2015 Chevrolet Volt Technical Service Bulletins

1,418 technical service bulletins (TSBs) are on record for the 2015 Chevrolet Volt. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10114437Feb 25, 2015Electrical system. This Preliminary Information communication provides information to the technician some vehicles may have a Service Stabilitrak message and a red brake lamp illuminated on the Instrument Panel Cluster. Technician may find a Diagnostic Trouble Code C0196 in the Electronic Brake Control Module. This concern may be preset after the vehicle was flat towed or just came off a car carrier.
• 10114434Feb 24, 2015Electrical system. This Preliminary Information communication provides information to the technician about vehicles equipped with absorbent glass mat 12 volt battery. Technician should insure that the EL-50313 Midtronics GR8 battery charger/tester has the current calibrations. When using the battery charger insure that absorbent glass mat and the correct cold cranking amps is selected.
• 10113571Feb 24, 2015Electrical system. This informational bulletin communicates Information to technicians on control module Diagnostic Trouble Code(s) (DTC)(s) P0601, P0602, P0603, P0604, P0606, P062F, P06F3, P1621 which can be shared in multiple modules.
• 10113570Feb 24, 2015Equipment. This technical bulletin is a revision for 11-08-49-001M to update the Condition.
• 10114432Feb 23, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that the Navigation radio does not have a global positioning system location but OnStar is able to accurately locate the vehicle. Technician should check the installation of the COAX cables to be router correctly. Technician will gain access to the Radio or Human Machine Interface depending on the vehicle build. Install…
• 10113566Feb 20, 2015Fuel system. This informational bulletin provides information for maintenance cleaning of the fuel injectors.
• 10114428Feb 19, 2015Electrical system. This Preliminary Information communication provides information to the technician about vehicles that may have a no crank with a "Waiting to Initialize" message displayed on the Driver Information Center. Technician may also find a Diagnostic Trouble Code P0AFA in the Hybrid Powertrain Control Module 2. Technician will need to insure that the 12 volt battery is fully charged.
• 10114427Feb 19, 2015Electrical system. This Preliminary Information communication provides information to the technician about disabling the remote express down feature per the customer request. Technician will need to reprogram the Body Control Module and choose ?DISABLE Remote Open All Windows feature of Remote Keyless Entry transmitter?.
• 10114426Feb 19, 2015Electrical system. This Preliminary Information communication provides information to the technician about vehicles equipped with absorbent glass mat 12 volt battery. Technician should insure that the EL-50313 Midtronics GR8 battery charger/tester has the current calibrations. When using the battery charger insure that absorbent glass mat and the correct cold cranking amps is selected.
• 10114413Feb 17, 2015Electrical system. This Preliminary Information communication provides information to the technician about vehicles that may have a Check Engine Lamp or Service Vehicle Soon lamp on after charging. If the technician finds Diagnostic Trouble Codes P16C4 or P16C5 set in history, the Hybrid Powertrain Control Module will need to be reprogrammed.
• 10114408Feb 13, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the existing cellular provider not having roaming agreements in areas outside of Canada to support transmitting of the packet data required for Turn-By-Turn feature to operate. The…
• 10113538Feb 11, 2015Tires, Wheels. This informational bulletin communicates comprehensive instructions to GM Dealers and authorized GM Accessory Distributor/Installers as to the proper methods for mounting, balancing, and installing accessory wheels and tires.
• 10113531Feb 9, 2015Equipment. This warranty administration bulletin provides information to clarify proper transaction administration of GM Dealer Empowerment Program and Goodwill Cases.
• 10113527Feb 6, 2015Exterior lighting. This informational bulletin communicates GM's position on exterior lighting components ?tinted or smoked? by an outside vendor.
• 10113519Feb 5, 2015Electrical system, Equipment. This preliminary informational bulletin adds the 2015 model year to repair information on correcting a customer concern of poor, limited, reduced Remote Keyless Entry (RKE) or Remote Vehicle Start (RVS) range.
• 10114383Feb 4, 2015Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that may have a engine noise is sometimes louder than expected. Also will explain the known normal and abnormal reasons why the engine may be louder. When the vehicle speed is between 25-50 miles per hour the road noise does not mask the engine noise this is considered normal. When the vehicle is first started for the…
• 10113515Feb 4, 2015Body and structure. This preliminary informational bulletin provides repair information to correct a customer concern of a rattle or sliding noise from the headliner area when making a turn, braking or upon acceleration.
• 10113514Feb 3, 2015Tires. This informational bulletin communicates GM's position on use of nitrogen gas in tires.
• 10113512Feb 3, 2015Electrical system. This preliminary informational bulletin provides a diagnostic tip for low line pressure or pressure regulator valve stuck after transmission service pump cover replacement.
• 10139439Jan 26, 2015Engine cooling. This preliminary informational bulletin provides diagnostic tips that may be helpful in correcting a customer concern about a whistle noise heard from the engine area after the vehicle has warmed up, or for up to 10 seconds after the engine is shut off.
• 10139438Jan 26, 2015Equipment. This informational bulletin provides information to correct a dealer concern of what they perceive to be paint staining when the protective shipping film is removed from certain vehicles.
• 10139437Jan 23, 2015Electrical system. This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
• 10139436Jan 23, 2015Equipment. This informational bulletin adds 2014 - 2015 model years to information regarding comeback prevention and using Customer Concern Verification Sheets (CCVS).
