2009 Chevrolet Silverado Technical Service Bulletins

276 technical service bulletins (TSBs) are on record for the 2009 Chevrolet Silverado. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10112413Oct 16, 2013Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have multiple electrical concerns and or intermittent no crank. Technician will need to remove the 175 amp Mega Fuse and inspect for arcing. If any type of arcing is found replace the affected components. Technician will also check the voltage drop on the positive and negative and the torque of the cable at the…
• 10112406Oct 15, 2013Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have various 2-Mode Hybrid issues. Some vehicle may have service hybrid system lamp that comes on with a Diagnostic Trouble Code P061B set. Technician will need to take a snap shot of the Electronic Brake Control Module and call General Motors Technical Assistance Center for further assistance.
• 10112401Oct 9, 2013Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. Technician may find Diagnostic Trouble Codes P0701, P0731, P0732, P0733, P0734, P0736, P0751, P0756, P0761, P0776, P0843, P0848, P0873, P0877, P0894 or P2723. Technician should follow published Service Information…
• 10112384Oct 2, 2013Vehicle speed control, Electrical system, Steering. This Preliminary Information communication provides information to the technician with the installation of Cruise Control on a vehicle which did not come equipped with the option. Technician will need to contact the Techline Customer Support Center to determine if a calibration is available for the vehicle. If they are able to provide a calibration for the vehicle then order steering wheel with cruise control…
• 10112382Oct 1, 2013Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician about the percentage of UV protection or tint offered by the windshield or side glass. Technician should be advised Windshield reduces UV rays down to 4% or less. Front side door glass reduces UV rays down to 35% or less. Windshields are SOLAR glass with a light transmittance of >/=70%. Front door glass are Solar glass with a light…
• 10036204Oct 1, 2013Transmission and drivetrain. Chevrolet/gmc: delayed or no drive and delayed or no reverse with dtc's, range inhibit. Model years 2001-2013. *pe updated on 06/08/2011. *kb updated on 06/16/2011. *kb updated 11/26/12. *pe updated 12/4/2013
• 10032396Oct 1, 2013Electrical system. Chevrolet/gmc/cadillac: multiple electrical concerns with dtc c0900 - keywords battery c/k cable clock crank cycle door dimming flicker gage gauge gmc hvac inop inoperative instrument intermittent ipc lock no panel power radio stall start temperature. *pe updated 3/28/11. Model yrs 2007-2009. *pe updated on 6/27/2011 added model yrs 2010-2011. *kb model years added 2012, 2013, and 2014. Updated 12/2/2013
• 10032393Oct 1, 2013Fuel system, Engine cooling, Transmission and drivetrain. Chevrolet/cadillac/gmc: hybrid driveability or customer concerns of flare, slip, stall at a stop, surge, lack of power, poor fuel economy, reduced ev range/limited electric propulsion, dtc p061b after campaign 09102b or dtc p061b prior to campaign. *pe updated 3/14/11. *pe updated 12/4/2013
• 10113254Sep 18, 2013Equipment. This Preliminary Information communication provides information to the technician about the new fluids available for axle service and clarifies usage. Technician will use the chart to determine the proper axle lubricant to use.
• 10053864Sep 1, 2013Steering. Buick/cadillac/chevrolet/gmc/pontiac/ saturn: there is fluid leaking from power steering system, along a fluid leak in front of vehicle underneath and should be inspected, cleaned and identified before repairing or replacing. Model 2010-14 lacrosse, 2011-14 regal, 2007-14 escalade, suburban, tahoe, yukon, yukon xl, yukon denali, yukon denali xl, 2013-14 xts, 2005-14 malibu, 2007-13 avalanche, silverado, sierra…
• 10113506Aug 28, 2013Tires. This warranty administration bulletin provide policy information on GM of Canada New Vehicle Limited Warranty Tire Program and Global Warranty Management (GWM) Submission Information.
• 10113502Aug 26, 2013Equipment, Transmission and drivetrain, Engine cooling, Electrical system…. This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND.
