2004 Chevrolet Silverado Other or unknown Problems

“After reading on several web forums about GM hitch receiver problems, I checked mine and was shocked that all but one weld on my receiver showed signs of rusting. Two were to the point where cracked welds were obvious. The dealer offered to replace it but I did not want a GM hitch so I used another receiver at my expense. I had towed a 7700 pound trailer about 20,000 miles max. Hitch has been disposed of. I have some photos (not very good). It is a 2004 chev, 2500hd, diesel.”

“I recently had a problem with the heater motor in my 2004 chevy Silverado. The heater motor began to make a squealing noise. I took it to the dealership where I purchased it . Mechanics looked it over and I was told the bearing in the heater motor was seizing up ,although the dealership didn't have a new heater motor in stock they were able to get one in a matter of hours. My truck was fixed that same day .I must say I was very impressed and happy with the service I received. Thank you.”

“I own a 2004 chevy Silverado 2500hd. On 11 feb 2005 I noticed some rust on my trailer hitch. I inspected it and found that there is rust around the welds, and that one of the welds is completely cracked. I went to the dealer and was told that the only fix is to re-weld it. I told them that I did not want it welded, I wanted it replaced. This is a warranty item. I feel that if the original robotic welds were not holding, then why weaken the metal more by heating it up again and re-welding it. …”

“There is a rattling transmitted through the steering wheel and heard and felt by the driver. It is especially noticeable during low speed driving as well as when turning or driving over rough terrain. It has been identified by GM in a technical service bulletin (TSB number 06-02-3-0056, issue date 1-20-06, cause inadequate lubrication on steering intermediate shaft) for various years of GM trucks. I believe this is an accident waiting to happen and a recall should be made.”

“1. Noticed transmission slipping over the last few months 2. A few weeks ago, the tail light, right turn signal and cruise control and dash lights started malfunctioning 3. Recently, the paint around rear passenger door and roof is peeling.”