2015 Chevrolet Suburban Technical Service Bulletins

2,543 technical service bulletins (TSBs) are on record for the 2015 Chevrolet Suburban. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10114353Jan 15, 2015Equipment. This Preliminary Information communication advises the technician the LCT1000 6 Speed Allison automatic transmission is on restriction through General Motors Product Quality Center. Dealer will need to call General Motors Product Quality Center for further assistance.
• 10114352Jan 15, 2015Tires, Wheels. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10114349Jan 15, 2015Electrical system. This Preliminary Information communication provides information to the technician about the wireless charging module has been placed on restriction through the General Motors Technical Assistance Center. Dealer will need to call General Motors Technical Assistance Center for further assistance. Customer may state that the phone does not charge, charges slow, moves out of charging spot, or charges intermittently…
• 10095317Jan 15, 2015Equipment. This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. General motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10095178Jan 15, 2015Transmission and drivetrain. This preliminary information communication advises the technician the lct1000 6 speed allison automatic transmission is on restriction through general motors product quality center. Dealer will need to call general motors product quality center for further assistance.
• 10094964Jan 15, 2015Electrical system. This preliminary information communication provides information to the technician about the wireless charging module has been placed on restriction through the general motors technical assistance center. Dealer will need to call general motors technical assistance center for further assistance. Customer may state that the phone does not charge, charges slow, moves out of charging spot, or charges intermittently…
• 10139415Jan 14, 2015Electrical system. This warranty administration bulletin provides policy information on ACDelco® replacement battery warranty procedures.
• 10139414Jan 14, 2015Equipment. This warranty administration bulletin adds 2012 - 2015 model years to information communicating a change in the product field action customer reimbursement procedure (U.S. Dealers Only).
• 10114345Jan 14, 2015Electrical system. This Preliminary Information communication provides information to the technician on how the radio display gets the air ambient temperature. On 1500 series trucks and all sport utility vehicle with regular production option code IO3 radio the ambient air temperature sensor is hard wired to the engine control module and then the signal goes on high speed local area network to the body control module from there on…
• 10114343Jan 14, 2015Equipment. This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10114342Jan 14, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10095359Jan 14, 2015Equipment. This preliminary information communication provides information to the technician on how the radio display gets the air ambient temperature. On 1500 series trucks and all sport utility vehicle with regular production option code io3 radio the ambient air temperature sensor is hard wired to the engine control module and then the signal goes on high speed local area network to the body control module from there on…
• 10094888Jan 14, 2015Equipment, Electrical system. This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10139412Jan 12, 2015Engine cooling. This informational bulletin supplies infomation for identifying non-GM (Aftermarket) engine calibrations for gasoline engines using Tech 2® or GDS 2 (U.S. and Canada).
• 10139411Jan 12, 2015Equipment. This preliminary informational bulletin provides information that accessory remote start does not work with OnStar RemoteLink? phone application.
• 10139410Jan 12, 2015Equipment. This preliminary informational bulletin provides inspection and repair information that may be helpful to correct customer concerns of XM/Cellular Mobile Phone/OnStar® antenna looseness or damage, XM/Cellular/OnStar® reception performance degraded, rattle/flutter/squeak noise, wind noise/whistle at highway speeds, and/or a water leak on headliner at sunvisor.
• 10139408Jan 9, 2015Equipment. This preliminary informational bulletin provides repair information to correct customer concerns about blank display, NAV screen audio content is unavailable via speech recognition, display screen is stuck on incoming call view after phone call finished, rear view camera display blank, USB issues, Bluetooth/Favorite Bar/Voice, iPod unable to detect via USB, recognition concerns, XM speech recognition inoperative…
• 10139207Jan 9, 2015Equipment, Back-over prevention (rear camera). This preliminary informational bulletin provides repair information to correct customer concerns about blank screen after startup and reverse, rear view camera message on, touch screen inoperable, Bluetooth and navigation concerns.
• 10114337Jan 9, 2015Equipment. This Preliminary Information communication advises the technician before replacing the crankshaft to review the following. Dealer should complete the Service Information diagnostics and the Cost Comparison Worksheet for Assembly Repair vs Replacement. Technician will use the latest version of 09-06-04-026G to verify the ECM calibration is not an Aftermarket calibration. If the customer prefers to KEEP the original…
• 10095185Jan 9, 2015Equipment. This preliminary information communication advises the technician before replacing the crankshaft to review the following. Dealer should complete the service information diagnostics and the cost comparison worksheet for assembly repair vs replacement. Technician will use the latest version of 09-06-04-026g to verify the ecm calibration is not an aftermarket calibration. If the customer prefers to keep the original…
• 10079305Jan 9, 2015Body and structure. 14300a - service update (revised part, service, and warranty information). On vehicles equipped with a power liftgate (tb5/tc2), the power liftgate may have been built with liftgate struts that can lock up and cease to move. If the liftgate strut locks up, the customer may not be able to open or close the liftgate either electronically or manually. Dealers are to replace the liftgate actuator assembly.
• 10139200Jan 6, 2015Engine, Electrical system. This informational bulletin provides information that may be useful in diagnosing/testing batteries that have set for a long period of time and/or set in cold weather climates to correct a customer concern of symptoms that include, but not limited to, a slow or no crank condition that may be caused by a discharged battery.
• 10139199Jan 6, 2015Suspension. This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.
• 10139198Jan 6, 2015Tires. This preliminary informational bulletin provides information that the tire pressure monitor (TPM) sensors must always be re-learned when accessory wheels are installed on the vehicle.
• 10114812Dec 29, 2014Engine. This Preliminary Information communication provides information to the technician about vehicles that the engine may run hot with the snow plow installed. Do not exceed 64?kilometers per hour / 40?miles per hour with a snow plow mounted to the vehicle even if equipped with VYU. The vehicle could overheat and be damaged.
• 10114807Dec 23, 2014Electrical system. This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that may have an intermittent "Check Trailer Wiring" or "Service Trailer Brake" message on the Driver Information Center. Technician will inspect and clean the ground wire (normally white wire) connection on the trailer side of the 7-pin connector. Inspect that the wires inside the trailer…
• 10114804Dec 22, 2014Transmission and drivetrain, Electrical system. This Preliminary Information communication provides information to the technician about vehicles that may have a Service 4WD message on the Driver Information Center. Technician may find C0398 or C0326 stored in the Transfer Case Control Module. Technician should reprogram the Transfer Case Control Module using Service Programming System for the updated calibrations to resolve this concern.
• 10126251Dec 19, 2014Transmission and drivetrain. This informational bulletin was created for the Manual Transmission Operating Characteristics. The different noises caused by driver habit, weather conditions , and normal manual transmission noises.
• 10114803Dec 19, 2014Transmission and drivetrain, Engine, Electrical system, Equipment. This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair vehicles with a rough idle and/or vibration at idle in Drive. This condition will not be present in Park, or Neutral. This concern may be caused by ground out within the one or both engine mounts. Technician will use CH-51450-A (Pico Oscilloscope) to measure the vibration disturbance.
• 10114802Dec 19, 2014Body and structure, Equipment. This Preliminary Information communication provides information to the technician the steps to diagnose and repair vehicles with visible water leak or signs of water intrusion from the antenna base, red OnStar LED, unable to connect to OnStar, OnStar unable to locate the vehicle, OnStar has inaccurate global positioning system location, no global positioning system on the navigation radio display, and inaccurate…
• 10114801Dec 19, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicle that may OnStar inoperative and Navigation/GPS/Compass issues. Technician may find Diagnostic Trouble Codes B101D sym 3C and or F0. Technician will gather data using a scan tool and contact General Motors Technical Assistance Center for further assistance. After approval technician will replace the OnStar module.
• 10250028Dec 18, 2014Electrical system, Fuel system. Special Return - Fuel Tank Module Kit: ACDelco Part Number M10256 (select date codes)
• 10126248Dec 18, 2014Wheels. This preliminary information bulletin provides information on how to remove stainless steel wheel nut caps with the matching depth of socket used on the wheel nut.