• 10113494Aug 19, 2013Engine cooling, Equipment. This informational bulletin provides information on close-coupled converter and engine replacement.
• 10113492Aug 15, 2013Seat belts. This informational bulletin provides information on availability for the seat belt extender.
• 10113483Aug 5, 2013Tires. This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
• 10059928Jun 28, 2013Equipment, Engine. Summary to be provided on a future date.
• 10113062Jun 25, 2013Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician about an owner that may request to have a different style mirror installed on their vehicle or request a different mirror before they purchase the vehicle. Swapping mirrors on vehicles equipped with Side Blind Zone Alert, Regular Production Option Code UFT, is not recommended. On other vehicles tech will need to verify if the vehicle…
• 10113059Jun 24, 2013Engine cooling. This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a Service Engine Soon Malfunction Indicator Lamp on at low mileage. Technician may find Diagnostic Trouble Codes P0420 and or P0430 stored. Technician should be advised that the catalytic converter efficiency Diagnostic Trouble Codes P0420 and P0430 are disabled for the first…
• 10038344Jun 1, 2013Latches, locks and linkages. Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. The probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. All 2014 and prior gm passenger cars and trucks.
• 10052311May 1, 2013Engine cooling. General motors: low engine oil pressure, no oil pressure, and/or engine noise. This could be the result of a sticking oil pump pressure relief valve.
• 10043887May 1, 2013Steering, Electrical system. Gm: the service stabilitrak message being displayed in dic. The stabilitrak indicator light may also be on. *js updated on 7/9/2013.
• 10112973Apr 16, 2013Equipment. This Preliminary Information communication provides information to the technician about vehicles that for no reason the alarm will go active. Technician will need to use a scan tool to verify that the alarm was activated by the inclination sensor. If the trigger is the inclination sensor, inspect the sensor's mounting location. Technician will need to relocate the sensor if it is attached to the driver's side lower…
• 10112958Apr 5, 2013Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that have low oil pressure, no oil pressure, and/or engine noise. Technician will need to replace the oil pump, flush the oil cooler lines.
• 10112955Apr 4, 2013Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that may have a cold engine tick noise for 50 seconds at start up. Technician determines if the tick noise is possibly coming from the exhaust manifold, as this noise could easily be mistaken for an engine tick noise.
• 10043850Feb 1, 2013Steering. Gmc: hydraulic power steering leak at hose connection to steering rack. All potential leaks should be completely cleaned and indentified before attempting to repair or replace any power steering components. *js updated 4/22/13.
• 10112763Jan 31, 2013Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a cold air leak on the front passenger side while driving. Technician will need to use black RTV silicone and apply over the seam between the upper and lower Heater-Vent-Air Conditioning case halves.
• 10112745Jan 30, 2013Back-over prevention (rear camera), Equipment. This Preliminary Information communication provides information to the technician that during the Pre-Delivery Inspection it may be noticed that the backup alarm is inoperative. Technician can locate the wire harness on the right rear of the frame. Technician can route the harness up and over the spare tire hoist tube and connect to the backup alarm.
• 10112740Jan 25, 2013Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that may have a service 4WD message displayed in the Driver Information Center. Technician may find Diagnostic Trouble Code C0379. Technician will need to inspect the front axle actuator connector for signs of moisture intrusion. If there is corrosion on the terminals at either location replace the actuator and harness.
• 10112737Jan 23, 2013Electrical system. This Preliminary Information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. Dealer should advise the customer the specification for speedometer needle accuracy is +/- 2 miles per hour at any given speed when looking straight at the needle.
• 10112725Jan 16, 2013Engine. This Preliminary Information communication provides information to the technician about vehicles that have misfires on cylinders 1, 4, 6 and 7. Technician should inspect the camshaft part numbers. Technician should ensure to use part number for the application by using the numbers stamped on the cam.
• 10112717Jan 14, 2013Engine cooling, Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a rough idle and/or momentary lack of power after cold starting the engine and immediately placing the transmission in gear. Technician should follow published Service Information diagnostics first. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle.
