2015 Ford Escape Technical Service Bulletins

128 technical service bulletins (TSBs) are on record for the 2015 Ford Escape. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10144219Jul 26, 2018Electrical system, Body and structure, Other or unknown, Latches, locks and…. If a trailer hitch receiver is installed on a 2013-2018 Escape or 2015-2019 MKC vehicle equipped with a hands-free liftgate, the hands-free liftgate function will become inoperative.
• 10144210Jul 18, 2018Equipment, Suspension. Some 2013-2018 Escape vehicles may exhibit damaged or delaminated bushing(s) on the rear suspension front lower arm (dog bone). If the rear suspension front lower arm requires replacement, an updated part BV6Z-5500-D with a solid bushing is available. Refer to Workshop Manual (WSM), Section 204-02 for removal and installation.
• 10137133Apr 13, 2018Electrical system, Equipment. Some 2013-2016 Escape and 2016 Focus, Transit and Transit Connect vehicles equipped with a front control display interface module (FCDIM) may exhibit the inability to store AM/FM presets, select AM/FM presets and/or erratic preset button operation. Reprogram the front control display interface module (FCDIM) using Integrated Diagnostic System (IDS) or Ford J2534 Diagnostic Software (FJDS) release 109.02 or higher.
• 10137129Apr 10, 2018Seats, Electrical system. Some 2015-2017 Escape vehicles built on or before 5-Apr-2017 with factory trailer tow may exhibit a concern with a trailer lamp out warning and/or BLIS not available warning without a trailer connected. Access connectors C439 (4 pin) and C432 (12 pin) in the trailer tow harness. Inspect for corrosion and/or water contamination. Clean as required and add electrical grease (XG-12). Install and fully seat cover on…
• 10137115Mar 30, 2018Engine cooling. Some 2015-2018 Fusion/MKZ/MKC/Escape/Edge vehicles equipped with a 2.0L EcoBoost engine may exhibit a runs rough condition with DTCs P0300, P0301, P0302, P0303, P0304 and/or P0316. This may be due to coolant intrusion due to corrosion on the engine block. To diagnose this concern, with the engine at normal operating temperature, pressurize the cooling system to 138 kPa (20 psi) and hold for 5 hours.
• 10137113Mar 30, 2018Equipment. Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10136597Feb 14, 2018Equipment. 2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
• 10140323Jan 10, 2018Equipment. The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access.
• 10138524Jan 10, 2018Equipment. The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access.
• 10140315Jan 8, 2018Engine, Transmission and drivetrain. Some 2013-2018 Escape/Fusion/MKZ vehicles equipped with 2.5L or 1.5L/2.0L/3.0L Ecoboost engine, 2015-2018 MKC/Edge/Explorer vehicles equipped with 2.0L/2.3L/2.7L EcoBoost engine, 2016-2018 MKX vehicles equipped with 2.7L Ecoboost engine, 2017-2018 Continental vehicles equipped with 2.7L/3.0L EcoBoost, and AWD may exhibit a fluid leak from the PTU intermediate shaft seal.
• 10138516Jan 8, 2018Engine cooling. Some 2013-2018 Escape/Fusion/MKZ vehicles equipped with 2.5L or 1.5L/2.0L/3.0L Ecoboost engine, 2015-2018 MKC/Edge/Explorer vehicles equipped with 2.0L/2.3L/2.7L EcoBoost engine, 2016-2018 MKX vehicles equipped with 2.7L Ecoboost engine, 2017-2018 Continental vehicles equipped with 2.7L/3.0L EcoBoost, and AWD may exhibit a fluid leak from the PTU intermediate shaft seal.
