1997 Ford F-150 Recalls
NHTSA lists 14 recall campaigns for the 1997 Ford F-150. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Fuel system, gasoline › Storage › Tank assembly › MountingCovers: Ford F-150 1997–2004, F-250 1997–1999, Lincoln Blackwood 2002–2003
Reported issue: Ford is recalling certain 1997 through 2003 model year ford f-150, 2004 model year ford f-150 heritage, 1997 through 1999 model year f-250 less than 8,500 lbs. Gross vehicle weight rating (gvwr), and 2002 and 2003 lincoln blackwood vehicles manufactured from june 20, 1995, through august 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland…
Possible consequence: As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. Either scenario may result in a fuel leak presenting a fire hazard.
Remedy: Ford will notify owners and instruct them to take their vehicles to a ford or lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. Early in this campaign, if replacement straps are not available, dealers may install a cable support under the strap as an interim…
- Vehicle speed controlCovers: Ford F-150 1994–2002, F-250 1994–1999, Expedition 1997–2002 +3 more
Reported issue: On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
Possible consequence: A fire at the switch could occur.
Remedy: By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. Owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed…
- Steering › Gear box › Shaft sectorCovers: Ford F-150 1997, Expedition 1997, F-250 1997
Reported issue: On certain pickup trucks and sport utility vehicles, if the intermediate shaft yoke separates from the steering gear input shaft, the steering system becomes disconnected.
Possible consequence: This could result in loss of steering control, potentially resulting in a vehicle crash without warning.
Remedy: Dealers will inspect the steering intermediate shaft yoke to determine if the yoke is fully seated on the steering gear input shaft. If the yoke is fully seated no service is required. If the yoke is not fully seated and bolt groove and spline is visible, the intermediate shaft and bolt will be replaced as well as…
- Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittingsCovers: Ford F-150 1997, F-250 1997
Reported issue: Vehicle description: light duty pickup trucks manufactured at the kansas city or norfolk assembly plants. The front fuel line assembly could have a hole rubbed through in one of two locations. The first location is below the fuel rail connection where the flexible hose is crimped to the steel tube. The bracket that attaches the front fuel line to the transmission could have been bent during assembly. The second…
Possible consequence: This condition could result in fuel leakage. Fuel leakage in the presence of an ignition source could result in a fire.
Remedy: Dealers will inspect these lines and replace the front fuel line assembly if necessary. Owner notification began october 27, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Exterior lightingCovers: Ford F-150 1997–1998, Windstar 1996–1998, Explorer 1997–1998 +2 more
Reported issue: Vehicle description: mini vans, light pickup trucks, and sport utility vehicles. Off lease canadian vehicles equipped with daytime running lights which meet canadian requirements and not the photometric requirements of fmvss 108, "lamps, reflective devices, and associated equipment." according to ford, the vehicles were imported into the u.s. Erroneously.
Possible consequence: The light given off from the daytime running lights is brighter than allowed by u.s. Standards.
Remedy: Dealers will be advised to deactivate the running light function and to complete any outstanding safety recalls on these vehicles.
- Fuel system, gasoline › Storage › Tank assemblyCovers: Ford F-150 1997–1998
Reported issue: Vehicle description: light duty 4-wheel drive pickup trucks. If the vehicle is overloaded, the rear leaf springs can be overstressed. A fatigue fracture of the spring can occur. The center leaf of the spring can fracture at the forward edge of the spring seat and, in some cases, contact the fuel tank.
Possible consequence: Fuel tank contact can damage the tank and result in fuel leakage. Fuel leakage in the presence of an ignition source can result in a fire.
Remedy: Dealers will inspect the rear springs and install an additional clip on the forward end of the rear springs to prevent fuel tank contact in the event of a leaf fracture. Any fractured springs will be replaced.
- Wheels › Lugs/nuts/bolts/studsCovers: Ford F-150 1997–1998, Expedition 1997–1998, F-250 1997–1998 +1 more
Reported issue: Vehicle description: multi-purpose vehicles and light duty pickup trucks. The lug nuts on these vehicles may not create sufficient clamp load allowing wheel movement in relation to the hub/rotor mounting surface.
Possible consequence: This can result in the loosening of lug nuts, stud fatigue failure, and the potential for a wheel separation from the vehicle, increasing the risk of a vehicle crash.
