2018 Ford F-150 Technical Service Bulletins

418 technical service bulletins (TSBs) are on record for the 2018 Ford F-150. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10144944Aug 23, 2018Brakes. Some 2017-2019 F-Super Duty vehicles may exhibit concerns related to brake drag. Utilize Workshop Manual (WSM) diagnostics in section 206-00 to verify the correct installation of the stoplamp switch. Improper adjustment of the stoplamp switch can cause the brake pedal assembly to lightly apply the brakes resulting in dragging condition.
• 10144917Aug 21, 2018Transmission and drivetrain, Electrical system. Some 2018 F-150 vehicles equipped with a 3.3L Duratec/3.5L EcoBoost/5.0L built on or before 23-Jul-2018 at Dearborn Truck Plant or 31-Jul-2018 at Kansas City Assembly Plant may exhibit an illuminated MIL with DTC P2450 and/or P144C stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
• 10144916Aug 21, 2018Equipment. Some 2015-2018 F-150 vehicles equipped with a 3.3L/3.5L Duratec, 3.5L EcoBoost and 5.0L engine and equipped with a block heater may exhibit a lack of heat concern from the heating ventilation and air conditioning (HVAC) system when operating the vehicle consistently in temperatures that are below -20Å?C (4Å?F). This condition may be due to deposits from the engine coolant becoming trapped in the heater core. Follow…
• 10144911Aug 21, 2018Engine cooling. Some 2015-2018 F-150 vehicles equipped with a 3.3L, 3.5L Duratec, 3.5L EcoBoost and 5.0L engine without a block heater may exhibit a lack of heat concern from the heating ventilation and air conditioning (HVAC) system when operating the vehicle in temperatures consistently below -20 degrees C (4 degrees F). This condition may be due to deposits from the engine coolant becoming trapped in the heater core. Follow the…
• 10144915Aug 17, 2018Engine. Some 2018 F-150 vehicles equipped with a 2.7L EcoBoost and built on or before 27-Nov-2017 may exhibit an intermittent engine stall when coming to a stop while towing. Follow the Service Procedure steps to correct the condition.
• 10144912Aug 16, 2018Equipment. Some 2018 F-150 vehicles equipped with a 3.0L diesel engine built on or before 13-Aug-2018 may exhibit a lack of cooling from the A/C system. Follow the Service Procedure steps to correct the condition.
• 10144938Aug 14, 2018Brakes. Some 2018 F-Superduty/F-150/Explorer/Taurus/Flex/MKT/Fiesta vehicles built on 8-Mar-2018 and through 18-Jun-2018 may exhibit a soft brake pedal and/or long brake pedal travel. Bleed the brake system per Workshop Manual (WSM), Section 206-00. For claiming, use causal part BRAKE and applicable labor operations in Section 02 of the Service Labor Time Standards (SLTS) Manual.
• 10144935Aug 7, 2018Electrical system. Some 2017-2019 F-Super Duty vehicles equipped with BLIS that have had the pickup box removed for upfitter modification may exhibit a BLIS warning message in the message center with no associated DTCs. Using the appropriate Ford scan tool at the latest level, re-configure the BLIS system to correct this concern. These settings can be found under toolbox > module programming > programmable parameters > warning lamps…
• 10144933Aug 7, 2018Brakes. Some 2018 F-Superduty/F-150/Explorer/Taurus/Flex/MKT vehicles built on 8-Mar-2018 and through 18-Jun-2018 may exhibit a soft brake pedal and/or long brake pedal travel. Bleed the brake system per Workshop Manual (WSM), Section 206-00. For claiming, use causal part BRAKE and applicable labor operations in Section 02 of the Service Labor Time Standards (SLTS) Manual.
• 10144932Aug 2, 2018Engine cooling. Some Ford and Lincoln vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit an oil leak from the engine oil pan RTV seal. Replace the oil pan following the procedure in Workshop Manual (WSM) Section, 303-01. After removing the oil pan it is suggested to allow the crankcase to drain overnight to minimize the chance of residual oil contaminating the crankcase sealing rail.
