2007 Chevrolet Silverado 3500 Technical Service Bulletins

497 technical service bulletins (TSBs) are on record for the 2007 Chevrolet Silverado 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10247065Sep 1, 2012Suspension. Stabilitrak/Traction Control OFF With Red Brake Warning Lamp
• 10245343Sep 1, 2012Suspension. Rattle Squeak Clunk Bump Noise From Front Suspension.
• 10245288Sep 1, 2012Electronic stability control. Unwanted Stability Activation And/Or C0710.
• 10022691Feb 1, 2012Brakes. Gmc: unable to communicate with the ebcm dtc u0121. *nj vehicles equipped with jl4. Updated 9/30/08. *pe updated 6/27/11. *pe updated 4/6/12.
• 10043504Jan 1, 2012Electrical system. Gmc/chevrolet: see docuemtn search button for owner letter. Auxiliary battery feed may cause fusible link to melt and open circuit to prevent damage or fire in wiring harness, due to electrical over load.
• 10037184Oct 1, 2011Seat belts. Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11.
• 10038984Apr 1, 2011Transmission and drivetrain. Gm: some vehicles may have transmission fluid leaking from the coolant lines in cold temperatures.
• 10022671Apr 1, 2011Steering. Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011.
• 10021022Nov 1, 2010Tires. P245/70r17 general ameritrac tire wear vibration. *kb updated 12/13/07. *nj updated 1/30/08. *nj updated 5/25/11.
• 10037129Oct 1, 2010Brakes. Gm: during brake inspections there have been some hairline cracks on the brake pads.
• 10034364Jan 1, 2010Engine cooling. Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined).
• 10028753Feb 1, 2009Air bags, Transmission and drivetrain. General motors: engine running with key off, continuous run; sensing diagnostic module (sdm), no communication, service air bag light illuminated (install diode to solenoid/relay).
• 10017214Dec 1, 2008Engine cooling. Hard start / no start outside temperatures below freezing. *tt updated 7/13/09.
• 10028485Nov 1, 2008Fuel system. General motors: the fuel gauge being inaccurate and the ses mil illuminated. Could be caused by the rear tank sender float arm contacting the side of the fuel tank or fuel filler spud inside the tank. (chassis cab)
• 10025303Oct 1, 2008Engine cooling. Chevrolet service campaign: see document search button for owner letter. Ecm eeprom - reprogram ecm. All 2007 and certain 2008 cheverolet silverado and express and gmc sierra and savana equipped with 6.6l duramax va diesel (rpo lmm - vin 6) engine. Csc was received. *pe updated 5/5/09. Csc letter was received.
• 10026149Aug 1, 2008Transmission and drivetrain. Gmc: flare and or harsh 2-3 shifts. This condition may be caused by leaking 1-2-3-4 and 3-5-r clutch fluid seal rings (230). Models cadillacs, chevrolets, gmc, hummers, pontiacs. Equipped with 6l80 (rpo myc) or 6l90 (rpo myd) automatic transmission.
• 10020883Jul 1, 2008Brakes, Equipment. Service stability lamp diagnostic trouble code (dtc) c0561. *kb updated 9/30/08.
• 10026794Jun 1, 2008Fuel system. Gmc: ses mil with dtc p1682. If normal diagnostic does not lead to correction, this concern could be caused by the rear fuel tank sender assembly being mispositioned. It could give an improper fuel level reading to the ecm. *pe updated 3/19/09.
• 10021415Jun 1, 2008Electrical system. Fuel gauge erratic in freezing temperatures p0463. *kb with one of the following engine rpo's: ly2, ly5, ly6. Lh6, l76, l92. Updated 1/30/08. *nj updated 12/5/08.
• 10021013May 1, 2008Suspension. Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08.
• 10020722May 1, 2008Air bags. Passenger side airbag door does not flush with dash pad/warped. (reposition locking tabs on airbag panel). *kb updated 10/5/07. *nj updated 9/12/08.
• 10023654Mar 1, 2008Transmission and drivetrain. Chevrolet gmc service campaign: see document search button for owner letter. Front axle vent tube kinked - fluid leak. *nj csc was received. Updated 4/24/08.
• 10020881Dec 13, 2007Air bags. Air bag indicator light is on. *kb updated on 12/13/07.