Remedy: Owners of these vehicles will be receiving two notifications. The first notification, which began in may 1998, will provide an interim repair procedure until parts become available. This interim procedure can be completed by owners or their dealers. It specifies that the lug nut torque must be verified to be 100 lbs…
- Vehicle speed control › Accelerator pedalCovers: Ford F-150 1997–1998
Reported issue: Vehicle description: light duty pickup trucks equipped with a 4.2l engine and originally sold or currently registered in one of the following states: alaska, montana, north dakota, minnesota, wisconsin, new york, vermont, new hampshire, maine, michigan, idaho, wyoming, south dakota, colorado, nebraska, kansas, iowa, missouri, illinois, indiana, ohio, pennsylvania, and massachusetts. The throttle is unable to return…
Possible consequence: Increased brake pedal efforts or some increase in stopping distance could result.
Remedy: Dealers will install a revised pcv system on these vehicles.
- Power train › Automatic transmission › Gear position indication (prndl)Covers: Ford F-150 1997–1998, Expedition 1997–1998, F-250 1997–1998 +1 more
Reported issue: Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. If the automatic transmission shift cable assembly was not fully attached to the steering column bracket, the shift cable assembly can come out of the bracket. The vehicle operator would then not be able to shift the transmission from one of the drive gear positions into the park position even though the gear shift selector would…
Possible consequence: The condition would not allow a disengagement of the transmission from the park position or affect proper neutral start switch operation. Unintended vehicle movement could occur if the parking brake was not set.
Remedy: Dealers will make the proper attachment of the transmission shift control cable to the steering column bracket and add a tie strap to that connection.
- Power train › Automatic transmissionCovers: Ford F-150 1997
Reported issue: Vehicle description: light duty pickup trucks. The transmission bracket end fitting can separate from the shift cable assembly resulting in operator inability to shift the transmission from one of the drive gear positions into the park position.
Possible consequence: This condition can result in unintended vehicle movement if the parking brake is not set.
Remedy: Dealers will install a new transmission shift control cable.
- Seat belts › Front › AnchorageCovers: Ford F-150 1997
Reported issue: The seat elt anchorage attachments are missing or misinstalled on these vehicles.
Possible consequence: A loose fastener can eventually detach and would not properly restrain an occupant in the event of a vehicle accident.
Remedy: Dealers will inspect and, as necessary, repair the seat belt anchorage attachments.
- Vehicle speed controlCovers: Ford F-150 1997
Reported issue: Vehicles originally sold or currently registered in the following states: alaska, montana, north dakota, minnesota, wisconsin, michigan (upper peninsula), new york, maine, vermont, and new hampshire. Operation at highway speeds during extreme cold, northern climate winter conditions, can result in ice forming in the throttle body of the engine.
Possible consequence: This ice can cause the throttle plate to remain in the highway cruising position after the accelerator is released or the speed control is deactivated. Under such conditions, the vehicle stopping distances would be increased possibly resulting in an accident.
Remedy: Dealers will install a foam insulating sleeve on the line from the pcv to the hose fitting on the throttle plate.
- Service brakes, hydraulic › Foundation components › Master cylinderCovers: Ford F-150 1997, F-250 1997, F-350 1997
Reported issue: The retainer clip that holds the master cylinder push rod to the brake pedal arm is missing.
Possible consequence: A loss of service braking can occur increasing the risk of a vehicle accident.
Remedy: Dealers will inspect to verify that the retainer clips are installed and if clips are missing will install clips.
- Equipment › Other › LabelsCovers: Ford F-150 1996–1997, F-250 1996–1997, Explorer 1996 +3 more
Reported issue: The certification labels on the involved vehicles has incorrect rear tire inflation pressure designations. This does not comply with fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Possible consequence: Incorrect inflation pressures could cause premature wear of the rear tires. .
Remedy: Owners will be provided with correct certification labels and instructions for installing these labels. Dealers can install this label if the owner so desires.
NHTSA investigations
- EA11006Fuel Tank Strap Failure Due to CorrosionClosed · May 4, 2011
- PE10036Fuel Tank Strap Corrosion/RustClosed · Sep 7, 2010
- PE01033Steering columnClosed · Sep 17, 2001
- RQ98022Rear suspension spring breakageOpen · Nov 13, 1998
- EA98018Alleged loss of throttle controlClosed · Aug 31, 1998
- PE98021Loss of throttle controlClosed · Apr 1, 1998
- RQ98005Automatic transmission controlClosed · Mar 13, 1998
- RQ98003Ice formation in the throttle bodyClosed · Mar 6, 1998
- EA97027Wheel separationClosed · Dec 24, 1997
- PE97033Wheel separation from vehicleClosed · Jul 14, 1997
- PE97019Failure transmission park engagement/locClosed · May 6, 1997
- EA96020Seat belt anchorage separationClosed · Aug 30, 1996
- PE96030Seat belt anchorage separationClosed · Apr 18, 1996
← All problems reported for the 1997 Ford F-150
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.