2016 Chevrolet Silverado 2500 Technical Service Bulletins

1,780 technical service bulletins (TSBs) are on record for the 2016 Chevrolet Silverado 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10111711Dec 12, 2016Equipment. This Preliminary Information communication provides information to the technician about vehicles that have installed an aftermarket bed cap or topper may question where they can wire in the center high mounted stop light for the cap or topper. Provisions for the center high mounted stop light have been provided at the Rear Body Junction Block (X63A) connector X6 terminal 1 for 2014-2015 model years.
• 10111709Dec 12, 2016Engine, Electrical system. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that have a no crank or a start and then immediate stall, Service Engine Soon Malfunction Indicator lamp may not be on when the ignition is in the run position. Technician may find Diagnostic Trouble Codes P0513 and or P262B may also be set. Technician will pulled the driver sill plate and…
• 10111708Dec 12, 2016Engine. This Preliminary Information communication provides information to the technician how to diagnose and repair vehicles that may have fuel gauge that shows empty and the low fuel level indicator is on. Technician will find Diagnostic Trouble Code P2636 will be set in the Engine Control Module. Technician will need to install (Y) Fuel Tank Fill Vent hose. Technician will need to remove the original fuel balance pump…
• 10111705Dec 12, 2016Steering. This Preliminary Information communication provides information to the technician on vehicles that may have an intermittent high idle. If a technician has duplicated, or the customer description aligns with the speeds mentioned in the idle speed description tables, the idle speed should be considered a normal characteristic of current vehicle design.
• 10111743Dec 9, 2016Suspension. This informational bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
• 10111740Dec 9, 2016Equipment. This bulletin contains information for the new tires that the vehicle is equipped with and that they are covered by General Motors against defects in material or workmanship under the New Vehicle Warranty (Base Warranty Coverage). For vehicles within this warranty period, defective tires will be replaced on a pro rata adjustment basis according to the published distance-based schedule.
• 10111741Dec 7, 2016Equipment. This informational bulletin provides information for dealers/technicians on when and how to submit a field product report.
• 10111758Dec 6, 2016Transmission and drivetrain. This technical bulletin provides a procedure on how to test and perform a clutch learn procedure to correct delayed clutch engagement.
• 10111742Dec 5, 2016Equipment. This warranty administration bulletin provide policy information for GM dealer empowerment program and goodwill procedures.
• 10111696Dec 1, 2016Electrical system. This Preliminary Information communication provides information to the technician to help converting vehicles to fleet key option Regular Production Option Code 6E2 or 6E8. Technician will need to check the Regular Production Option Code for 6E2 or 6E8. Technician will need to order the correct key part number per the Regular Production Option Code. Then the technician will need re-code the lock cylinders to match…
• 10111694Dec 1, 2016Electrical system. This Preliminary Information communication provides information to the technician about the Upfitters questions about installing aftermarket electrical accessories. Dealer should reference the latest version of General Motors Upfitter Integration Bulletin 115 for this information. It can be found at http://www.gmupfitter.com.
• 10111693Dec 1, 2016Exterior lighting. This Preliminary Information communication provides information to the technician of the snow plow headlamps inoperative after switching from the factory headlamps to the snowplow headlamps. There may be a diagnostic trouble code B2575 and or a B2699 set in the body control module. Technician is to refer to the latest version of the General Motors up-fitter integration bulletin 116 for additional information these…
• 10138009Nov 30, 2016Equipment. This engineering information bulletin ends the need for information from the field on vehicles that have the condition of the Air bag light illuminated and SIR codes set within the SIR module.
• 10114858Nov 30, 2016Equipment, Wheels. This Preliminary Information communication provides information to the technician about removing the tinnerman push nuts when installing the accessory 22" 6-Spoke Split Chrome Wheels Regular Production Option Code (SEU) or during any service requiring wheel removal.
• 10114857Nov 30, 2016Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a poor Heater-Vent-Air Conditioning air flow from the passenger side far right dash vent when compared to the other dash vents. Technician will need to remove the Heater-Vent-Air Conditioning air distributor duct. Technician can now cut out the portion of the deflector to increase air flow.