• 10127421Nov 23, 2017Equipment, Engine cooling. Some 2013-2016 Escape vehicles equipped with a 1.6L EcoBoost engine may require the replacement of the A/C suction line. When replacing the suction line, verify that all of the compressor to engine block fasteners are installed and torqued properly. The compressor requires three fasteners - 2 bolts (W701331-S442) and one stud/nut - installed securing it to the engine block and torqued to 25 Nm (18 lb.ft) per the…
• 10127394Nov 3, 2017Body and structure. Some 2013-2018 Escape, Focus and C-Max vehicles may exhibit a water stained headliner after the vehicle has experienced a water leak from areas such as the roof opening panel, fixed glass, roof rails and roof ditch mouldings. Follow the procedure below to remove the water stains from the headliner after the water leak has been repaired. Follow the Service Procedure steps to correct the condition.
• 10127405Nov 2, 2017Transmission and drivetrain, Electrical system. Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the…
• 10125080Oct 6, 2017Back-over prevention (rear camera). Some owners of 2013-2018 Escape vehicles may complain of the rear license plate viewed in the lower portion of the display screen when using the parking aid camera. This is due to the convex camera lens to provide as much viewing angle as possible. This is a normal vehicle characteristic and no repairs or adjustments should be attempted to correct this condition.
• 10115953Jul 14, 2017Equipment. Some 2013-2017 Edge/MKX/Escape/MKC/Fusion/MKZ/Flex/MKT/Mondeo/Kuga/EcoSport AWD vehicles where diagnosis leads to a RDU clutch issue, a rear drive unit (RDU) service kit is available. Use the vehicle identification number (VIN) in the parts catalog to look for base part 4A232. If clutch assembly (base 4A232) is not listed in the catalog, this message does not apply. For vehicle repairs refer to updated Workshop…
• 10100517Mar 28, 2017Suspension. Some 2015-2017 escape and mkc vehicles without a vehicle dynamic suspension system and built on 1-apr-2015 and through 1-oct-2016 may exhibit a rattle and/or clunking noise from the rear suspension while driving over bumps and/or making turns at low speeds. Suspect rear shock absorbers will compress 2-5 inches of travel before significant resistance is observed.
• 10099087Mar 21, 2017Engine, Equipment. Some 2013-2017 escape vehicles built on or before 28-feb-2017 may exhibit a noise and/or vibration from the climate control blower motor with or without a lack of airflow from panel registers and may also have an odor. This concern may be due to small animals that can enter the blower motor housing area through the air inlet duct and cause damage to the air inlet duct assembly and/or blower motor assembly.
• 10099002Mar 13, 2017Electrical system. Some 2015-2017 escape vehicles equipped with emtc and built on or before 8-apr-2016 may exhibit incorrect air distribution from the instrument panel registers when panel mode is selected on the heater ventilation air conditioning (hvac) control panel. Follow the service procedure steps to correct the condition.
• 10095624Feb 2, 2017Transmission and drivetrain. Multiple 2014-2016 vehicles equipped with 6f35 transmission and built on 1-jan-2014 and through 31-dec-2015 may exhibit harsh reverse engagement and harsh/delayed 3rd and 5th gear up/down shifts with no dtcs present. This may be due to a mechanically binding shift solenoid b (ssb). Verify harsh reverse and 3rd and 5th gear shift events are present. Using ids, identify the band number of ssb for use when ordering…
• 10095175Jan 23, 2017Equipment, Engine. 2013-2016 fiesta, escape, transit connect and 2013 fusion vehicles with a 1.6l gasoline turbocharged direct injection (gtdi) engine may exhibit an engine oil level reading that is up to 8 mm above the maximum mark on the engine oil dipstick when the engine is filled with the correct amount of oil. This is a normal characteristic of this engine. Do not lower the oil level to the maximum mark on the engine oil…
• 10095154Jan 10, 2017Engine. To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye is available. Workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. The new white fluorescent dye provides a distinct white glow to identify engine oil leaks. The new white fluorescent dye requires a pure uv diagnostic inspection lamp. The white-colored…
• 10094643Dec 22, 2016Engine. Some 2015-2017 edge/mkx, escape/mkc, fusion/mkz and explorer vehicles equipped with a 2.0l or 2.3l may exhibit damage to the engine appearance cover, valve cover and/or intake manifold when attempting to remove the appearance cover. To reduce the possibility of damage, carefully pull straight upward on the underside of the cover at each fastener location to remove. Do not pull the cover forward or to the side.