• 10144931Aug 2, 2018Equipment. 2018 F150 vehicles excluding Raptor built at Dearborn Truck Plant on or after 26-Feb-2018 and at Kansas City Assembly Plant on or after 10-Mar-2018 have the AAT sensor located in the right exterior mirror. The AAT sensor is serviced separately from the mirror assembly. If the vehicle is built on or after the dates listed above, do not add the sensor and harness behind the grill. If the sensor is missing from the…
• 10144930Aug 2, 2018Electrical system. Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 not at the latest software level may exhibit Various Performance Related concerns such as Display Operation, Navigation, Voice Recognition, Phone Pairing, Applink, Travel Link, Slow System Response, etc. Check for SYNC software update under the OASIS Tab SYNC selection. If an update is available refer to WSM, Section 415-00 and update the APIM software.
• 10144928Aug 2, 2018Engine cooling. Some 2018 F-150 vehicles equipped with a 5.0L engine may exhibit an illuminated MIL with DTCs P0390 and/or P0394. These DTCs may be caused by low engine oil level. Before performing any diagnosis or repair, make sure the oil level is between the minimum and maximum marks on the oil level indicator. If the oil level is below the minimum mark, diagnose the low oil level concern first. Refer to the Workshop Manual…
• 10144192Jul 17, 2018Transmission and drivetrain, Electrical system. Some 2018 F-150 vehicles equipped with a 2.7L, 3.5L, or 5.0L engine and built on or before 4-May-2018 may exhibit an illuminated MIL with DTC P27B6 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
• 10144205Jul 11, 2018Equipment, Engine. Some 2017-2018 F-150 and 2018 Navigator vehicles equipped with a 3.5L EcoBoost and built on or before 09-Mar-2018 may exhibit excessive oil consumption. If there are no visible external oil leaks, replace both engine valve covers. Refer to Workshop Manual, Section 303-01. For claiming, use causal part 6582 and applicable labor operations in Section 6 of the Service Labor Time Standards (SLTS) Manual.
• 10144198Jul 2, 2018Equipment, Visibility (wipers, defrost, mirrors). Some 2015-2018 F-150, 2017-2018 F-Super Duty, 2018 Expedition/Navigator vehicles equipped with a vista roof opening panel may exhibit a concern with the glass panel brackets. The brackets may crack and/or break apart resulting in symptoms that include but are not limited to binding/sticking, glass stuck open or closed, noisy operation including chatter, rattling, or grinding. The roof opening panel glass brackets…
• 10143109Jun 29, 2018Engine cooling, Equipment. Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. This noise may be caused by a cracked piston skirt. The noise can be isolated to a cylinder using a stethoscope or other suitable listening device. Canceling the affected cylinder will reduce or eliminate…
• 10143104Jun 25, 2018Transmission and drivetrain, Equipment. Some 2018 F-150 vehicles equipped with a 3.0L diesel engine may have DTC U0415 set in the powertrain control module (PCM) after a key on engine off (KOEO) or key on engine running (KOER) self-test. Do not attempt any repairs for this DTC at this time. Monitor OASIS for updates.
