2014 Chevrolet Volt Technical Service Bulletins

1,656 technical service bulletins (TSBs) are on record for the 2014 Chevrolet Volt. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10083782Apr 27, 2016Engine, Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of black smoke when starting the vehicle after sitting.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10083073Apr 26, 2016Electrical system, Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078743Apr 26, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078560Apr 25, 2016Steering. This preliminary information bulletin provides a procedure to inspect and replace the steering column seal to correct a customer concern on a rubber squeak type noise when turning the steering wheel due to the seal for the intermediate shaft, located at the front of dash, rubbing on the rotating intermediate steering shaft.
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.
• 10083587Apr 22, 2016Equipment. This preliminary information communication advises the technician to contact the gm technical assistance center for further instructions. The concern is the radio may be unable to save xm favorite stations.
• 10083509Apr 21, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern. The vehicle's xm radio only has xm preveiw channels.
• 10083482Apr 21, 2016Equipment. This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. The vehicle's xm travel link may be inopertive.
• 10078522Apr 20, 2016Equipment. "this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to customer improperly setting the radio volume high enough when the turn-by-turn navigation messages are played. "
• 10078520Apr 20, 2016Electrical system. This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
• 10083884Apr 19, 2016Equipment. This preliminary information communication advises the technician on the steps for diagnosing the concern. The vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
• 10083484Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078735Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078507Apr 18, 2016Electrical system, Equipment. This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
• 10078506Apr 18, 2016Electrical system. This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
• 10078504Apr 18, 2016Engine. This informational bulletin provides information internal engine noise or damage after oil filter replacement
• 10078502Apr 15, 2016Equipment. This warranty administration bulletin provides information on gm’s policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
• 10083585Apr 13, 2016Equipment. This preliminary information communication advises the technician not to make any repairs or replace any parts. The technician is to contact the gm technical assistance center to review a concern when the vehicle's radio is unable to save a xm preset after saving presets.
• 10078481Apr 12, 2016Equipment. This informational bulletin provides information on the purpose of magnetic drain plugs.
• 10078472Apr 12, 2016Visibility (wipers, defrost, mirrors). This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
• 10078435Apr 7, 2016Equipment, Body and structure. This preliminary informational bulletin provides information that may be helpful when addressing underbody component corrosion with customers.
• 10083512Apr 5, 2016Visibility (wipers, defrost, mirrors), Equipment. This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078604Apr 5, 2016Electrical system, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10083579Apr 1, 2016Equipment. This preliminary information communication is to contact gm technical assistance center to report the concern and obtain a case number. The customer is unable to select radio presets from the usb or sd card as they are greyed out.
• 10078588Apr 1, 2016Electrical system, Equipment. This preliminary information communication is to contact gm technical assistance center to report the concern and obtain a case number. The customer is unable to select radio presets from the usb or sd card as they are greyed out.
• 10078434Apr 1, 2016Transmission and drivetrain. This informational bulletin provide information on the operating characteristics of a manual transmission.
• 10078430Apr 1, 2016Steering. "this technical bulletin provides a procedure to inspect the steering gear for a normal condition of grease or sealant on exterior case of gear due to the manufacturing process."
• 10113973Mar 31, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will check Global Warranty Management system for customer satisfaction program 15086 status. If the status of the customer satisfaction program 15086 was not completed follow the steps to get the Telematics…
• 10113967Mar 30, 2016Electrical system. This Preliminary Information communication advises the technician that the high voltage drive motor battery and battery sections are being placed on restriction through the General Motors Technical Assistance Center. Dealer will need to call General Motors Technical Assistance Center for further assistance.
• 10112831Mar 30, 2016Wheels. This informational bulletin provides information on chemical staining, pitting, and corrosion on wheels and the proper cleaners to use to fix the conditions due to multiple causes.
• 10112829Mar 29, 2016Equipment. This preliminary informational bulletin provides information on GM is implementing a new service strategy that uses a set of universal coaxial repair kits to service vehicles. This only applies to cable used for high frequency signals, such as cellular (OnStar®), satellite radio (XM) and GPS (navigation). The kits do NOT apply to the AM/FM cables.