• 10094578Dec 9, 2016Engine. Some 2015-2016 escape vehicles equipped with 1.6l gasoline turbocharged direct injection (gtdi) engines built on or before 9/30/15 may exhibit runs rough, lack of power, surge, buck/jerk, miss, loss of rpm, hesitation and/or an illuminated mil with diagnostic trouble code (dtc) p0236 stored in the powertrain control module(pcm) memory. These conditions may be caused by a wiring concern in the reference voltage…
• 10093865Dec 2, 2016Electrical system. Some 2015-2017 escape vehicles equipped with emtc and built on or before 8-apr-2016 may exhibit incorrect air distribution from the instrument panel registers when panel mode is selected on the heater ventilation air conditioning (hvac) control panel. Follow the service procedure steps to correct the condition.
• 10095995Nov 17, 2016Steering. Some 2010-2016 epas equipped vehicles may exhibit steering related noises. The workshop manual (wsm) diagnostic procedures have been updated in section 211-02. When diagnosing and repairing epas steering noises use the updated procedures.
• 10095968Nov 2, 2016Equipment. 2013-2017 escape vehicles equipped with moonroof exhibit a small vent opening position of 5 mm. This is the normal vent position for optimal nvh/windnoise qualities. When the vent is closed, the moonroof will open to the 10 mm position then close. The sliding glass also opens to the 10 mm position to give the glass enough clearance before it opens to the rearward position. This is the normal operating…
• 10091125Oct 27, 2016Visibility (wipers, defrost, mirrors). All 2013-2017 escape vehicles exhibit a frayed/cut short appearance at the front edge of the headliner near the windshield. This is a normal characteristic of the headliner and no repairs should be attempted.
• 10091003Oct 26, 2016Tires. Setting the correct tire inflation pressure is an important step in the pre-delivery process and during routine maintenance intervals. Recent customer clinics revealed that most every vehicle in the clinics had the tire pressures set incorrectly. Tire pressures from the factory are not set to the correct specification. Maintaining the correct tire pressure is key to the ride characteristics of the vehicle and…
• 10091151Oct 17, 2016Brakes. Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps…
• 10090681Oct 17, 2016Brakes. Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps…
• 10090671Oct 14, 2016Electrical system. Some 2013-2016 fusion/escape/mkt/flex/mks/taurus, 2015-2016 mkz/mkc/edge and 2016 mkx vehicles may exhibit various radio concerns including: speaker static with key-off, no audio after vehicle is first started with diagnostic trouble code (dtc) u0184, no volume control, or a stuck cd with no slot blockage. Prior to starting normal diagnosis for any of these conditions, verify the acm is at the latest calibration…
• 10090505Oct 10, 2016Engine. Some 2015-2016 f-150, c-max, edge, mks, taurus, and flex and 2016 expedition, explorer, escape, fusion, mustang, mkz, mkx, navigator, transit and transit connect vehicles equipped with a 2.0l, 2.5l, 3.5l or 3.7l gasoline engine and built on or before 31-may-2016 may exhibit an intermittent loss of power and/or an illuminated powertrain malfunction (wrench) lamp with diagnostic trouble codes (dtcs) p2111, p2112…
• 10109079Sep 30, 2016Seat belts. Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
• 10109070Sep 21, 2016Engine cooling, Engine. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes…