• 10139433Jan 23, 2015Electrical system. This informational bulletin provides information on control module diagnostics and configuration, programming using the TIS Service Programming System (SPS), set-up and warranty.
• 10079522Jan 23, 2015Body and structure. 14274 - customer satisfaction program. On certain 2010-2015 model year cadillac srx and 2011-2015 model year chevrolet volt vehicles, the manual liftgate gas strut may detach from the liftgate when the liftgate is closed and the piston rod could separate from the strut tube. If this occurs, the liftgate will not work and there may be damage to the liftgate exterior trim and sheet metal. Dealers are to replace the…
• 10139431Jan 22, 2015Equipment. This preliminary informational bulletin provides information to dealership personnel that the roof antenna may be missing from trunk kit during Pre-Delivery Inspection (PDI).
• 10139430Jan 22, 2015Wheels. This informational bulletin provides information on chemical staining, pitting, corrosion and/or spotted appearance of chromed aluminum wheels, along with warranty information regarding these conditions.
• 10114360Jan 22, 2015Electrical system. This Preliminary Information communication advises the technician that the Battery Charge Module for the Chevrolet Volt Part Restriction has ended. These parts can now be ordered directly through your parts department without General Motors Technical Assistance Center authorization.
• 10114358Jan 22, 2015Equipment. This Preliminary Information communication advises the technician that the Electronic Brake Control Module and Brake Pressure Modulator Valve part restriction has ended. These parts can now be ordered directly through your parts department without General Motors Technical Assistance Center authorization.
• 10114357Jan 22, 2015Engine cooling. This Preliminary Information communication provides information to the technician on the steps to vacuum fill to ensure the cooling system is properly filled. Technician will need to use special tool GE-47716 Vac-N-Fill Coolant Refill Tool. Technician will also perform Hybrid/EV Battery Pack Coolant Pump Bleed Procedure in the GDS2 tool.
• 10095153Jan 22, 2015Engine cooling. This preliminary information communication provides information to the technician on the steps to vacuum fill to ensure the cooling system is properly filled. Technician will need to use special tool ge-47716 vac-n-fill coolant refill tool. Technician will also perform hybrid/ev battery pack coolant pump bleed procedure in the gds2 tool.
• 10095123Jan 22, 2015Electrical system. This preliminary information communication advises the technician that the battery charge module for the chevrolet volt part restriction has ended. These parts can now be ordered directly through your parts department without general motors technical assistance center authorization.
• 10094941Jan 22, 2015Electrical system, Brakes. This preliminary information communication advises the technician that the electronic brake control module and brake pressure modulator valve part restriction has ended. These parts can now be ordered directly through your parts department without general motors technical assistance center authorization.
• 10139422Jan 16, 2015Engine cooling. This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
• 10139417Jan 15, 2015Equipment. This preliminary informational bulletin provides repair information to correct a customer concern that when the vehicle is in ECO mode, there is a lack of heat coming from the HVAC system.
• 10114352Jan 15, 2015Tires, Wheels. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10095317Jan 15, 2015Equipment. This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. General motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10139415Jan 14, 2015Electrical system. This warranty administration bulletin provides policy information on ACDelco® replacement battery warranty procedures.
• 10139414Jan 14, 2015Equipment. This warranty administration bulletin adds 2012 - 2015 model years to information communicating a change in the product field action customer reimbursement procedure (U.S. Dealers Only).
• 10114343Jan 14, 2015Equipment. This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10114342Jan 14, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10094888Jan 14, 2015Equipment, Electrical system. This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10139411Jan 12, 2015Equipment. This preliminary informational bulletin provides information that accessory remote start does not work with OnStar RemoteLink? phone application.
• 10139201Jan 6, 2015Engine. This preliminary informational bulletin provides diagnostic tips that may be helpful in correcting a customer concern about a whistle noise heard from the engine area after the vehicle has warmed up, or for up to 10 seconds after the engine is shut off.
• 10139200Jan 6, 2015Engine, Electrical system. This informational bulletin provides information that may be useful in diagnosing/testing batteries that have set for a long period of time and/or set in cold weather climates to correct a customer concern of symptoms that include, but not limited to, a slow or no crank condition that may be caused by a discharged battery.
• 10139199Jan 6, 2015Suspension. This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.
• 10139198Jan 6, 2015Tires. This preliminary informational bulletin provides information that the tire pressure monitor (TPM) sensors must always be re-learned when accessory wheels are installed on the vehicle.
• 10057262Jan 1, 2015Electrical system. General motors:2010-2015 cadillac srx, 2011-2015 chevrolet volt . Some model vehicles are experiencing problems with the liftgate strut rod detaching. Dealers are to correct the problem. *lj see document search button for owners letter.
• 10126251Dec 19, 2014Transmission and drivetrain. This informational bulletin was created for the Manual Transmission Operating Characteristics. The different noises caused by driver habit, weather conditions , and normal manual transmission noises.
• 10114801Dec 19, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicle that may OnStar inoperative and Navigation/GPS/Compass issues. Technician may find Diagnostic Trouble Codes B101D sym 3C and or F0. Technician will gather data using a scan tool and contact General Motors Technical Assistance Center for further assistance. After approval technician will replace the OnStar module.

← All problems reported for the 2015 Chevrolet Volt