-up position, intermittent inoperative seat adjustment or not lowering.
• 10135249Oct 21, 2016Equipment. This informational bulletin provides information on approved warranty part numbers for original equipment batteries
• 10119050Oct 19, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicles voice recognition inoperative for calling Bluetooth phone contacts. Technician will need to Clear All Private Data and repair any phones that were deleted.
• 10119048Oct 18, 2016Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that have noise from the exhaust and / or exhaust odor within the vehicle. Technician may find the left hand catalytic converter pipe cracking near cylinder head mounting flange weld. Technician will need to replace the catalytic converter with latest part number from General Motors Service Parts Operations. General…
• 10135267Oct 15, 2016Equipment. This informational bulletin provides information on the proper ways to remove or replace the key cylinder covers due to somevehicleshavingthe key cylinders hidden during the time of delivery.
• 10135239Oct 13, 2016Equipment. This warranty administration bulletin provide policy information on required operating procedures.
• 10135237Oct 13, 2016Equipment. Battery Testing and Warranty Replacement Requirements (North America ONLY)
• 10135236Oct 13, 2016Electrical system. This warranty administration bulletin provides policy information on the requirements for battery testing and warranty replacements.
• 10135242Oct 12, 2016Electronic stability control. This informational bulletin provides information on Some vehicles may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
• 10135276Oct 10, 2016Electrical system. This technical bulletin provides multiple fixes for a condition of a waiting for update screen appearing on the display, due to either a reprogramming of the hmi module or due to a fuse that needs to be pulled and restarting of the module.
• 10135263Oct 10, 2016Wheels. This Technical Bulletin provides a procedure to add a nut correcting the gap of the upper trim cover to the IP.
• 10135241Oct 9, 2016Fuel system. This informational bulletin provides information on the top tier fuels that are recommended in GM vehicles.
• 10135274Oct 7, 2016Transmission and drivetrain. This Bulletin provides guidelines for Dealers to determine whether or not they need to contact the PQC for an engine, transmission or transfer case assembly replacement and information explaining the PQC process, Global Warranty Management Transaction submission, vehicle repair record retention and proper handling of assembly returns.
• 10135243Oct 7, 2016Equipment. This informational bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before sold (prepping) to the customer.
• 10135247Oct 5, 2016Equipment, Electrical system. The information in this bulletin details the proper configurations for the ignition key, fob, key tags and key rings and applying a QR code sticker or barcode sticker to a key fob.
• 10135244Oct 5, 2016Equipment. This Informational Bulletin provides information for customers to report Missing or Inaccurate navigation Radio Map Disc information.
• 10119015Oct 4, 2016Equipment. This Preliminary Information communication provides information to the technician about vehicles that the radio will turn on unwanted after a key cycle when the radio was shut off before the key was turned off. Dealer should communicate to the customer that we apologize for this inconvenience and that General Motors is working on a solution for this concern.
• 10118917Sep 30, 2016Equipment. This Warranty Admin bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
• 10118916Sep 30, 2016Equipment. This warranty administration bulletin provide policy information on warranty and policy exchange program for electronic products for U.S. and Canada dealers only.
• 10118913Sep 30, 2016Equipment. This warranty administration bulletin provide policy information for courtesy transportation and roadside assistance programs.
• 10118912Sep 30, 2016Equipment. This informational bulletin provides information on return or reimbursement of customer owned CDs, DVDs or Navigation Discs .
• 10118907Sep 30, 2016Tires. This warranty administration bulletin provides information on The tires supplied with a new vehicle are covered by General Motors against defects in material or workmanship under the Bumper-to-Bumper New Vehicle Limited Warranty.

← All problems reported for the 2016 Chevrolet Impala