2007 Ford E-350 Technical Service Bulletins

24 technical service bulletins (TSBs) are on record for the 2007 Ford E-350. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10243490Sep 7, 2023Transmission and drivetrain. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
• 10178768Jul 8, 2020Electrical system, Other or unknown. These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer…
• 10056196May 1, 2014Transmission and drivetrain. Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. Model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward.
• 10055629Feb 1, 2014Transmission and drivetrain, Engine cooling. Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. Model 2003-2007 f super duty, 2004-2010 e series, 2003-2005 excursion.
• 10039053Mar 1, 2011Transmission and drivetrain, Electrical system, Engine cooling, Brakes. Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
• 10039130Nov 17, 2010Engine cooling. Ford: there may be a lack of rpm, hesitation, or rough running concerns when the vehicle is in idle. There may be two trouble codes stored. The problem may be caused by aftermarket generators installed or modifications to the front end drive. E-350/450.
• 10034571Jun 11, 2010Fuel system. Ford: runs rough, lacks power, hard start, no start. Some vehicles and trucks equipped with 6.0l engine may exhibit a runs rough, lacks power, hard to start, no start concern with or without diagnostic trouble code (dtc) p0611 code or various injector circuit codes.
• 10028826Jun 1, 2009Engine cooling, Fuel system. Ford: some vehicles with diesel engines may experience no starts, hard starts or rough running when cold and may be accompanied with diagnostic trouble codes (dtcs) p0611, p1378 and/or all 8 injector circuit codes.
• 10028730May 1, 2009Engine cooling. Ford: some vehicles equipped with 6.0l diesel engine may exhibit any one or combination of the following concerns-lack of power, white/black smoke or a surge.
• 10028284Mar 20, 2009Engine cooling. Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. There are several potential causes for these symptoms.
• 10026387Oct 23, 2008Engine cooling. Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
• 10027985Sep 1, 2008Engine cooling. Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp).
• 10024325Mar 1, 2008Engine cooling. 6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08.
• 10023855Oct 1, 2007Engine cooling. 6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles.
• 10022675Sep 19, 2007Brakes. Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes.
• 10096432Jun 7, 2007Electrical system. On some vehicles, when the gateway 401 module transitions from its power down mode (ignition off) to its power up mode (ignition on) the module may not wake up. If this action occurs, the module's led display panels will not prove-out and the backlights on the led display panels will not illuminate.
• 10022719Jun 7, 2007Equipment. Certain 2007 e-series strip chassis vehicle emission control information (veci) label replacement.
• 10022760Jun 1, 2007Transmission and drivetrain. Crank/no start/ no pcm communication and possibly p1336 and other codes.
• 10021462Apr 27, 2007Engine cooling. Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start.
• 10022243Apr 1, 2007Engine cooling. Lack of power due to low fuel pressure - fuel tank liner seperation.
• 10021236Mar 23, 2007Engine cooling. Lack of cooling fan operation.
• 10021234Mar 23, 2007Engine cooling. 6.0l - mil on with dtc p2138, p2139, and p2140.
• 10021621Feb 1, 2007Fuel system. Lack of power due to low fuel pressure, fuel tank liner seperation.
• 10022232Dec 1, 2006Exterior lighting. Headlight adjustment needed.

← All problems reported for the 2007 Ford E-350