2006 Ford Crown Victoria Technical Service Bulletins

29 technical service bulletins (TSBs) are on record for the 2006 Ford Crown Victoria. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10177863Jul 13, 2020Body and structure. This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
• 10166447Sep 18, 2019Engine, Electrical system. This SKU is a Radiator Fan. The customer communication requested return of unsold inventory to inspect the electrical connections. An electrical connection issue may lead to the fan not working potentially throwing a check engine light for overheating.
• 10156863Feb 7, 2019Equipment, Body and structure. Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
• 10155551Feb 7, 2019Body and structure. Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
• 10109070Sep 21, 2016Engine cooling, Engine. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes…
• 10205037Apr 21, 2016Steering, Body and structure. Inpected or repaired under 13R01 - Requests for recall service action under 13S08
• 10183773Apr 21, 2016Steering. For 2005-2012 Crown Victoria, 2005-2011 Grand Marquis and Town Car vehicles, Regional Program 13R01 applies to vehicles not registered in corrosion states and not included in Safety Recall 13S08, where operation in high corrosion areas for an extended period may lead to corrosion in the lower intermediate steering shaft swing link. This may result in a compressed upper intermediate steering shaft and separation…
• 10054924Sep 16, 2014Steering. Ford: the lower intermediate steering shaft, has corrosion of swing link joints, combined with collapsed upper intermediate steering shaft, resulting in steering column separation and loss of steering control. Model 2005-2011 crown victoria, grand marquis, town car. *pe updated 04/23/14 *lj updated 07/10/15 *ta updated 7/15/15
• 10054006Oct 2, 2013Steering. Ford: swing link joints on lower intermediate steering shaft, has corrosion, and combined with collapsed upper intermediate steering shaft, on some vehicles, causes steering column to separate, leading to steering control loss. Model 2005-2011 crown victoria, grand marquis, town car.
• 10045340Jul 10, 2012Engine. Ford/lincoln/mercury: if battery was disconnected or dead, vehicles/trucks may experience hard starts and engine idle rpm fluctuation and exhibit diagnostic trouble codes (dtcs) p0505, p0506, p2111 and p2112.
• 10034526Jul 29, 2010Equipment. Ford: performance white or vibrant white paint peeling. In some affected vehicles, the performance white or vibrant white paint may not have been applied properly and may peel on the upper horizontal surfaces due to the excessive heat and sunlight exposure experienced in police or law enforcement service.
• 10029205Jun 1, 2009Engine cooling, Transmission and drivetrain. Ford/mercury/lincoln: vehicles may exhibit one or more of the following symptoms: drive away hesitation, loss of rpm on deceleration, difficulty starting, and/or idle rpm less than desired. The f53 motorhome chassis is included.
• 10023864Nov 1, 2007Engine cooling. Malfunction indicator lamp (mil) on--diagnostic trouble code (dtc) p2106 and p061b--police interceptor built before 10/19/2007.
• 10023943Oct 1, 2007Engine cooling. Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. Updated 2/23/10.
• 10022298Jul 25, 2007Engine cooling. Reduction in power at wide open throttle.
• 10021902Jun 25, 2007Equipment, Engine cooling. Engine overheating-poor a/c performance.
• 10019391Jan 22, 2007Transmission and drivetrain. Extended coverage program for forward clutch cylinder in the transmission may crack at the snap ring groove location causing a loss of clutch capacity and the eventual loss of forward gears. *tt supplement #2, owner notification. *tt supplement #4.
• 10020703Dec 28, 2006Engine cooling. Engine cooling fan inoperative - engine overheating - poor a/c performance.
• 10020676Dec 20, 2006Transmission and drivetrain. Un-commanded tcc apply on the 1-2 shift causing perception of hesitation and/or lack of power during shift.
• 10022230Dec 1, 2006Air bags. Air bag indicator light illuminated.
• 10019389Oct 20, 2006Transmission and drivetrain. The forward clutch cylinder in the transmission may crack at the snap ring groove location causing loss of clutch capacity and the eventual loss of forward gears. Customer satisfaction program 06b36. *tt supplement #1. *tt supplement #2. *kb supplement #3.
• 10021058Aug 25, 2006Transmission and drivetrain. Transmission oil cooler bypass valve inspection - program expiration extension.
• 10021060Aug 1, 2006Engine cooling. Engine cooling fan (8c607) inoperative.
• 10020107May 1, 2006Transmission and drivetrain. Transmission oil cooler (toc) bypass valve that may stick in the closed position, inhibiting transmission cooling and potentially causing the transmission to overheat. Customer satisfaction program 06b39.
• 10018748Nov 14, 2005Seats. Driver's seat cushion sagging.
• 10018745Nov 14, 2005Engine cooling. Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running.
• 10016803Nov 14, 2005Electrical system. High effort to activate horn - vehicles built before 5/6/2005. *tt oasis.
• 10018955Jan 1, 2005Steering. Light steering efforts at highway speeds.
• 10018943Jan 1, 2005Brakes. Parking brake control slow to release, vehicles built from 12/06/2004 through 11/21/2005.

← All problems reported for the 2006 Ford Crown Victoria