• 10022592Dec 1, 2007Engine cooling. Duramax diesels with ses light and dtc p0402. *kb updated 2/27/08.
• 10021081Dec 1, 2007Tires. Tire sidewall irregularities. *kb updated 1/30/08.
• 10022262Nov 1, 2007Tires. Tire pressure monitor system concerns. *kb 2008 passenger cars and trucks (including saturn). Updated 2/26/08.
• 10023215Oct 1, 2007Fuel system. Ei07239 - 5.3l, lmg, lc9 driveability symptoms, hesitation, miss, lack of power, dtc p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307, p0308, p0171, p0172, p0174, p1174, p1175, check engine light, mil, injector. *nj updated 2/19/08.
• 10023212Oct 1, 2007Equipment. Ei07264 - manual hvac performance, temperature, mode, a/c does not cool, dtc b0228, b0413, b0423, b0433, b3779, b3782 *nj updated 2/15/08.
• 10021847Oct 1, 2007Other or unknown. Procedure for installation of an aftermarket trailer brake controller in lieu of factory installed integrated trailer brake controller. *kb updated 11/02/07. *nj updated 2/19/08.
• 10022768Sep 26, 2007Electrical system. Auxiliary power to 7-way trailer connector.
• 10023221Sep 1, 2007Electrical system. Various electrical concerns - intermittently functioning or inoperative component, ip warning light on, dic message displayed, dtc set, no crank/start (repair ip wiring harness)
• 10023211Sep 1, 2007Exterior lighting. Use of auxiliary center high mounted stop lamp (chmsl) with installation of accessories overhead rack system.
• 10021448Sep 1, 2007Engine cooling. Intermittent low battery voltage, engine will not crank, engine cranks but will not start, charging system light on, service battery charging system message displayed, dtc b1405 and/or b1516 set. (reprogram bcm). *kb updated 11/02/07
• 10020953Sep 1, 2007Electrical system. Information on auxiliary power wire at trailer and installation of aftermarket trailer brake controller - towing, tow *kb updated 11/02/07.
• 10022363Aug 3, 2007Suspension. Rear axle hop during aggressive braking.
• 10022362Aug 3, 2007Tires. Service tire monitor message with aftermarket wheels. *kb updated on 09/20/07.
• 10022360Aug 3, 2007Transmission and drivetrain. Allison lct1000 harsh 3-2, 2-1 downshift, and abs may activate.
• 10020808Jul 1, 2007Fuel system. Information on 3.5l, 3.9l, and 5.3l e85 fuel compatible vehicles, with alcohol content, switching between gasoline and e85 fuel. *kb updated on 09/19/07.
• 10021939Jun 27, 2007Brakes. Part restriction on the electronic brake control module.
• 10021692Jun 15, 2007Other or unknown. Trailer hitch insert - product update.
• 10021676Jun 15, 2007Transmission and drivetrain. New design front axle side bearing adjusters.
• 10021673Jun 15, 2007Interior lighting. Ipc backlighting inoperative tbc 2a fuse open.
• 10022470Jun 1, 2007Brakes. Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground).
• 10022369Jun 1, 2007Fuel system. Service update for inventory and customer vehicles e85 virtual flex fuel sensor (vffs) update- reprogram ecm.
• 10022536May 1, 2007Other or unknown. Service update for inventory and customer vehicles. Incorrect gvwr and capacity information.
• 10021853May 1, 2007Other or unknown. Installation instructions for e85 flex fuel emblems and yellow colored fuel caps in support of the e85 ethanol marketing program.
• 10021852May 1, 2007Body and structure. Door trim gap at rearof door.
• 10021845May 1, 2007Transmission and drivetrain. 6t70, 6t75, 6l50, 6l80, or 6l90. Automatic transmission - information on transmission fluid pressure (tfp) switch check for false dtc's p0842, p0843, p0872, p0873, p0877, p0878, p0989, or p0990.
• 10021841May 1, 2007Engine cooling. Chuggle, surge or hesitation may be felt with active fuel management system cylinder deactivation transition from v8 mode to v4 mode.
• 10021395Apr 24, 2007Brakes. Adding aftermarket trailer brake controller with integrated trailer brake controller.

← All problems reported for the 2007 Chevrolet Silverado 3500