2018 Chevrolet Volt Technical Service Bulletins

849 technical service bulletins (TSBs) are on record for the 2018 Chevrolet Volt. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10157003Sep 13, 2017Equipment, Engine cooling. This Preliminary information communicates the possibility of the timing chain tensioner gasket being improperly installed or mis-positioned after major engine repairs causing a low engine oil pressure and dtc p06DE.
• 10157002Sep 13, 2017Engine cooling, Electrical system, Equipment. This Preliminary Information communication advises the technician that the High Voltage Drive Motor Battery and Battery sections have been placed on part restriction by General Motors Technical Assistance. Dealer will need to call General Motors Technical Assistance Center for further assistance.
• 10157001Sep 13, 2017Equipment, Fuel system, Engine. This Preliminary information communicates to the technician, that they may be working on a concern of a rattle or pop noise during gas engine start. That if no codes or other symptoms are present, do not attempt repairs at this time. To advise the customer that GM Powertrain is aware of this concern and working on a resolution.
• 10159569Sep 12, 2017Equipment, Engine cooling. This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on gasket sealing surfaces or reused parts.
• 10156999Sep 11, 2017Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10159578Sep 7, 2017Electrical system, Equipment. This informational bulletin provides information on approved warranty part numbers for original equipment batteries
• 10156990Sep 6, 2017Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technicians may also contact Partech and/or the Techline Customer Support Center for additional support.
• 10159574Sep 5, 2017Engine. This informational bulletin provides information on Internal Engine Noise or Damage After Oil Filter Replacement.
• 10156988Sep 1, 2017Equipment. This Preliminary information communicates to the technician, that if the latest calibration have been installed per 17058 and Service Information for the P2097 fails to isolate the cause, do not attempt repairs at this time. To return the vehicle to the customer and to advise that GM is aware of this concern and working on a resolution.
• 10140293Aug 31, 2017Engine cooling. This informational bulletin provides information on Intake Manifold Inspection/Replacement After Severe Internal Engine Damage.
• 10140298Aug 30, 2017Equipment. The intent of this technical bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
• 10137748Aug 29, 2017Engine, Transmission and drivetrain. This Preliminary information communicates to look for other codesP0AEE, P0AF3, P0BD2, P0BD7, P0BDC, P0BE1 if a customer comes in with a Mil Request.
• 10137745Aug 29, 2017Transmission and drivetrain. This Preliminary Information communication provides the technician with inspection and repair instructions for vehicles with a no start/no propulsion condition that is setting a DTC P0A0C for the high voltage interlock circuit.Technician will reprogram the Hybrid Powertrain Control Module 2 to resolve the concern.The HPCM2 will then ignore the interlock circuit and P0A0C will no longer be a valid DTC for the vehicle
• 10137744Aug 29, 2017Transmission and drivetrain. This Preliminary Information communication advises the technician the 5ET50 electric variable automatic transmission assembly and component is being placed on restriction through the General Motors Technical Assistance Center. Dealer will need to call General Motors Technical Assistance Center for further assistance.
• 10140406Aug 23, 2017Equipment, Body and structure. Thins informational bulletin provides information on Paint-less Dent Repair Process.
• 10140295Aug 22, 2017Electrical system. This informational bulletin provides information on OnStar® VCIM is currently restricted parts. By working closely with our dealers and technicians, through the part restriction process, the General Motors team will gain a better understanding of any field concerns that may develop.
• 10137733Aug 22, 2017Equipment. This Preliminary Information communication advises the technician that the Human Machine Interface, Radio or Tuner, radio controls, Integrated Center Stack, display, and Media Disc Players are placed on restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
• 10137729Aug 21, 2017Engine, Transmission and drivetrain. This Preliminary information communicates diagnostic tip information related to P2119. It advises the technician that this code will not illuminate the MIL or cause reduced engine power conditions. That the throttle body should not be replaced base solely on this code. To follow SBD related to any symptom that the vehicle may have.
• 10137727Aug 21, 2017Engine. This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, An out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.
• 10137722Aug 16, 2017Equipment. The PI was created to advise of an engineering investigation for a concern of unable to connect toOnStar Virtual Advisor when selecting "New Destination" in the OnStar menu.