• 10143103Jun 22, 2018Equipment, Electrical system. Some 2016-2018 Ford and Lincoln vehicles with SYNC 3 may exhibit an intermittent blue or black screen. Check for SYNC software update under the OASIS Tab SYNC selection. If update is available refer to WSM, Section 415-00 and update APIM software. After Installation Complete pop-up appears, remove USB flash drive and install into IDS tool to update Ford database. Perform a complete ignition cycle by turning the key…
• 10143102Jun 22, 2018Equipment, Electrical system. Various 2016-2018 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the vehicle is at version 2.2 please update the module to the latest software level. After the software is updated make sure you shut the vehicle off, open the door for 2 minutes, then…
• 10143101Jun 22, 2018Equipment, Engine. Some 2017-2018 F-150 vehicles equipped with a 3.5L EcoBoost engine built at Kansas City Assembly Plant on or before 23-Feb-2018 or Dearborn Truck Plant on or before 26-Feb-2018 may exhibit an oil leak from the oil pan RTV seal. Replace the oil pan following the procedure in Workshop Manual (WSM) Section, 303-01. After removing the oil pan, it is suggested to allow the crankcase to drain overnight to minimize the…
• 10143100Jun 22, 2018Engine, Equipment. Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. This noise may be caused by a cracked piston skirt. The noise can be isolated to a cylinder using a stethoscope or other suitable listening device. Canceling the affected cylinder will reduce or eliminate…
• 10143099Jun 20, 2018Equipment, Engine. Some 2018 F150, Navigator and Expedition vehicles equipped with 3.5L EcoBoost engine may experience malfunction indicator lamp (MIL) illumination with Diagnostic Trouble Code(s) DTC P0365 and/or P0369. This may be due to low engine oil level, low engine oil pressure or damaged variable camshaft timing (VCT) phasers. Before performing Powertrain Control and Emissions Diagnostics (PC/ED) Manual diagnostics, inspect…
• 10143097Jun 20, 2018Engine cooling, Transmission and drivetrain, Equipment. Some 2018 F-150 vehicles equipped with a 3.0L diesel engine may have DTC P061B set in the powertrain control module (PCM) after scan tool requested engine speed control. This may include engine speed output state control in data logger, key on engine running (KOER) self-test, or a manual diesel particulate filter (DPF) regeneration where engine speed is increased during the regeneration. Disregard this DTC…
• 10143095Jun 19, 2018Equipment. Some 2013-2018 F-150 and 2017-2018 Expedition/Navigator vehicles may exhibit an intermittent grinding noise coming from the right or left IWE area in 2WD mode. This may be caused by an intermittent leak in the check valve. Before completing any normal diagnosis suspect that the check valve is the root cause of the issue. If the check valve has been ruled out as the root cause for the issue refer to Work Shop Manual…
• 10143086Jun 8, 2018Equipment. Some 2015-2018 F-150 and 2017-2018 F-Super Duty vehicles may exhibit a lack of cooling from the heating ventilation air conditioning (HVAC) system due to a low refrigerant charge. Using an ultraviolet (UV) leak detection light, inspect the condenser near the receiver/dryer cap for the presence of dye. If dye is present, replace the condenser. For claiming, use causal part 19712 and applicable labor operations in…
• 10143085Jun 8, 2018Visibility (wipers, defrost, mirrors), Equipment, Electrical system. 2018 F150 vehicles excluding Raptor built at Dearborn Truck Plant on or after 26-Feb-2018 and at Kansas City Assembly Plant on or after 10-Mar-2018 have the AAT sensor located in the right exterior mirror. The AAT sensor was relocated from the front grill/fascia area. The AAT sensor is serviced separately from the mirror. Refer to Ambient Air Temperature Sensor GSB G0000178 for additional information. The Workshop…
• 10143082Jun 6, 2018Electrical system, Engine. Some 2018 F-150 vehicles equipped with a 3.3L engine built on or before 7-May-2018 at Dearborn Assembly Plant or on or before 31-May-2018 at Kansas City Assembly Plant may exhibit an illuminated MIL and/or runs rough condition with DTC P0192 and/or P0193. Various other DTCs may be set. This may be due to engine harness chaffing at the right cylinder head near connector C1056 at the cylinder head core plug boss.
• 10143076Jun 4, 2018Equipment, Transmission and drivetrain. Some 2017-2018 F-150/Raptor, 2018 Expedition/Mustang/Navigator vehicles equipped with a 10R80 automatic transmission and built on or before 20-Nov-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0741 and P1744 in the powertrain control module (PCM) or transmission control module (TCM). This may be due to a sticking torque converter clutch (TCC) valve in the…
• 10137149Apr 30, 2018Electrical system. Some 2015-2018 F-150 may exhibit a dash panel distortion at the defrost duct area. Engineering is investigating the condition. Do not attempt repair at this time.
