2021 Chevrolet Silverado 1500 Technical Service Bulletins

1,464 technical service bulletins (TSBs) are on record for the 2021 Chevrolet Silverado 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10231660Jan 24, 2023Back-over prevention (rear camera). This Preliminary information communicates information to the technician that if they receive a vehicle with this concern and verifying the rear view camera is zoomed in, General Motors is aware of this and working on a solution for the concern.
• 10231514Jan 24, 2023Engine cooling, Electrical system. This technical bulletin provides repair information to correct a customer concern of Charge Air Cooler (CAC) Icing, Check Engine Lamp Illuminated, Possible P0299, P2227, and/or P0300 DTCs Set.
• 10231500Jan 24, 2023Engine cooling. This technical bulletin provides a procedure to seal the exhaust at the UFSCR and Tailpipe flange.
• 10231651Jan 20, 2023Equipment. This Preliminary information communicates Some customers may comment that the SES lamp is illuminated or was Illuminated and turned off, with no driveabilty concerns. During inspection Technician may notice DTC P2635. Unknown at this time engineering is working on this concern
• 10231487Jan 20, 2023Transmission and drivetrain. This informational bulletin advises the technician of a possibly noise coming from the transmission oil pump.
• 10231365Jan 20, 2023Engine cooling. This service bulletin provides a service procedure to correct a condition of a Ticking Noise from the Engine.
• 10231364Jan 20, 2023Latches, locks and linkages. This service bulletin provides information for dealers/technicians on the process to disable and enable passive unlocking.
• 10231302Jan 20, 2023Equipment. This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only).
• 10231486Jan 19, 2023Engine cooling, Fuel system. This technical bulletin provides a procedure to replace the fuel feed line if found the cause of the failure which set the DTC.
• 10231427Jan 19, 2023Electrical system, Transmission and drivetrain. This informational bulletin advises the tech to inspect the transfer case motor electrical connectors for possible damage or corrosion that might be caused by a damage grommet inside the electrical connector.
• 10231650Jan 18, 2023Visibility (wipers, defrost, mirrors). This Preliminary information communicates an issue with poor a/c performance and to replace the a/c condenser.
• 10231649Jan 17, 2023Visibility (wipers, defrost, mirrors). This Preliminary information communicates an issues will low or poor heater performance on the drivers side. Dealers are to inspect the HVAC temperature door linkage and if ok replace the heater core.
• 10231646Jan 17, 2023Back-over prevention (rear camera), Electrical system. This Preliminary Information communication provides information to the technician about vehicles that are found to have a back-up alarm inoperative during the Pre-Delivery Inspection. On trucks equipped with the Back Up Alarm (RPO 8S3), the alarm will be intentionally left disconnected from the assembly plant. Technician will reroute the harness and plug it in.
• 10231374Jan 17, 2023Equipment. This warranty administration bulletin provides policy information requirements applicable to key fob replacement under the New Vehicle Limited Warranty or under a Replacement Parts Warranty on 2017-2022 and newer model year vehicles with RPO ATH and AVJ.
• 10231643Jan 13, 2023Engine cooling. This Preliminary information communicates to the dealers information related to a Malfunction Indicator Lamp (MIL) Illuminated During Cold Ambient Temperatures with DTCs P30C3 and/or P30BF P30C7 P30CB Setting.
• 10230613Jan 13, 2023Fuel system, Electrical system, Engine cooling. This technical bulletin provides a procedure to replace the fuel injector and the wiring harness to correct a customer concern of Malfunction Indicator Lamp (MIL) Illuminated with DTC P0201, P0202, P0203, P0204, P0205, P0206 and/or P0216 Set.
• 10230612Jan 13, 2023Electrical system. This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.
• 10231640Jan 12, 2023Electrical system. This Preliminary information communicates diagnostic tips when trying to root cause a SES MIL with DTC's B2B0D and B2B0E. Main cause is aftermarket electrical devices spliced into the ignition main fuses.
• 10230609Jan 12, 2023Transmission and drivetrain. This service bulletin provides a repair procedure to correct a customer concern of Delayed and/or Harsh Engagement of Transmission Shift After Vehicle Sitting with Engine Off.
• 10230608Jan 12, 2023Transmission and drivetrain. This Technical bulletin provides a repair to correct a condition of Shudder/Surging While Driving.
• 10230611Jan 11, 2023Engine cooling, Electrical system. This technical bulletin provides a procedure to locate a possible short in the engine wiring harness.
• 10231632Jan 9, 2023Fuel system. This Preliminary Information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle. The bump clunk issue may be due to fuel movement in the fuel tank when not completely full. The condition is eliminated after completely filling…
• 10230603Jan 6, 2023Engine cooling, Electrical system. This service bulletin provides information for U.S. dealers ONLY to refer to the Battery Maintenance Report to identify vehicles in dealer inventory that require attention.
• 10230601Jan 6, 2023Electrical system, Transmission and drivetrain. This service bulletin provides information for the technician that may experience a condition when after performing a DTC Clear/Reset on the TCM during diagnosis or after completion of a transmission repair or replacement, the DTCs did not clear or appear to reset on the next engine start.
• 10228951Jan 6, 2023Engine cooling. Service Update. Certain vehicles may have a condition in which ice or sludge can accumulate in the Charge Air Cooler (CAC) or Closed Crankcase Ventilation (CCV) system when driving in extremely cold weather conditions (-18°C (0°F) or less). Dealers will install a radiator air front lower baffle and, if necessary, reprogram the Engine Control Module.
• 10231625Jan 5, 2023Engine cooling. This Preliminary information communicates in temperatures below freezing, it may be noticed that exhaust is only exiting from the right hand exhaust tailpipe. The cause of this condition is a low point in left side tailpipe which results in condensation building up at the low point in the tailpipe. In low temperatures the condensation can freeze and form ice limiting the flow of exhaust out of the left tailpipe.
• 10230604Jan 4, 2023Wheels, Transmission and drivetrain. This technical bulletin provides a procedure to replace the front wheel drive shaft if found the cause of the custmers concern.
• 10228912Dec 23, 2022Wheels. This service bulletin provides information on Dealer Installed LPO Wheel Installation and Return Process.
• 10228907Dec 21, 2022Transmission and drivetrain. This service bulletin provides a diagnostic procedure to aid in correcting a customer concern of a Howling, Whining/Whirring Noise, Shudder/Vibration and/or Grinding Noise While in 4HI, 4HI Auto and/or During Parking Lot Maneuvers in Auto Mode.
• 10228906Dec 21, 2022Equipment. This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
• 10228909Dec 20, 2022Transmission and drivetrain. This informational bulletin advises the tech to check if the trans cooler lines are twisted which may cause the customers concern.
• 10230697Dec 15, 2022Visibility (wipers, defrost, mirrors). This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related components. That any of the listed DTC's may set with or without poor engine performance.
• 10228893Dec 15, 2022Electrical system, Equipment, Engine cooling. This bulletin provides a procedure to program the BCM to correct the customers concern of RKE idle Time-out.
• 10230695Dec 14, 2022Equipment. This Preliminary information communicates information on how dealers can contact the supplier for Associated Accessories offered through GM.
• 10228888Dec 14, 2022Engine cooling. This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
• 10228886Dec 14, 2022Engine cooling. This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
• 10228863Dec 13, 2022Engine cooling, Transmission and drivetrain. This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle service record retention and proper handling of assembly returns for Canadian Dealers only.
• 10230691Dec 12, 2022Forward collision avoidance. This Preliminary information communicates a "Forward Collision System Reduced" message displayed on the DIC when the Forward Automatic Braking has been set to the "Alert" setting. This is normal when the FAB has been set to "Alert".
• 10228901Dec 12, 2022Electrical system, Equipment. This service bulletin provides repair information to correct a customer concern of Rear View Camera Display Gridlines Dim.
• 10228229Dec 9, 2022Suspension. This engineering information (EI) closure ends the need for gathering information from technicians in regards to the front upper control arm ball joint separated from the socket.
• 10227798Dec 8, 2022Engine cooling, Electrical system. This technical bulletin provides repair information to correct a customer concern of Engine Wire Harness Chafing.
• 10228192Dec 7, 2022Equipment. This service bulletin provides information about GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period.
• 10230685Dec 6, 2022Engine cooling. This Preliminary information communicates to dealers? information related to a Malfunction Indicator Lamp (MIL) Illuminated due to a U0672 setting. Advises the technician to perform Electric Engine Coolant Pump connection inspections. To clear the code to see if it resets current. If the code resets it advises to utilize Strategy Based Diagnosis. If the code does not reset, it advises to release the vehicle to the…
• 10228226Dec 6, 2022Brakes. This service bulletin provides information to dealership personnel that after performing a brake inspection, brake pad replacement, or any other repair that requires the caliper piston to be reseated may be causing DTC C05B0 to falsely set for eBoost applications.
• 10230684Dec 5, 2022Electrical system. This Preliminary information communicates to the dealers information related to a Malfunction Indicator Lamp (MIL) Illuminated During Cold Ambient Temperatures with DTCs P30C3 and/or P30BF P30C7 P30CB Setting.
• 10230683Dec 5, 2022Equipment, Electrical system. This Preliminary Information communication provides information to the technician that General Motors Technical Assistance Center may ask for Global Diagnostic System 2 Session Log. Technician will need use Global Diagnostic System 2 to send the session logs to General Motors Technical Assistance Center for further assistance on the vehicle in question.
• 10228225Dec 5, 2022Transmission and drivetrain. This service bulletin advises the technician that the possible cause may not be from a faulty clutch piston or extension housing and to perform testing on transmission for possible other issues, but it still may be possible on high mile vehicles that orifices in housing may have come dislodged, causing the same customer concern.
• 10230682Dec 2, 2022Equipment, Electrical system. This Preliminary Information communication provides information to the technician that General Motors Technical Assistance Center may ask for Global Diagnostic System 2 Session Log. Technician will need use Global Diagnostic System 2 to send the session logs to General Motors Technical Assistance Center for further assistance on the vehicle in question.
• 10227401Nov 30, 2022Equipment, Electrical system. This service bulletin provides diagnostic/repair information to correct a customer concern of Cellphone not Charging or USB Receptacle Inoperative.
• 10227398Nov 30, 2022Transmission and drivetrain. This Technical bulletin provides a repair to correct a condition of Shudder/Surging While Driving.

← All problems reported for the 2021 Chevrolet Silverado 1500