2005 Dodge Grand Caravan Recalls
NHTSA lists 5 recall campaigns for the 2005 Dodge Grand Caravan. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Equipment adaptive/mobilityCovers: Dodge Grand Caravan 2005, Grand Caravan SE 2005–2007, All IN One Mobility Town & Country 2006–2007 +5 more
Reported issue: All in one mobility is recalling certain model year 1997 through 2008 conversion vans equipped with vmi/ricon 6-way power seat bases. There is a possibility of a defective weld at the joint between the pivoting plate and the pivoting plate pin.
Possible consequence: The seat occupant may be injured if the seat base pin were to break.
Remedy: All in one mobility will notify owners and the vehicles will be repaired free of charge. The safety recall began on june 22, 2010. Owners may contact all in one mobility at 1-503-255-5005.
- SeatsCovers: Dodge Grand Caravan 2005, 2007
Reported issue: Arizona mobility products (amp) is recalling one 2005 and one 2007 conversion vans built on dodge grand caravan chassis equipped with vmi/ricon 6-way power seat bases. There is a possibility of a defective weld at the joint between the pivoting plate and the pivoting plate pin.
Possible consequence: The seat occupant may be injured if the seat base pin were to break.
Remedy: Amp will notify owners and repair vehicles free of charge. The safety recall began on june 10, 2010. Owners may contact amp at 1-602-385-5988.
- Air bags › Frontal › Sensor/control module-inactiveCovers: Dodge Grand Caravan 2005–2006, Chrysler Town And Country 2005–2006, Dodge Caravan 2005–2006
Reported issue: Chrysler is recalling certain model year 2005-2006 dodge caravan, grand caravan and chrysler town & country vehicles originally sold in or currently registered in the states of connecticut, delaware, iowa, illinois, indiana, kansas, kentucky, massachusetts, maine, maryland, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota…
Possible consequence: If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. Until the vehicle is repaired, the airbags may not provide the enhanced protection in the event of a crash.
Remedy: Chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during june 2010. Owners may contact chrysler at 1-800-853-1403.
- Visibility › Windshield wiper/washer › MotorCovers: Dodge Grand Caravan 2005–2006, Chrysler Town And Country 2005–2006, Dodge Caravan 2005–2006 +1 more
Reported issue: On certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break.
Possible consequence: During certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash.
Remedy: Dealers will inspect and replace the windshield wiper motor free of charge. The recall began on june 19, 2006, to dodge durango owners. Minivan owners will be notified during july 2006. Owners may contact daimlerchrysler at 1-800-853-1403.
- Seat belts › Front › RetractorCovers: Dodge Grand Caravan 2005, Chrysler Town And Country 2005, Dodge Caravan 2005
Reported issue: After performing the ncap test, it was discovered that on certain minivans equipped without the available "stow 'n go" seating option, the right front seat belt retractor assembly may have been improperly assembled.
Possible consequence: As a result, the seat belt may not properly restrain the occupant during certain crash conditions, which can increase the risk of injury.
Remedy: Dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. Owner notification began on february 23, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
← All problems reported for the 2005 Dodge Grand Caravan
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.