• 10112821Mar 24, 2016Electrical system. This preliminary informational bulletin provides information on GM Accessory Remote start not working with onstars remotelink phone applications
• 10113957Mar 22, 2016Electrical system. This Preliminary Information communication advises the technician that some vehicles intermittently the favorites saved from a USB drive or SD card are grayed out and not selectable. Please communicate to the customer that we apologize for this inconvenience and that General Motors is currently evaluating this concern.
• 10113955Mar 22, 2016Equipment. This Preliminary Information communication advises the technician that some vehicles may have a radio display that is covered when the radio station favorites list is maximized. This is a normal operating characteristic and no repair attempt should be made. The hidden screen functions will operate again after the user minimizes the favorites list by dragging it to the bottom of the display.
• 10113948Mar 21, 2016Equipment. This Preliminary Information communication provides information to the technician about iPhones will not always autoconnect through Bluetooth to the vehicle. If the vehicle has more than one device listed in the Bluetooth device list, and the last device used was an Apple product, the Apple products will not autoconnect. The system will connect to one of the other devices instead. This concern is usually noticed…
• 10112812Mar 21, 2016Seats. This technical bulletin provides a procedure to Driver or Passenger Seat Cushion Frame Replacement to correct the condition of the front seat travels past the rear stop and will not move forward due to the seat track may travel underneath and past the most rearward design intent end stop.
• 10113932Mar 15, 2016Transmission and drivetrain, Electrical system. This Preliminary Information communication provides information to the technician when the vehicle will not charge the high voltage battery, current Diagnostic Trouble Codes, and the vehicle will not shift out of park. Technician will follow Service Information for any current Diagnostic Trouble Codes. Technician will insure the charge cord is working correctly. Verify that the issue was not a result of charging…
• 10112795Mar 15, 2016Equipment. This informational bulletin provides information on what is needed to be prepared for TAC, caller preparedness and checklists and contacting U.S. technical Assistance and the use of strategy based diagnostics
• 10112791Mar 14, 2016Equipment. This warranty administration bulletin provides information on Courtesy Transportation and Roadside Assistance Programs
• 10112789Mar 14, 2016Visibility (wipers, defrost, mirrors). This technical bulletin provides a procedure to relearn the power folding mirriors and road test to correct a conditon of power fold away mirriors glass shakes or flutters at normal driving speeds
• 10113926Mar 11, 2016Equipment, Tires. This Preliminary Information communication advises the technician what affects electric range and provides driving tips for better energy efficiency. Vehicles may have an electric range is less than customer expectations or what is being displayed on the in-vehicle display for EV range. The distance you can go in an electric vehicle varies with the outside temperature. All electric vehicles are less efficient in…
• 10112785Mar 10, 2016Equipment, Electrical system. This informational bulletin provides information on Original Equipment Batteries Part Number and ACDelco Replacement Battery Approved Warranty Part Numbers
• 10113921Mar 8, 2016Equipment. This Preliminary Information communication advises the technician after the OnStar Canada upgrade the OnStar Vehicle Diagnostic Email report is inoperative. Please communicate to the customer that we apologize for this inconvenience and that General Motors is working on a solution for this concern.
• 10112779Mar 7, 2016Electrical system. This informational bulletin provides information on vehicles may rock or move slightly forward or rearward while in Park at start up after cold soak and that this is considered a normal conditon and no repairs are necessary
• 10113914Mar 4, 2016Engine cooling. This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspect for a poor crimp on the coil grounds ring terminal at the engine block for the bank with the concern and repair the wire.
• 10113912Mar 4, 2016Equipment. This Preliminary Information communication provides information to the technician about some vehicles that may have a concern of Bluetooth music skipping. This condition is a normal operating characteristic of the vehicle. Streaming music through Bluetooth uses a lot of the radio's processing resources.

← All problems reported for the 2014 Chevrolet Volt