• 10109052Sep 14, 2016Engine, Electrical system, Transmission and drivetrain. Some 2015-2016 Escape and 2016 Fusion vehicles equipped with a 2.0L GTDI engine may exhibit a rolling reverse to drive engagement shudder on acceleration. Reprogram the powertrain control module (PCM) to the latest calibration using IDS release 102.01 or higher. Make sure you are connected to the internet when entering module programming to obtain the latest updates. Calibration files may also be obtained at…
• 10079006Aug 31, 2016Body and structure, Other or unknown. Inoperative hands-free liftgate after addition of trailer hitch
• 10092555Aug 18, 2016Visibility (wipers, defrost, mirrors), Equipment, Electrical system. Some 2015-2017 focus/c-max/escape vehicles equipped with one touch up feature. The 2016-2017 workshop manual section 501-11 was updated 8/2016 with revised diagnostics, the 2015 wsm updates will follow later. Refer to the 2016-2017 wsm revised diagnostics for any of the following concerns: one-touch up feature is inoperative, window door glass does not travel fully to either open/closed position,and window bounces…
• 10092386Aug 3, 2016Engine. Some 2015-2016 escape and 2016 fusion vehicles with the 2.0l gasoline turbo direct injection (gtdi) engine may exhibit a rolling reverse to drive engagement shudder on acceleration which continues after tsb 15-0187 has been completed. Engineering is currently investigating this condition. Refer to workshop manual (wsm), section 307-01 for normal diagnostics.
• 10091272Jul 13, 2016Transmission and drivetrain. 2013-2017 fusion/escape/mkz (excluding 3.7l), 2015-2016 edge/explorer (excluding 3.5l/3.7l), 2015-2016 mkc, and 2016 mkx vehicles (excluding 3.7l) equipped with all wheel drive (awd) may exhibit a leaking passenger side power transfer unit (ptu) halfshaft/linkshaft seal. This may be due to a worn ptu bushing. The ptu bushing can now be repaired without ptu replacement.
• 10091269Jul 8, 2016Engine. Some 2013-2016 escape vehicles equipped with 2.5l engine may exhibit a rough idle, low rpm at idle or a stall on hot restart with no dtcs in self test. This may be due to the a/c compressor clutch being seized. If a vehicle comes in for this concern, check the a/c compressor to see if it is engaged during start up/initial run. The pcm strategy keeps the a/c compressor clutch off for 5 seconds on initial start. If…
• 10091142Jun 17, 2016Equipment. 2013-2016 escape,2014-2016 fiesta, transit connect and 2013-2015 fusion vehicles equipped with 1.6l gtdi engine - updated workshop manual (wsm) section 303-03 cooling system
• 10078990May 13, 2016Electrical system. Siri eyes free functional issues using bluetooth and apple ios 9.2 and 9.2.1
• 10078985May 10, 2016Equipment. A/c compressor lockup - vehicles in storage or used infrequently
• 10078979May 4, 2016Tires, Body and structure. Drive minimum 15 miles before diagnosing tire vibrations
• 10205031Apr 20, 2016Equipment. Touchscreen navigation system - arabic language - blank screen
• 10183767Apr 20, 2016Electrical system. Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (FDIM) or an improper software configuration of the FDIM.
• 10183749Apr 5, 2016Electrical system. In some of the affected vehicles, the front control/display interface module (FCDIM) may have been unintentionally programmed for the European market instead of the North American market
• 10205010Mar 17, 2016Engine, Fuel system. 2.0L Ecoboost - Fuel odor
• 10075275Mar 17, 2016Fuel system. 2.0L ECOBOOST - FUEL ODOR ISSUE Some 2013-2016 Escape, 2015-2016 MKC vehicles built on or before 12/15/2015, 2013-2016 Fusion, MKZ, 2013-2015 Explorer, 2013-2014 Focus ST and Edge vehicles equipped with 2.0L EcoBoost engines may exhibit fuel odor originating from the positive crankcase ventilation (PCV) hose. SERVICE PROCEDURE 1. Is the vehicle a 2016 Escape or MKC? a. Yes - check the vehicle build date. Was the…

← All problems reported for the 2015 Ford Escape