2004 Chevrolet Suburban Technical Service Bulletins

606 technical service bulletins (TSBs) are on record for the 2004 Chevrolet Suburban. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10021021Feb 22, 2007Engine cooling. Service vme. Supplement to 00-02-35-003l. Update on new I-shaft.
• 10021019Feb 22, 2007Transmission and drivetrain. Slip condition in 2nd, 3rd, or 4th. Damaged 2-4 or 3-4 clutch. *kb updated 10/31/07.
• 10021015Feb 22, 2007Electrical system. Unable to locate emergency light relay and/or blunt cut wires.
• 10021010Feb 22, 2007Tires. Bridgestone dueler product information update.
• 10012089Feb 1, 2007Steering. Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated.
• 10017373Nov 1, 2006Equipment. Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated
• 10021017Sep 27, 2006Visibility (wipers, defrost, mirrors). Door glass pops out of run channel.
• 10020874Sep 23, 2006Suspension. Left front axle shaft difficult to remove. Axle differential leak seal shaft.
• 10019825May 3, 2006Tires. Service vme - aftermarket wheels/tire pressure monitor/fmvss 138.
• 10019852Mar 1, 2006Suspension. Revised upper control arm replacement.
• 10017462Feb 1, 2006Transmission and drivetrain. 4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission.
• 10014986Feb 1, 2006Brakes. Service stability message on, diagnostic trouble code (dtc) c0131, c0196, c0290 and/or c0292 set.
• 10018926Jan 25, 2006Transmission and drivetrain. 4wd inoperative and possible dtc c0327 stored in the transfer case control module.
• 10018623Jan 9, 2006Visibility (wipers, defrost, mirrors). Front hvac blower inoperative.
• 10018566Jan 6, 2006Visibility (wipers, defrost, mirrors). Front blower inoperative stay running during low ambient temperature.
• 10018544Jan 6, 2006Seats. Heated seat inoperative or shut off in 30 seconds. Diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module.
• 10017310Nov 2, 2005Tires. Service tire pressure monitoring system diagnostics codes.
• 10017308Nov 2, 2005Suspension. Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005).
• 10017299Nov 2, 2005Transmission and drivetrain. Electronic transfer case unable to complete shift.
• 10017277Nov 1, 2005Visibility (wipers, defrost, mirrors). Unwanted operation of rear windows.
• 10011197Nov 1, 2005Suspension. 20 inch wheels and tires available through gmspo. *tt updated.
• 10017196Oct 28, 2005Engine cooling. Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161.
• 10017155Oct 26, 2005Engine cooling. Diagnostic trouble code p0128 or engine will not reach operating temperature.
• 10017145Oct 26, 2005Transmission and drivetrain. 4l80e/4l85e harsh shift or slip no tcc apply.
• 10017132Oct 25, 2005Visibility (wipers, defrost, mirrors). Blower motor inoperative at low ambient temperatures.
• 10017123Oct 25, 2005Visibility (wipers, defrost, mirrors). Service vme-outside rear view mirror inoperative.
• 10017100Oct 24, 2005Transmission and drivetrain. Tcc surge and/or fluid contamination.
• 10017092Oct 24, 2005Brakes. Service brake booster message.
• 10017023Oct 21, 2005Electrical system. Additional diagnostic information dtc p0757.
• 10017015Oct 20, 2005Visibility (wipers, defrost, mirrors). Rear blower turns on by itself/defaults to high blower speed and/or defaults to full cold.
• 10016942Oct 18, 2005Engine cooling. Hard start or extended crank time on initial cold start when using alcohol blended fuels.
• 10016866Oct 13, 2005Tires. Bridgestone dueler product information update.
• 10016821Oct 12, 2005Electrical system. Bulletin-sit-bulletin-1656326: pit3569. Low tire light on and or dic check tire pressure message when cold.
• 10017764Oct 1, 2005Seats. Unwanted/loose seat movement.
• 10017760Oct 1, 2005Engine cooling. Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement.
• 10016714Sep 28, 2005Suspension. Automatic level control inoperative due to water ingestion.
• 10016562Sep 22, 2005Tires. Low tire light on and or dic check tire pressure message when cold.
• 10016560Sep 22, 2005Tires. Check tire pressure message.
• 10016558Sep 22, 2005Transmission and drivetrain. Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm.
• 10016554Sep 21, 2005Brakes. Hoot or squeak type noise on rapid brake apply.
• 10016529Sep 20, 2005Visibility (wipers, defrost, mirrors). Service vme - outside rearview mirror vibration.
• 10015018Sep 1, 2005Equipment. Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital).
• 10017380Aug 1, 2005Seats. Intermittent heated seats inoperative, diagnostic trouble code b3941 set.
• 10017532Jun 1, 2005Tires. Tire pressure monitoring (tpm) system - system messages.
• 10017336Jun 1, 2005Engine cooling. Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300.
• 10014899May 11, 2005Steering. Steering idler arm inspection procedure.
• 10014870May 11, 2005Engine cooling. 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174.
• 10014857May 11, 2005Transmission and drivetrain. Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module.
• 10014853May 11, 2005Transmission and drivetrain. Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation.
• 10017409May 1, 2005Engine cooling. Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder).

← All problems reported for the 2004 Chevrolet Suburban