2006 Chevrolet Trailblazer Technical Service Bulletins

789 technical service bulletins (TSBs) are on record for the 2006 Chevrolet Trailblazer. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10112013Jan 22, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone contacts to not have any Emojis loaded to any contact.
• 10111997Jan 16, 2014Equipment. This Preliminary Information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for Non - General Motors aftermarket accessories installed on the vehicle that can cause these issues.
• 10137777Jan 14, 2014Equipment, Electrical system. This Informational bulletin explains the warranty and policy exchange program for electronic devices and products, what can be approved by TAC and where the electronic parts can be returned to.
• 10137776Jan 14, 2014Transmission and drivetrain. This information was created to inform the technician that the 2-3 upshift and the 3-2 downshift clunk is caused by the releasing of the 2-4 band and application of the 3-4 clutch assembly during an upshift. Also during a 3-2 downshift, the releasing of the 3-4 clutch during the application of the 2-4 band, can cause torque reversal down the output shaft creating a clunk. This is a normal condition.
• 10111986Jan 14, 2014Engine cooling. This Preliminary Information communication provides information to the technician that some vehicles may have a Service Engine Soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. Technician will follow service information diagnosis first. If service information diagnosis does not isolate the cause of this concern perform a cylinder deactivation active fuel management system compression test in…
• 10137775Jan 8, 2014Equipment. This warranty administration bulletin provide policy information of the JOB CARD, for a repair on vehicles and what is acceptable - customer authorization; Service manager approvals and transaction authorization; Details of concern, cause and correction; Labor Time; Technician ID and acoutablity of labor time; Proper documentation and retension of warranty parts; Accurate sublet charges and receipts; Add on…
• 10111977Jan 7, 2014Engine. This Preliminary Information communication provides information to the technician about vehicles that are setting Diagnostic Trouble Code P0300 after engine repairs. Technician will need to ensure that injector connectors for cylinder 5-7 and 6-8 are not crossed.
• 10137773Jan 2, 2014Equipment. This warranty administration bulletin provides information on GM?s policy for comprehensive courtesy transportation to its customers.
• 10137772Jan 2, 2014Equipment. This warranty administration bulletin provide policy information of the JOB CARD, for a repair on vehicles and what is acceptable - customer authorization; Service manager approvals and transaction authorization; Details of concern, cause and correction; Labor Time; Technician ID and acoutablity of labor time; Proper documentation and retension of warranty parts; Accurate sublet charges and receipts; Add on…
• 10190934Jan 1, 2014Equipment, Body and structure. Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the…
• 10190933Jan 1, 2014Body and structure, Equipment. Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the…
• 10133103Dec 16, 2013Back-over prevention (rear camera). This informational bulletin provides directions on submitting different PIRs
• 10133098Dec 13, 2013Equipment. This preliminary information bulletin provides a revision of 13-00-89-004D to include updated information.
• 10133097Dec 13, 2013Equipment. This preliminary bulletin explains physical damage to radios and IPCs must be reviewed and validated if covered under GM warranty or not.
• 10133087Dec 5, 2013Visibility (wipers, defrost, mirrors). This preliminary bulletin explains the marks in the glass are normal when wearing polarized sunglasses and do not replace any glass for this reason.
• 10133086Dec 4, 2013Fuel system, Other or unknown. This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.
• 10118889Nov 27, 2013Electrical system. This preliminary bulletin provides information on Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404, E4413, E4414, E4423 or E4491).
• 10118880Nov 19, 2013Equipment. This informational bulletin provides an update for 13-00-89-004C to include updated information.
• 10118866Nov 11, 2013Equipment. This informational Bulletin provides a revision for 00-06-01-026D to add the 2014 model year.
• 10118859Nov 7, 2013Equipment. This informational bulletin provides a revision for 04-06-04-047K to add the 2014 model year.
• 10118858Nov 7, 2013Equipment. This informational bulletin provides a revision for 04-06-04-047 to add the 2014 model year.
• 10118842Nov 1, 2013Equipment. This informational Bulletin provides a revision for 10-08-110-001 to add the 2012-2014 model years.
• 10112331Nov 1, 2013Engine cooling. This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, An out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.
• 10112329Nov 1, 2013Equipment. This Preliminary Information communication provides information to the technician about customers that may complain of various concerns when using Bluetooth components. Technician should use the Preliminary Information to gather information from the customer on their Bluetooth device and the concern they are having before calling General Motors Technical Assistance Center.
• 10112436Oct 30, 2013Engine, Fuel system. This Preliminary Information communication provides information to the technician that some vehicles may have a Service Engine Soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. Technician will follow service information diagnosis first. If service information diagnosis does not isolate the cause of this concern perform a cylinder deactivation active fuel management system compression test in…
• 10112399Oct 8, 2013Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down, remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10113256Sep 18, 2013Electrical system, Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down, remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10113227Sep 3, 2013Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partech for assistance.
• 10245841Sep 1, 2013Vehicle speed control, Body and structure, Electrical system. Driver Door Switch Short Circuit
• 10113506Aug 28, 2013Tires. This warranty administration bulletin provide policy information on GM of Canada New Vehicle Limited Warranty Tire Program and Global Warranty Management (GWM) Submission Information.
• 10113502Aug 26, 2013Transmission and drivetrain, Brakes, Electrical system, Equipment, Engine…. This warranty administration bulletin provide policy information on a revised customer concern not duplicated/verified labor operation numbers and how to submit CCND.
• 10113199Aug 20, 2013Electrical system. This Preliminary Information communication provides information to the technician about vehicles that the OnStar system will not connect. Technician should record module info per the latest version of PIC4310 and contact General Motors Technical Assistance Center.
• 10113494Aug 19, 2013Engine cooling, Equipment. This informational bulletin provides information on close-coupled converter and engine replacement.
• 10113191Aug 13, 2013Engine cooling. This Preliminary Information communication provides information to the technician that some vehicles may have a Service Engine Soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. Technician will follow service information diagnosis first. If service information diagnosis does not isolate the cause of this concern perform a cylinder deactivation active fuel management system compression test in…
• 10059991Aug 13, 2013Body and structure, Electrical system. Summary to be provided on a future date.
• 10113188Aug 12, 2013Steering. This Preliminary Information communication provides information to the technician vehicles with a slight rough idle. Technician should compare the concern with a like vehicle. If the concern is worse than a like vehicle, technician should follow published Service Information diagnosis and repair as necessary.
• 10113483Aug 5, 2013Tires. This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
• 10113177Aug 5, 2013Engine, Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308.
• 10114183Jul 19, 2013Fuel system. 10054E - Special Coverage (customer co-pay discontinued). The contacts on the fuel level sensor may wear prematurely. This wear could cause the fuel gauge to read empty after filling the tank and cause the malfunction indicator light (MIL) to illuminate. As the fuel level in the tank drops, the MIL may turn off and the gauge may display a reading; however, the reading may indicate a slightly higher level of fuel…
• 10059924Jul 19, 2013Fuel system. Summary to be provided on a future date.
• 10130578Jul 18, 2013Electrical system. This informational bulletin provides information for warranty codes that are generated by EL-50313 midtronics GR8 battery tester/charger.
• 10130570Jul 16, 2013Equipment. This informational bulletin provides information for the PQC assembly replacement process.
• 10130567Jul 12, 2013Equipment. This informational bulletin provides information on key codes security rules and information on GM key code look up application.
• 10130562Jul 9, 2013Equipment. This informational bulletin provides information on key code security and information on GM key code look up applications.
• 10250092Jul 1, 2013Electrical system. Special Coverage Adjustment - Fuel Level Sensor Contact Wear
• 10246579Jul 1, 2013Fuel system. Special Coverage Adjustment - Fuel Level Sensor Contact Wear
• 10113120Jul 1, 2013Engine cooling. This Preliminary Information communication provides information to the technician that some vehicles may have a Service Engine Soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. Technician will follow service information diagnosis first. If service information diagnosis does not isolate the cause of this concern perform a cylinder deactivation active fuel management system compression test in…
• 10041526Jul 1, 2013Fuel system. Buick/chevrolet/gmc: see document search button for owner letter. Fuel level sensor contact wear may be premature. *pe updated 10/5/11. *pe updated 12/5/11. *pe updated 12/6/11. *pe updated 9/30/13.
• 10059977Jun 28, 2013Body and structure, Electrical system. Summary to be provided on a future date.
• 10059967Jun 27, 2013Body and structure, Electrical system. Summary to be provided on a future date.

← All problems reported for the 2006 Chevrolet Trailblazer