• 10137709Aug 10, 2017Equipment, Engine. This Preliminary Information communication advises the technician that the drive motor generator control module is being placed on restriction through the General Motors Technical Assistance Center. Dealer will need to call General Motors Technical Assistance Center for further assistance.
• 10137708Aug 10, 2017Electrical system. This Preliminary Information communication advises the technician the Battery Charge Module is being placed on restriction through the General Motors Technical Assistance Center. Dealer will need to call General Motors Technical Assistance Center for further assistance.
• 10140374Aug 9, 2017Equipment. This informational bulletin provides information for the service parts identification (SPID) label replacement.
• 10137705Aug 9, 2017Equipment. This Preliminary Information communication provides information to the technician about customers that may complain of various concerns when using Bluetooth components. Technician should use the Preliminary Information to gather information from the customer on their Bluetooth device and the concern they are having before calling General Motors Technical Assistance Center.
• 10140296Aug 7, 2017Equipment. This warranty administration bulletin provide policy information on required operating procedures.
• 10137702Aug 3, 2017Transmission and drivetrain. This Preliminary information communicates that engineering is working on a fix for P3260.
• 10140297Aug 2, 2017Equipment. This warranty administration bulletin provide policy information on warranty and policy exchange program for electronic products for U.S. and Canada dealers only.
• 10126081Jul 31, 2017Equipment. This informational bulletin explains the Road Force balancers and what they can do for customer concerns.
• 10126113Jul 25, 2017Electrical system. This informational bulletin provides information on Information on How to Prevent Inadvertent Vehicle Starting from Key Fob or OnStar Mobile Application and where to locate the information for future use.
• 10126068Jul 25, 2017Electrical system. This technical bulletin provides information on Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing and the procedures to turn the transport mode message on and off.
• 10126065Jul 25, 2017Equipment. This warranty administration bulletin provide policy information on required operating procedures.
• 10126111Jul 24, 2017Electrical system. This informational bulletin provides to the tech the new version of SPS that will prompt warnings when trying to reprogram modules that have been already reprogrammed.
• 10126100Jul 17, 2017Wheels. This informational bulletin provides information on mcgard wheel locks and if the key ever fractures that they will replace it via the website provided.
• 10137665May 23, 2017Equipment. This informational bulletin explains the Road Force balancers and what they can do for customer concerns.
• 10137600May 22, 2017Wheels. This informational bulletin provides information on Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels.
• 10137680May 19, 2017Brakes. This preliminary informational bulletin provides information regarding the normal characteristic of instrument panel red brake light intermittently comes on.
• 10137601May 17, 2017Engine. This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on engine surfaces.
• 10137605May 15, 2017Equipment. This informational bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.
• 10137640May 10, 2017Transmission and drivetrain. This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
• 10137635May 10, 2017Fuel system, Equipment. This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
• 10137602May 4, 2017Equipment. This informational bulletin provides the dealership with how to prep a vehicle for delivery to the customer to aid in higher CSi scores.
• 10137603May 2, 2017Equipment. This warranty administration bulletin provide policy information on required operating procedures.
• 10138086Mar 29, 2017Suspension. This informational bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operations.
• 10138087Mar 17, 2017Steering. This preliminary information bulletin provides information for diagnosing a power steering fluid leak at the fluid reservoir.
• 10138060Mar 15, 2017Equipment. This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
• 10138025Mar 13, 2017Steering. This technical bulletin provides a procedure inspecting for excess grease or Sealant on the Exterior of the steering gear due to seeing grease or sealant on certain locations on the gear.
• 10138054Mar 10, 2017Electrical system. This informational bulletin provides information on On rare occasions, a security code input message with SPS error code E5659, M5304, and/or M5530 may be displayed in TIS2web when the technician is programming any module. If this concern is encountered, the technician should start by ensuring that the module being programmed is not a used module and that the VIN matches on VIN plate, TIS2web programming screen…
• 10138053Mar 9, 2017Transmission and drivetrain. This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
• 10138014Mar 7, 2017Equipment. This information bulletin explains the labor operation numbers used for submitting warranty claims and how to setup, and reprogram modules.

← All problems reported for the 2018 Chevrolet Volt