• 10137119Apr 27, 2018Other or unknown. Some 2018 Expedition/Navigator vehicles built on or before 24-Feb-2018, 2017-2018 F-Super Duty built on or before 26-Feb-2018 and Transit vehicles built on or before 26-Feb-2018 and 2015-2018 F-150 vehicles built on or before 3-Mar-2018 may exhibit a trailer connected and/or disconnected message in the IPC without a trailer connected. Follow the Service Procedure steps to correct the condition.
• 10137145Apr 25, 2018Engine cooling. Some Ford and Lincoln vehicles equipped with a 2.7L or 3.0L EcoBoost engines may exhibit an oil leak from the engine oil pan RTV seal. Replace the oil pan by performing the published Workshop Manual (WSM) service procedures. After removing the oil pan, it is suggested to allow the crankcase to drain overnight to minimize the chance of residual oil contaminating the crankcase sealing rail.
• 10137143Apr 23, 2018Transmission and drivetrain. Some 2018 F-150, Expedition, Navigator, Transit and Explorer vehicles may exhibit an illuminated MIL with DTC P025A stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump driver module (FPDM) connector. Confirm FPDM connector (F-150 C4336, Expedition/Navigator C433, Transit C433, Explorer C3239) is fully seated prior to performing…
• 10137122Apr 17, 2018Transmission and drivetrain. Some 2018 Expedition/F-150/Mustang/Navigator vehicles equipped with a 10R80 automatic transmission and built on or before 30-Nov-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0721 in the powertrain control module (PCM) or transmission control module (TCM). Follow the Service Procedure steps to correct the condition.
• 10137130Apr 11, 2018Equipment, Electrical system. Some 2018 Ford and Lincoln vehicles equipped with a TCU may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization and/or accessory protocol interface module (APIM) DTC U0198 or no modem electronic serial number (ESN) displayed. To correct this condition, remove the TCU fuse for 5 minutes then reinstall. Make sure you are connected to the internet before retesting.
• 10137127Apr 6, 2018Equipment. Various 2018 vehicles equipped with SYNC or SYNC 3 automatic system updates via WI-FI are unable to connect to the vehicles 4G WI-FI Hotspot. SYNC/SYNC3 with automatic system updates do not support connecting SYNC to the vehicles internal 4G WI-FI Hotspot if equipped. The SYNC automatic update feature must be connected to an external Wi-Fi source to function properly. No repairs should be made in attempt to correct…
• 10137113Mar 30, 2018Equipment. Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10137103Mar 21, 2018Equipment. Some 2018 Mustang equipped with 5.0L engines and F-150 equipped with 2.7L, 3.3L, 3.5L and 5.0L, Expedition, Navigator with 3.5L GTDI Engines may exhibit Diagnostic Trouble Code P0181(Fuel Temperature Sensor A Circuit Range/Performance) after performing Key On Engine Off(KOEO) and Key On Engine Running(KOER) diagnostic tests with cold fuel(Below 50F/10C) in vehicle fuel tank. If vehicle exhibits DTC P0181 after…
• 10137102Mar 21, 2018Equipment. Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 and connected to an iPhone recently upgraded to iOS 11.2.5 may exhibit functional concerns where USB audio playback and App Link will not operate. This may also include, under certain conditions, no Bluetooth streaming. Apple has released iOS 11.2.6 to address this concern. Advise the customer to update the device to iOS 11.2.6 and re-evaluate before…
• 10137101Mar 21, 2018Transmission and drivetrain. Some vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing the VCT solenoid to stick. Before attempting any component diagnosis or replacement of the VCT solenoid, refer to Powertrain Control and Emissions Diagnosis (PC/ED) pinpoint test HK11 to cycle the affected…
• 10137088Mar 12, 2018Equipment, Wheels. Some 2013-2018 F-150/Expedition/Navigator 4x4 vehicles may exhibit an intermittent grinding noise coming from the right front or left front wheel area while accelerating in 2WD mode. Refer to the Workshop Manual (WSM), Section 308-07, Diagnosis and Testing Symptom Chart - NVH > The front axle makes noise in 2H mode only and generally under heavy throttle.
