1996 Ford E-150 Brakes Problems
- Complaints
- 14about this part
- Share
- 24%of 59 total for the year
- Median mileage
- 147,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 14 complaints about the brakes of the 1996 Ford E-150, 24% of the 59 complaints for this model year. Where a mileage was given, the median is 147,000 miles. 4 of these say a crash was involved and 1 a fire, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“My vehicle according the NHTSA has recall #09v399000 for the brake system speed control which can catch on fire even in the garage with the vehicle off. I asked Ford to repair this because I just bought this vehicle and they claim there are no recalls on this vehicle, and I know there is and I know the recall hasn't been installed on my vehicle. Are they saying this because time ran out to have this done because I just bought this vehicle or do they just not want to? Thanks for your help.”
NHTSA complaint #10585226, filed 2014-04, 81,555 miles“1. I was traveling a 35 MPH on a straight road during the daylight hours. The road was dry. The weather was sunny, and there was very little traffic in a two lane road. As I approached standing traffic at a traffic light I began to slow gradually with engine braking. As I appoached the stopped car I began to touch the brake pedal, and immediately noticed no braking effect. I than pressed the pedal a couple more inches, and still there was little braking effect. …”
NHTSA complaint #10116880, filed 2005-04, 144,000 miles“Vehicle was parked, and upon entering noticed the smell of an electrical fire. Started the vehicle, odometer was inoperable and vehicle would not shift out of park. Upon further inspection, found a blown 15 amp fuse in the fuse panel. Replaced fuse, odometer came back on and vehicle shifted out of park. Approximately 10 seconds later, the smell of burning wiring was evident, as was smoke from under the hood. Pulled the fuse back out, opened the hood to find the brake pressure switch on fire, which melted the brake fluid reservoir as well as the battery casing also.”
NHTSA complaint #10509001, filed 2013-04, 168,000 miles“I was following another vehicle who stopped suddenlly. When I applied my brakes as hard as I could my foot was not fully on the brake pedal. Due to the location of the brake I just pivot my foot keeping the heel satationary. I was able to depress the brake pedal enough that part of my right put depressed the gas pedal at the same time as I was trying to brake resulting in the car not stopping. Either the brake pedal is located to closely to the gas pedal or the brake pedal travel is excessive.”
NHTSA complaint #701059, filed 1998-12“Noisy ABS; did we and do we have working ABS? No help from Ford. Don davis Ford invoice 202541 12/15/97, middlekauff inv. 404267 12/18/97 & 436463 2/2/99, five star inv. C05234 6/2/98 pd for brake fluid flushing with brake job (5star ruined caliper too), karl klement inv. 36021 8/19/98. My husband & I flushed the brakes - looked like dirty motor oil. 3 second whee became a chirp, pd. Utter Ford inv. C02461 5/19/99 to bleed ABS control unit - whee is gone but does our ABS work? It's never engaged and don't know if it will. …”
NHTSA complaint #706718, filed 1999-05Brakes: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2016 | 3 | 38% |
| 2015 | 1 | 13% |
| 2014 | 3 | 50% |
| 2013 | 1 | 5% |
| 2012 | 1 | 8% |
| 2011 | 3 | 13% |
| 2010 | 2 | 20% |
| 2009 | 1 | 14% |
| 2008 | 1 | 9% |
| 2007 | 1 | 8% |
| 2006 | 1 | 6% |
| 2005 | 4 | 25% |
| 2004 | 8 | 24% |
| 2003 | 3 | 14% |
| 2002 | 5 | 18% |
| 2001 | 11 | 30% |
| 2000 | 7 | 14% |
| 1999 | 14 | 17% |
| 1998 | 8 | 13% |
| 1997 | 18 | 18% |
| 1996 | 14 | 24% |
| 1995 | 20 | 28% |
| 1994 | 26 | 21% |
| 1993 | 10 | 14% |
| 1992 | 8 | 13% |
| 1990 | 2 | 12% |
| 1989 | 1 | 3% |
| 1988 | 1 | 7% |
| 1987 | 1 | 6% |
Other parts of the 1996 Ford E-150
11 complaintsElectrical system
10 complaintsVehicle speed control
6 complaintsFuel system
5 complaintsSuspension
5 complaintsTires
5 complaintsSteering
4 complaintsBody and structure
4 complaintsEquipment
3 complaintsAir bags
2 complaintsSeat belts
2 complaintsTransmission and drivetrain
2 complaints
← All problems reported for the 1996 Ford E-150
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology