2005 Chevrolet Silverado Engine Problems
- Complaints
- 4about this part
- Share
- 1%of 316 total for the year
- Median mileage
- 120,100miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 4 complaints about the engine of the 2005 Chevrolet Silverado, 1% of the 316 complaints for this model year. Where a mileage was given, the median is 120,100 miles. 1 a fire, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Had to add coolant over a time.....no evidence of a leak on my driveway or any other place. Started truck one morning and heard clicking noise coming from engine. I observed water coming from the muffler. Took vehicle to dealer on april 22, 2014. ( mileage 84241) dealer found blown head gasket and seals, one cracked head and water in oil. Repairs done: complete valve job (replace head gasket, seals & other associated parts), replace broken bolts, replace coolant hoses, radiator & heater hoses and thermostat etc.. …”
NHTSA complaint #10593754, filed 2014-05, 84,192 miles“Parked truck at outside stall and went indoors. After about 20 minutes I heard noises and went outside. Found the whole truck was engulfed in flames. By the time the fire department arrived 6 minutes later the fire spread to two additional vehicles. The heat melted and consumed everything except the frame. The fire investigator suspects the fire initiated due to electrical failure and generated from either the driver side dash board or left side of engine. The damage was too destructive to pinpoint exact cause.”
NHTSA complaint #10474231, filed 2012-09, 130,200 miles“The low coolant light went on. The only way to fill the system is to open the reservoir cap. Unfortunately because the engine had a head gasket failure the cooling system would not depressurize, even when cold. It seems to me that there should be a pressure cap that when the engine overheats it allows the cooling system to depressurize. This closed system is very dangerous especially when someone who is used to filling the overflow tank when the coolant is low. Because the lack of an over flow tank anyone that opens the plastic reservoir could became burned.”
NHTSA complaint #10572825, filed 2014-03, 110,000 miles“The contact owns a 2005 Chevrolet Silverado. The contact stated that while driving at 70 MPH, the check engine warning light illuminated. The contact noticed there was a engine leak and noticed that a few bolts that hold the exhaust pipe were missing. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was not available.”
NHTSA complaint #10747067, filed 2015-08, 135,000 milesRelated service bulletins
- 10112272Jan 14, 2016This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period.
- 10056354Sep 1, 2014Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. Model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500…
- 10112069May 14, 2014This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a Service Engine Soon Malfunction…
Engine: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2017 | 16 | 13% |
| 2015 | 15 | 20% |
| 2014 | 16 | 13% |
| 2013 | 7 | 11% |
| 2012 | 6 | 9% |
| 2011 | 7 | 9% |
| 2010 | 10 | 16% |
| 2009 | 6 | 8% |
| 2008 | 11 | 7% |
| 2007 | 12 | 7% |
| 2006 | 3 | 2% |
| 2005 | 4 | 1% |
| 2004 | 7 | 1% |
| 2003 | 7 | 1% |
| 2002 | 4 | 1% |
| 2001 | 4 | 0% |
| 2000 | 3 | 0% |
| 1999 | 2 | 0% |
| 1997 | 1 | 0% |
| 1994 | 2 | 1% |
Other parts of the 2005 Chevrolet Silverado
87 complaintsElectrical system
64 complaintsTransmission and drivetrain
29 complaintsAir bags
28 complaintsSteering
24 complaintsEngine cooling
20 complaintsSuspension
19 complaintsFuel system
17 complaintsTires
14 complaintsBody and structure
11 complaintsVisibility (wipers, defrost, mirrors)
9 complaintsEquipment
5 complaints
← All problems reported for the 2005 Chevrolet Silverado
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology