2007 Ford E-250 Technical Service Bulletins

13 technical service bulletins (TSBs) are on record for the 2007 Ford E-250. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10243490Sep 7, 2023Transmission and drivetrain. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
• 10178768Jul 8, 2020Electrical system, Other or unknown. These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer…
• 10056196May 1, 2014Transmission and drivetrain. Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. Model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward.
• 10055629Feb 1, 2014Transmission and drivetrain, Engine cooling. Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. Model 2003-2007 f super duty, 2004-2010 e series, 2003-2005 excursion.
• 10039053Mar 1, 2011Transmission and drivetrain, Electrical system, Engine cooling, Brakes. Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
• 10039149Aug 26, 2010Engine cooling, Transmission and drivetrain. Ford: there are driveability concerns such as hesitation, low idle, or loss of power. 2007-2008 e150/250.
• 10022675Sep 19, 2007Brakes. Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes.
• 10096432Jun 7, 2007Electrical system. On some vehicles, when the gateway 401 module transitions from its power down mode (ignition off) to its power up mode (ignition on) the module may not wake up. If this action occurs, the module's led display panels will not prove-out and the backlights on the led display panels will not illuminate.
• 10022719Jun 7, 2007Equipment. Certain 2007 e-series strip chassis vehicle emission control information (veci) label replacement.
• 10022760Jun 1, 2007Transmission and drivetrain. Crank/no start/ no pcm communication and possibly p1336 and other codes.
• 10022243Apr 1, 2007Engine cooling. Lack of power due to low fuel pressure - fuel tank liner seperation.
• 10021621Feb 1, 2007Fuel system. Lack of power due to low fuel pressure, fuel tank liner seperation.
• 10022232Dec 1, 2006Exterior lighting. Headlight adjustment needed.

← All problems reported for the 2007 Ford E-250