• 10126247Dec 18, 2014Equipment. This preliminary information bulletin advises the technician that there is no update for the customers concerns of the GM remote start doesn't work with the Onstar remotelink phone application.
• 10114792Dec 15, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicles with a low-volume, repetitive ticking noise coming from all speakers that may be more noticeable when listening to talk radio where there are breaks in the dialogue, allowing the noise to be more easily heard. Technician should not replace any parts for this concern. Engineering is currently evaluating this concern.
• 10114789Dec 15, 2014Equipment. This Preliminary Information communication provides information to the technician about when listening to an iPod that the first song will still be displayed when the next song in the list is playing. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle and that the current song can be displayed by pressing the ?next? button while the device is playing.
• 10126238Dec 12, 2014Equipment. This preliminary informational bulletin provides procedures to inspect , replace, or repair the XM radio antenna to correct the customers concern loss XM services, noise and/or water leak.
• 10114788Dec 12, 2014Equipment. This Preliminary Information communication provides information to the technician about when listening to an iPod that the first song will still be displayed when the next song in the list is playing. Dealer should communicate to the customer that we apologize for this inconvenience and that General Motors is currently evaluating this concern.
• 10114786Dec 12, 2014Electrical system. This Preliminary Information communication provides information to the technician about vehicles that may have any of these concerns remote keyless entry, passive Entry and Start Inoperative, No Fob detect message on driver information center, service tire pressure system, no audio, touch screen Inoperative, Steering Wheel Controls Inoperative, Service Stabilitrak, rear power windows inoperative, rear wiper…
• 10126231Dec 10, 2014Equipment. This information provides the proper way to install the floor mats .
• 10126228Dec 10, 2014Seats. This preliminary information provides a procedure to apply grease to the seat track to correct the costomer concern of excessive movement and a click noise while driving.
• 10114775Dec 10, 2014Electrical system. This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2.
• 10114773Dec 10, 2014Steering. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have a grind, pop, shudder or bind feeling/noise in the steering column when turning left or right. Technician will inspect for the lower column bearing to be out of position and the upper intermediate steering shaft to lower column shaft bolt and nut may be contacting the…
• 10126227Dec 9, 2014Equipment. This preliminary information provides a procedure to update the radio to correct the cutomers concern of a Blank Display, NAV Screen Audio Content is Unavailable via Speech Recognition, Display Screen is Stuck on Incoming Call View After Phone Call Finished, Rear View Camera Display Blank, USB Issues/Bluetooth/Favorite Bar/Voice, iPod Unable to Detect via USB, Recognition Concerns, XM Speech Recognition…
• 10126225Dec 9, 2014Electrical system, Equipment. This preliminary information bulletin provides a procedure on reprograming the HMI module to repair the customers concern of the blank screen after start up, Rear view camera on, touch screen inop, bluetooth and navigation concerns.
• 10114772Dec 9, 2014Electrical system. This Preliminary Information communication provides information to the technician about vehicles that the radio will lose audio except warning chimes and become inoperative after using Siri. The concern may be corrected by an ignition cycle. If the radio continues to be inoperative please contact General Motors Technical Assistance for further direction.
• 10126221Dec 8, 2014Electrical system. This warranty informational bulletin advised the technician that when performing a wiring repair, more information is required.
• 10081072Dec 8, 2014Body and structure. 14300 - service update. This bulletin provides a service procedure to replace the liftgate actuator assembly on certain vehicles equipped with a power liftgate (tb5/tc2). The power liftgate on these vehicles may have been built with liftgate struts that can lock up and cease to move. If the liftgate strut locks up, the customer may not be able to open or close the liftgate either electronically or manually.
• 10114766Dec 4, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have oil leak after the balancer is removed or replaced. Technician will need to insure the balancer bolt is the correct bolt for the engine application.
• 10114764Dec 3, 2014Electrical system. This Preliminary Information communication provides information to the technician with the correct way to remove the front shock electrical connector terminals. Technician will need to slightly bend the end of the J-38125-12A release tool. There is a purple Terminal Position Assurance that will align itself in the release position when the release tool is inserted into the release hole.

← All problems reported for the 2015 Chevrolet Suburban