• 10051760Jan 1, 2013Engine. Chevrolet/gmc: after cold starting engine and placing in gear, would have a rough idle and/lack of power, momentarily before startup a few minutes later. Models 2009-2013 express, silverado, suburban, savana, sierra.
• 10112697Dec 27, 2012Equipment, Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308.
• 10113849Dec 20, 2012Engine cooling. This informational bulletin provides information on the proper oils to use on GM vehicles including information regarding the differences of the Dexos oils.
• 10112690Dec 18, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a compass that's not accurate or slow to update. Technician should check for a magnetic base roof mounted accessory interfering with the compass module.
• 10112688Dec 18, 2012Transmission and drivetrain. This Preliminary Information communication advises the technician that 2ML70 Transmission Assembly will be placed on a parts restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
• 10113843Dec 17, 2012Equipment. This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10112668Dec 13, 2012Exterior lighting. This Preliminary Information communication provides information to the technician about the puddle light operation. Technician should be advised that the puddle lamps to operate, "Approach Lighting" must be turned on using the Drivers Information Center buttons.
• 10112655Dec 12, 2012Wheels, Tires. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10112648Dec 12, 2012Electrical system, Engine cooling. This Preliminary Information communication provides information to the technician about vehicles with a "Service Charging System" message displayed on the Driver Information Center and/or a low voltage reading on the volt gauge during the first several minutes after a cold start. Technician may find a Diagnostic Trouble Code B1517 sym 03. If this concern only occurs during the first several minutes of a cold start…
• 10113837Dec 7, 2012Equipment. This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
• 10113831Dec 4, 2012Equipment. This preliminary information bulletin provides a descritption of operation of the echo control and noise cancellation settings for concernc regarding noice drop outs during calls and muffled sound.
• 10043510Dec 1, 2012Equipment. Cadillac/chevrolet/gmc: original style blower motor assembly is no longer available. A revised hvac blower motor assembly for full size trucks is required, with modifications, to function properly. *pe updated 2/25/13.
• 10112615Nov 29, 2012Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician the steps to diagnose and repair vehicles that have windows inoperative while the engine is running but work when the engine is off. Technician should look for aftermarket parts and remove them and retest the windows before any in depth diagnostics are performed.
• 10112614Nov 29, 2012Equipment. This Preliminary Information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. Dealer should advise the customer starting in 2003 the passenger compartment air filter is no longer available as a factory option.
• 10112613Nov 29, 2012Tires. This Preliminary Information communication provides information to the technician about vehicles with tire sidewall irregularities. This is a visual condition that will not affect durability, reliability or performance of the tires. Dealer should communicate to the customer that slight sidewall indentations are a common characteristic of radial tire construction.
• 10112609Nov 28, 2012Body and structure. This Preliminary Information communication provides information to the technician about vehicles that the customer or up-fitter may have removed the rear bumper, install a different rear bumper, or add a different box/flat bed/cube box/hitch, etc. to the rear of the truck, which affects the rear park assist operation. Technician can disable the rear park assist for this concern.
• 10112606Nov 28, 2012Electrical system, Equipment. This Preliminary Information communication provides information to the technician that customers may inquire as to the availability of OnStar bluetooth on their vehicle. Technician should be advised that Vehicles with Regular Production Option Code (UPF or UWE) offer Bluetooth through the OnStar system.
• 10112603Nov 27, 2012Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a rattle, buzz, tick, or vibration type noise that appears to be coming from the center of the dash. Technician will adjust the transmission dipstick tube away from the front of cowl to provide additional clearance.
• 10112597Nov 21, 2012Fuel system. This Preliminary Information communication provides information to the technician about vehicles that have a buzz or rattle type noise during light acceleration around 1200-2000 Revolutions per minute. Technician will need to reposition the fuel line and bracket down away from the floor pan.

← All problems reported for the 2009 Chevrolet Silverado