• 10114855Nov 30, 2016Latches, locks and linkages. This Preliminary Information communication provides information to the technician about owners that want the auto door lock disabled. There is no avalible setting or Body Control Module calibration to turn off the auto door locks.
• 10114854Nov 30, 2016Electrical system. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that have a click, rattle or a squeak nose coming from the dash. Technician will use Service Information to locate the Accessory AC and DC Power Control Module located to the right of the steering column. Remove the power inverter module and apply two sided tape to the module bracket to insulate…
• 10114853Nov 30, 2016Equipment. This Preliminary Information communicates New model features of the 2016 and 2017 Silverado and Sierra eAssist.
• 10114852Nov 30, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicles voice recognition inoperative for calling Bluetooth phone contacts. Technician will need to Clear All Private Data and re-pair any phones that were deleted.
• 10114851Nov 30, 2016Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a Harsh Shift 1/2 and 2/3 and Sputter Applying Throttle Between 0 and 30%, Rough idle. Technician may find Diagnostic Trouble Codes P0101, P0171, P0172, P0174, and or P0175. Technician should inspect for cast flashing near the Mass Air Flow sensor as seen below.
• 10114850Nov 30, 2016Steering, Visibility (wipers, defrost, mirrors), Electrical system, Electronic…. This Preliminary Information communication provides information to the technician about vehicles that may have any of these concerns remote keyless entry, passive Entry and Start Inoperative, No Fob detect message on driver information center, service tire pressure system, no audio, touch screen Inoperative, Steering Wheel Controls Inoperative, Service Stabilitrak, rear power windows inoperative, rear wiper…
• 10137996Nov 29, 2016Electrical system, Forward collision avoidance, Equipment. This technical bulletin provides a procedure to reprogram the FVCM if the battery has issues that are related to the front camera module.
• 10137956Nov 29, 2016Transmission and drivetrain, Equipment. This technical bulletin provides a procedure to flush and drain fluids for the transmission to eliminate a shake and/or shudder during a light throttle acceleration between 48 and 104 KM/H (30 and 65 MPH) at a steady state.
• 10138006Nov 23, 2016Equipment. This engineering information bulletin is ending the need for information on vehicles with the condition of Vehicle Crank with No Start or Stalling with DTC P0011 and/or P00C6 Set.
• 10114848Nov 23, 2016Equipment. This Preliminary Information communication advises the technician how determine if the vehicle is equipped with wireless fidelity. Technician should check the Regular Production Option Code list for (VV4).
• 10138001Nov 21, 2016Body and structure. This preliminary informational bulletin adds the 2016 model year to repair information to correct a customer concern of the hood fluttering, vibrating or displaying visible motion at highway speeds or over rough road surfaces.
• 10114842Nov 18, 2016Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
• 10114840Nov 18, 2016Seats, Electrical system. This Preliminary Information communication provides information to the technician only to provide additional tips when diagnosing a front heated seat concern and is not meant to be a diagnostic flow chart or replace Service Information. Always, perform and refer to Service Information for the latest diagnostic information and procedures. Trucks equipped with heated and cooled seats Regular Production Option Code…
• 10114839Nov 18, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have Trailer connection not recognized or ?Check Trailer wiring? or ?Service Trailer Brake? message. Technician may find Diagnostic Trouble Codes C1112, C1113, C1114, C111B, U1556, and/or U1505. Technician will need to inspect the Trailer Brake Power Module connector for corroded terminals and replace as necessary.
• 10137951Nov 17, 2016Transmission and drivetrain, Equipment. Delayed Engagement After Sitting With Engine Off - Torque Converter Fluid Drain Back
• 10137990Nov 16, 2016Equipment, Body and structure. This informational bulletin provides information to dealership personnel regarding formulation of a lighter variant paint being made available in order to match the paint on trucks exhibiting a lighter color due to mis-application at the plant.
• 10137617Nov 16, 2016Engine cooling, Equipment. This informational bulletin provides information on higher then expected oil consumption.
• 10114835Nov 16, 2016Brakes, Transmission and drivetrain, Vehicle speed control. This Preliminary Information communication provides information to the technician on the step to diagnose and repair the vehicles that may have a shake or shudder during light throttle acceleration, between 30 and 65 miles per hour steady state driving. Also shudder feeling that may be described as driving over rumble strips or rough pavement. Technician will need to run the vehicle in three different operational…
• 10114834Nov 16, 2016Steering. This Preliminary Information communication provides information to the technician on the steps to diagnosis and repair steering that feels loose or has excessive play. This concern could be caused by the Pitman Shaft Over-Center Preload Adjustment becoming misadjusted. Technician will need to replace the steering gear pitman arm shaft with an updated design.
• 10114831Nov 15, 2016Equipment, Fuel system, Engine. This Preliminary Information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, an out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.
• 10114830Nov 15, 2016Transmission and drivetrain, Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have harsh concerns. Technician are advised to use GDS2 software to confirm which shift is causing the concern. On low mileage vehicles technician are instructed to perform a drive learn procedure. On higher mileage vehicles technicians are instructed to remove the transmission fluid pan and inspect for debris.
• 10114829Nov 15, 2016Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that have an exhaust leak, noisy exhaust, or noise mid-vehicle. Technician will need to check for an unseated pipe to pipe mid-joint connection. Technician will need to install new exhaust band.
• 10138013Nov 14, 2016Engine cooling. This engineering informational bulletin is requesting information from the field on vehicles that have the condition of a MIL or a engine misfire due to a loose spark plug wire.
• 10137624Nov 14, 2016Equipment. This warranty administration bulletin provide policy information on the change in product field action customer reimbursement procedure.
• 10137953Nov 10, 2016Equipment. This Technical Bulletin provides a fix to reprogram the radio for vehicles that may experience any of the following conditions: DTC U0184 Set, Radio Inoperative, Blue Screen, AM Clipping Noise, HD On/Off Status Not Retained in Stations, Time Lag on Transitions, No Audio with Internal Amp, Park Assist Symbol Position Wrong in Rear View Camera
• 10137622Nov 10, 2016Visibility (wipers, defrost, mirrors), Body and structure. This Informational bulletin describes warranty part reviews where door glass had chips or scratches.
• 10137616Nov 9, 2016Equipment, Tires. This bulletin contains information for the new tires that the vehicle is equipped with and that they are covered by General Motors against defects in material or workmanship under the New Vehicle Warranty (Base Warranty Coverage). For vehicles within this warranty period, defective tires will be replaced on a pro rata adjustment basis according to the published distance-based schedule.
• 10114825Nov 8, 2016Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have harsh shifts concerns. Technicians will use Global Diagnostic System 2 software to confirm which shift is causing the concern. On low mileage vehicles technician are instructed to perform a drive learn procedure. On higher mileage vehicles technicians are instructed to remove the transmission fluid pan and…
• 10138008Nov 7, 2016Equipment. This engineering informational bulletin is requesting information from the field on vehicles that have the condition of the rear view camera is inoperative.
• 10137625Nov 7, 2016Electrical system. This technical bulletin provides information on Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing and the procedures to turn the transport mode message on and off.
• 10137615Nov 7, 2016Equipment, Tires. This warranty administration bulletin provides information on The tires supplied with a new vehicle are covered by General Motors against defects in material or workmanship under the Bumper-to-Bumper New Vehicle Limited Warranty.
• 10114824Nov 7, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to contact General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10137621Nov 4, 2016Equipment, Fuel system. This informational bulletin provides information for maintenance cleaning of the fuel injectors.
• 10137620Nov 3, 2016Fuel system, Equipment. This informational bulletin provides information for maintenance cleaning of the fuel injectors.
• 10137619Nov 2, 2016Equipment, Fuel system. This Informational Bulletin provides information on availability of Diesel Fuel additives.

← All problems reported for the 2016 Chevrolet Silverado 2500