2015 Chevrolet Silverado 1500 Technical Service Bulletins

1,284 technical service bulletins (TSBs) are on record for the 2015 Chevrolet Silverado 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10075739Jan 20, 2016Engine. Some customers may comment about a rough idle and/or vibration at idle in Drive. This condition may be most noticeable following extended driving, while idling at a stop in Drive. May feel like a lopey or lumpy idle, or may be described as a low idle. This condition will not be present in Park, Reverse, or Neutral. There will not be any DTCs with this concern.
• 10075754Jan 19, 2016Electrical system. Summary to be provided on a future date.
• 10075750Jan 15, 2016Electrical system. Summary to be provided on a future date.
• 10252173Jan 13, 2016Electrical system, Visibility (wipers, defrost, mirrors), Equipment. Radio HVAC IPC Blank Out When Operating A Snow Plow.
• 10246963Jan 13, 2016Equipment. Changing Turn-By-Turn Voice Response To Metric Or English Units
• 10075745Jan 11, 2016Engine cooling. Summary to be provided on a future date.
• 10252172Jan 6, 2016Electrical system, Equipment. Radio Display May Momentarily Flicker When Vehicle Is First Started.
• 10250069Jan 1, 2016Engine cooling. Delayed Engagement After Sitting With Engine Off
• 10250067Jan 1, 2016Equipment. Infotainment System Will Not Return to Media After Bluetooth Call Ends
• 10248432Jan 1, 2016Transmission and drivetrain. Transmission Oil Cooler Line Disconnect
• 10246639Jan 1, 2016Steering. Power Steering Noise or Fluid Leak from Power Steering Pump, Gear or High Pressure Hose During Extreme Low Temperature Conditions
• 10246556Jan 1, 2016Engine cooling. Delayed Engagement After Sitting With Engine Off
• 10252155Dec 21, 2015Equipment. CD Player Inoperative.
• 10250048Dec 1, 2015Back-over prevention (rear camera). Clunking Noise from Front of Vehicle During Turns and/or Bumps
• 10250047Dec 1, 2015Back-over prevention (rear camera). Clunking Noise from Front of Vehicle During Turns and/or Bumps
• 10246535Dec 1, 2015Suspension. Clunking Noise from Front of Vehicle During Turns and/or Bumps
• 10246534Dec 1, 2015Suspension. Clunking Noise from Front of Vehicle During Turns and/or Bumps
• 10201122Dec 1, 2015Steering, Equipment. Greese or Sealant Visible on Steering Gear - Should not be interpreted as Leak
• 10201118Dec 1, 2015Electrical system, Transmission and drivetrain. Recovery Process from a Controller Reprogramming Interruption
• 10201117Dec 1, 2015Equipment, Body and structure. Clunking Noise from Front of Vehicle During Turns and/or Bumps
• 10201115Dec 1, 2015Equipment, Other or unknown. OnStar Voice Fallback Number Update
• 10201107Dec 1, 2015Fuel system. Fuel Odor During Fuel Filling or During Idle, Possible P0442 or P0455 DTC SET
• 10201104Dec 1, 2015Engine. Information on Exhaust fluid range, exhaust fluid quality poor, service exhaust fluid system or service emission system driver information Center Messages
• 10201103Dec 1, 2015Equipment, Engine. Clean Exhaust Filter see owners manual now or cleaning exhaust filter keep driving until message is cleared displayed on DIC, DTC P2463 May be set
• 10201101Dec 1, 2015Equipment. Information on Mounting Points for Pickup Box Accessories
• 10201100Dec 1, 2015Engine, Engine cooling. New Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber
• 10201098Dec 1, 2015Transmission and drivetrain, Engine. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
• 10201097Dec 1, 2015Engine cooling, Engine. Information on Diesel Engine Ticking Noise
• 10190535Dec 1, 2015Visibility (wipers, defrost, mirrors), Electrical system. Information on Inside Rear View Mirror and Camera Loose Some customers may comment that the inside rear view mirror or front camera is loose or that the mirror/camera mounting bracket is loose or has fallen off. If a vehicle is encountered with the above condition, do not attempt to reinstall the bracket onto the windshield. The above listed vehicles have a revised bracket design that is not serviceable. It is…
• 10190521Dec 1, 2015Suspension. Clunking Noise from Front of Vehicle During Turns and/or Bumps Some customers may comment on a clunking noise originating from the front of the vehicle that is more predominant during turns or traveling over bumps. This may be caused by a damaged stabilizer shaft frame bracket. There have been some cases in which the bracket is cracked, as shown. This condition has been found to be the result of insufficient welds…
• 10190506Dec 1, 2015Engine cooling. Information on Exhaust Fluid Range, Exhaust Fluid Quality Poor, Service Exhaust Fluid System or Service Emission System Driver Information Center Messages
• 10190503Dec 1, 2015Engine, Transmission and drivetrain. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
• 10190502Dec 1, 2015Engine cooling. Information on Diesel Engine Ticking Noise