• 10136611Feb 21, 2018Equipment. Some 2016-2018 Ford and Lincoln Vehicle equipped with SYNC 3 and connected to an iPhone recently upgraded to iOS 11.2.5 may exhibit a concern where USB Audio playback and App Link applications will not function properly. This may also include, under certain conditions, no Bluetooth Streaming. Apple is aware of the issue and is working on a resolution with a future iOS release. No repairs should be performed at this…
• 10136610Feb 21, 2018Fuel system. Some 2018 Mustang equipped with 5.0L engines and F-150 equipped with 2.7L, 3.3L, 3.5L and 5.0L engines may exhibit illuminated Malfunction Indicator Light(MIL) with Diagnostic Trouble Code P0181(Fuel Temperature Sensor A Circuit Range/Performance) stored in Powertrain Control Module(PCM) memory. DTC may set if Key On Engine Running(KOER) diagnostic routine is performed with cold fuel(Below 50F/10C) in vehicle fuel…
• 10136608Feb 21, 2018Electrical system. Some 2017-2018 F-150 vehicles built on or before 29-Sep-2017 may exhibit a no crank/no start, auto-start-stop inoperative, illuminated malfunction indicator lamp (MIL) and or powertrain malfunction indicator lamp, transmission shift issues, DTC P061A, U0140, U0401, U0101, U0074 and/or U0037 being set in the PCM, TCM, IPC, FCIM, ABS and/or PSCM. This may be due to the 15525 transmission wire harness not being…
• 10136606Feb 19, 2018Transmission and drivetrain. 2017-2018 F-150/Raptor and 2018 Expedition/Navigator/Mustang vehicles equipped with a 10R80 automatic transmission require a new automatic transmission fluid, MERCONù Ultra Low Viscosity (ULV). It is important to positively identify the transmission and service with the correct fluid. Use only Motorcraft MERCONù ULV Automatic Transmission Fluid XT-12-QULV (WSS-M2C949-A) or equivalent when servicing a 10R80…
• 10136581Feb 16, 2018Transmission and drivetrain. Some 2018 F-150 equipped with 5.0L engines built on or before 3-Jan-2018 may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0316 and/or P0011, P0012, P0016, P0018, P0021, P0022, P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 stored in powertrain control module (PCM) and exhibit no drivability concerns. Follow the Service Procedure steps to correct the condition.
• 10136597Feb 14, 2018Equipment. 2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
• 10136594Feb 14, 2018Visibility (wipers, defrost, mirrors). Some 2015-2018 F-150 vehicles equipped with power folding mirrors may exhibit the mirror housing vibrating while driving, moving freely or not moving to the desired position after the mirror is manually folded. Refer to the Owner's Manual for the power mirror synchronization procedure.
• 10136593Feb 13, 2018Electrical system. Some 2018 F-150, Expedition, and Navigator vehicles may exhibit an illuminated MIL with DTC P0521 stored in powertrain control module (PCM) usually after a crank, no-start event. Refer to Workshop Manual (WSM), Section 303-14 for normal diagnostics. If unable to determine root cause, do not attempt any repairs. Engineering is investigating, monitor OASIS for updates.
• 10136592Feb 9, 2018Electrical system. When connecting the Vehicle Communication Module (VCM) and Integrated Diagnostic System (IDS) or Ford Diagnosis and Repair System (FDRS) to the DLC located on the driver side under the steering column at the GWM, make sure that the ignition is off before connecting the VCM. If the ignition is on or the engine is running during the connection, it can result in various warning lights being illuminated with diagnostic…

← All problems reported for the 2018 Ford F-150