2019 Chevrolet Suburban Technical Service Bulletins

978 technical service bulletins (TSBs) are on record for the 2019 Chevrolet Suburban. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11009756Sep 17, 2024Engine, Transmission and drivetrain. This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global Warranty Management.
• 11009088Sep 16, 2024Transmission and drivetrain. This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
• 11009039Sep 14, 2024Other or unknown. This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only).
• 11009029Sep 13, 2024Engine. This bulletin advises the technician that if the code sets, verify the sensor then inspect the engine oil pump for a sticking valve that may cause the MIL to illuminate.
• 11007776Sep 13, 2024Other or unknown. This Preliminary Information communication advises the technician that some vehicles may have a dim Driver Information Center when the interior of the vehicle is hot from a sun load or extended heater operation. The Driver Information Center is designed to dim with high temperature exposure. This is done to protect the Driver Information Center from damage.
• 11007761Sep 13, 2024Brakes. This Preliminary Information communication provides information to the technician that a customer may request the factory Integrated Trailer Brake Control be bypassed and their aftermarket trailer brake controller be installed instead. Technician will need to gain access to the body harness. Install trailer brake controller harness General Motors part number 23184088 into Middle Bus Electrical Center (X61A).
• 11007744Sep 12, 2024Other or unknown. This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
• 11007743Sep 12, 2024Other or unknown. This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
• 11007691Sep 11, 2024Brakes. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicle that may have a "Check Trailer Wiring" or "Service Trailer Brake System” message on the Driver Information Center when a trailer is connected to the vehicle. Diagnostic Trouble Code C1114 set in the Chassis Control Module. Chassis Control Module has to determine the type of trailer brake system…
• 11007687Sep 11, 2024Other or unknown. This Preliminary Information communication provides the technician with steps to resolve the issue of an oily substance that may be found on the inside windshield surface, and appears to be leaking from the rear view mirror area. Technician will remove the moisture sensor and clean the glass and mounting bracket with alcohol wipe. If the gel separates from the sensor the sensor will need to be replaced.
• 11007686Sep 11, 2024Brakes. This Preliminary information communicates an issue with the Hydrastar Electric Over Hydraulic trailer brake system causing a voltage spike into the trucks electrical system which is causing DTC C1114 to set.
• 11009037Sep 10, 2024Other or unknown. This service bulletin provides information on Enhancing Field Product Reports with Digital Pictures.
• 11008966Sep 9, 2024Transmission and drivetrain. This technical bulletin provides a procedure for the techs to replace the forward check ball and separator plate if found the cause of the customers concern of No Forward Gear When Shifting from Park to Drive and/or Reverse to Drive.
• 11008956Sep 9, 2024Other or unknown. This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
• 11007208Sep 6, 2024Other or unknown. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 11007196Sep 6, 2024Other or unknown, Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency…
• 11006988Sep 4, 2024Body and structure. This Preliminary information communicates an issue with a wind noise while driving at highway speeds and dealers are to inspect the body harness pass through for being full seated into the cowl.
• 11008898Aug 27, 2024Other or unknown. The bulletin provides direction on how to locate the Temporary Service Part (TSP) form in GlobalConnect.
• 11006621Aug 26, 2024Electrical system. Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined…
• 11007936Aug 22, 2024Suspension. This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
• 11007935Aug 22, 2024Suspension. This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
• 11008906Aug 19, 2024Engine. This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
• 11007721Aug 16, 2024Electrical system, Engine. This service bulletin provides information on AGM batteries that require less frequent charging in storage.
• 11006500Aug 16, 2024Other or unknown, Electrical system. This Preliminary Information communication provides information to the technician with additional information on the functionality of Lane Keep Assist. Starting with 2016 model year Lane Keep Assist Regular Production Option Code (UHX) replaced Lane Departure Warning Regular Production Option Code (UFL). Lane Keep Assist is designed to assist the driver in keeping the vehicle from drifting out of a driving lane…
• 11006317Aug 13, 2024Seats. This Preliminary information communicates assistance in locating the Rear seat belt comfort guides in the parts catalog.