• 10190387Dec 1, 2015Transmission and drivetrain, Electrical system. Recovery Process from a Controller Reprogramming Interruption During service reprogramming of the T87 TCM, some technicians may notice the TCM may fail during the reprogramming event and become unresponsive to the Service Programming System (SPS), unresponsive to the GDS2 tool. This bulletin addresses corrective actions to attempt to recover the module before declaring the TCM as a bad part and replacing. During…
• 10190383Dec 1, 2015Fuel system, Other or unknown. Fuel Odor During Fuel Filling or During Idle, Possible P0442 or P0455 DTCs Set Some customers may comment on a strong fuel odor during fuel filling or during vehicle idle. Cause This may be caused by the fracture or breaking of the gasoline filler neck recirculation line connector Correction If you encounter a vehicle with the above concern, complete the following procedure: 1. Raise the vehicle and visually…
• 10190381Dec 1, 2015Engine cooling. CLEAN EXHAUST FILTER SEE OWNERS MANUAL NOW or CLEANING EXHAUST FILTER KEEP DRIVING UNTIL MESSAGE IS CLEARED Displayed on DIC, DTC P2463 May Be Set
• 10190379Dec 1, 2015Equipment, Engine cooling. New Tool Availability — EN-48974 – EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax® Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber
• 10089570Nov 18, 2015Equipment. 15657 - customer satisfaction program. Certain vehicles equipped with l96 or lc8 engine may have been built without a frame mounted heat shield that is designed to protect the brake lines from the heat emission of the exhaust system. Dealers are to inspect for the presence of the front frame exhaust heat shield and, if missing, install a new heat shield.
• 10075749Nov 10, 2015Brakes, Electrical system. Summary to be provided on a future date.
• 10089569Nov 4, 2015Engine. 15617 - customer satisfaction program. Certain vehicles equipped with a 6.2l (l86) engine and enhanced towing (nht) may have been built with an inner grille not intended for this application. At the trucks advertised towing capacity of 17,700 lbs. (8,025 kg.), engine coolant and engine oil temperatures may exceed design intent. There is no engine oil temp monitoring or customer warning.
• 10190533Nov 1, 2015Steering. Grease or sealant visible on steering gear - should not be interpreted as leak. Some customers or technicians may comment on seeing grease or sealant on certain locations of the steering gear. The illustrations below include arrows showing the areas on the steering gear that the supplier intentionally applies sealing grease. Any of these locations have the potential of showing visible grease under normal operation.
• 10072092Nov 1, 2015Engine. Summary to be provided on a future date.
• 10126401Oct 30, 2015Body and structure. This informational bulletin provides information on the PQC assembly replacement process - for dealers required to contact PQC prior to replacing an assembly (U.S. and Canada only).
• 10126418Oct 27, 2015Engine cooling. 15766 - Customer Satisfaction Program. Certain 2015 model year Chevrolet Silverado HD and GMC Sierra HD model vehicles equipped with the Duramax Diesel 6.6L Engine (RPO LML) may exhibit engine harness chafing on the EGR stud. Dealers are to inspect the harness for damage, reroute the harness, and install a clip onto the EGR stud.
• 10126395Oct 27, 2015Engine cooling. This informational bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
• 10126417Oct 26, 2015Electrical system. 15038 - Dealer Message Only - Not a Field Action. Select 2015 model year vehicles will receive a software download via OnStar® to update the software for the Electronic Climate Control (ECC) system. This over-the-air update is being piloted on a few hundred customer vehicles in the mid-October thru mid-December timeframe. Pending the successful completion of the pilot, rollout to the general vehicle population will…
• 10126393Oct 26, 2015Equipment. This warranty administration bulletin provides policy information on an updated warranty and policy exchange program for electronic products through GM authorized Electronic Service Centers (ESCs) (U.S. and Canada).
• 10126386Oct 22, 2015Body and structure. This preliminary informational bulletin adds the 2016 model year to repair information to correct a customer concern of the hood fluttering, vibrating or displaying visible motion at highway speeds or over rough road surfaces.
• 10126385Oct 22, 2015Electrical system, Equipment. This preliminary informational bulletin adds the 2014 - 2016 model years to cleaning information to correct a customer concern of seeing a white film/residue on the IP pad and/or door trim panels.
• 10126384Oct 22, 2015Brakes. This preliminary informational bulletin adds the 2015 Chevrolet Colorado and GMC Canyon to diagnosis and repair information to correct a customer concern of alleged no park, vehicle rolls in park or park will not hold.

← All problems reported for the 2015 Chevrolet Silverado 1500