• 11006293Aug 13, 2024Electrical system. This Preliminary information communicates to the dealer an issue where the vehicle's engine may crank over unprompted and not start afterward. This is the result of hooking up the Active Fuel Injector Tool incorrectly on vehicles equipped with a direct fuel injection system. This Preliminary information instructs the dealer of a repair kit they received that will prevent this issue when installed correctly.
• 11006274Aug 13, 2024Electrical system. This Preliminary Information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. Dealer should advise the customer the specification for speedometer needle accuracy is +/- 2 MPH at any given speed when looking straight at the needle.
• 11006682Aug 9, 2024Other or unknown. This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
• 11007155Aug 8, 2024Engine. This informational bulletin advises the technician that the engine and related parts will be debited if found that the tech did not properly prepare the engine block from dirt and debris in bolt holes or if found that the block was damaged by the tech.
• 11007115Aug 8, 2024Engine. This service bulletin provides information on Internal Engine Noise or Damage After Oil Filter Replacement.
• 11007121Aug 7, 2024Engine. This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.
• 11007095Aug 7, 2024Fuel system. This bulletin provides information on the TOP TIER Detergent Gasoline Licensed Brands and the TOP TIER Diesel Fuel Licensed Brands that are recommended for use in all GM vehicles and the TOP TIER FUELS website URL.
• 11006670Aug 7, 2024Engine. This service bulletin advises about the possible issues that may occur when using a scotch brite pad or highly abrasive disk on gasket sealing surfaces or reused parts.
• 11007116Aug 6, 2024Electrical system, Engine. This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.
• 11007091Aug 5, 2024Engine. This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
• 11006849Aug 5, 2024Seat belts. This service bulletin provides information on regular inspection of the Seat Belt Lap Anchor.
• 11006644Aug 1, 2024Other or unknown. This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
• 11006511Jul 31, 2024Visibility (wipers, defrost, mirrors). This PI provides information on Rear and Side Tempered Glass Spots (Quench Marks) and that they are a normal characteristic.
• 11006473Jul 30, 2024Transmission and drivetrain. This technical bulletin provides a procedure for the techs to replace the forward check ball and separator plate if found the cause of the customers concern of No Forward Gear When Shifting from Park to Drive and/or Reverse to Drive.
• 11006371Jul 26, 2024Electrical system, Other or unknown. This service bulletin provides information for dealers/technicians on the process to disable and enable passive unlocking.
• 11006278Jul 26, 2024Other or unknown. This service bulletin describes the U.S. Dealer Special Tool Loan Program process.
• 11006421Jul 24, 2024Transmission and drivetrain. GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.
• 11006290Jul 24, 2024Engine, Electrical system. This service bulletin provides information to dealership personnel on a new refrigerant (R1234yf) for A/C service.
• 11006377Jul 23, 2024Fuel system. This informational bulletin explains the difference in AFM and DFM engines and what is and is not activated during this occurrence.
• 11006282Jul 22, 2024Wheels. This service bulletin provides information on Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels.
• 11005351Jul 18, 2024Transmission and drivetrain. This technical bulletin provides a procedure for the techs to replace the forward check ball and separator plate if found the cause of the customers concern of No Forward Gear When Shifting from Park to Drive and/or Reverse to Drive.
• 11005339Jul 17, 2024Engine. This service bulletin explains the difference in oil filters for gas engines with new oil pump control systems and the possibilities of what may happen using the incorrect filter.
• 11005311Jul 9, 2024Transmission and drivetrain. This service bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operation.
• 11004727Jun 29, 2024Fuel system. This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
• 11004761Jun 28, 2024Engine, Fuel system. This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.

← All problems reported for the 2019 Chevrolet Suburban