2008 Ford F-250 Recalls
NHTSA lists 7 recall campaigns for the 2008 Ford F-250. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Equipment adaptive/mobilityCovers: Ford F-250 2005–2008, F-350 2005–2008
Reported issue: Comm trans is recalling 108 my 2005-2008 ford e250 and e350 vans built on ford chassis and equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift system accessible for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch…
Possible consequence: A lift occupant can be injured should the lift begin to stow unintentionally.
Remedy: Comm trans is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). Owners may contact ricon at 1-818-267-3000 or comm trans at 901-726-9394.
- Equipment adaptive/mobilityCovers: Ford F-250 2005–2008, F-350 2005–2008
Reported issue: Comm trans is recalling 111 my 2005-2008 ford e250 and e350 vans built on ford chassis and equipped with ricon platform style wheelchair lifts. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations on motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the…
Possible consequence: The user of the lift could be injured should the lift move unintentionally.
Remedy: Comm trans is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). Owners may contact ricon at 1-818-267-3000 or comm trans at 901-726-9394.
- Fuel system, gasoline › DeliveryCovers: Ford F-250 2008, F-350 2008
Reported issue: Ford is recalling 64,754 my 2008 f-250 and f-350 single rear wheel, 4x4, 156 inch wheel base pick up trucks equipped with a two piece drive shaft for failing to conform to the fuel spillage requirements of federal motor vehicle safety standard no. 301, "fuel system integrity." during a 30 mph frontal impact into a rigid barrier, the fuel tank can move forward and contact a frame cross member, potentially causing…
Possible consequence: Fuel spillage, in the presence of an ignition source, could result in a fire.
Remedy: Dealers will install a bracket on the affected vehicles free of charge. The recall began on may 23, 2008. Owners may contact ford at 1-800-392-3673.
- SeatsCovers: Ford F-250 2008, F-550 SD 2008, F-350 2008 +1 more
Reported issue: Ford is recalling 87,515 my 2008 f250, f-350, f-450, and f-550 vehicles for failing to comply with all the requirements of federal motor vehicle safety standard no. 207, "seating systems." some 40% split and captain's chair driver's seats, equipped with lumbar supports, may have improper welds at the joint of the seat back pivot bracket and the seat back frame.
Possible consequence: In the event of a crash, the seat side pivot bracket may crack or break, increasing the risk of injury to the seat occupant.
Remedy: Dealers will add a reinforcement to the driver's seat back frame on the 40% split or captain's chair seat equipped with lumbar support or, if necessary, the seat back frame will be replaced. The recall began on march 28, 2008. Owners may contact ford at 1-800-392-3673.
- Air bags › Frontal › Driver side › Inflator moduleCovers: Ford F-250 2008, Expedition 2008, F-350 2008 +1 more
Reported issue: Certain vehicles fail to conform to the requirements specified in federal motor vehicle safety standard no. 208, 'occupant crash protection.' the driver air bag module may not have been properly assembled.
Possible consequence: This condition may prevent the driver air bag from properly deploying and reduce occupant protection in the event of a crash.
Remedy: Dealers will replace your driver air bag module free of charge. The recall began on november 20, 2007. Owners may contact ford at 1-800-392-3673.
- Power train › Automatic transmission › Control module (tcm/pcm/tecm)Covers: Ford F-250 2008, F-550 SD 2008, F-350 2008 +1 more
Reported issue: On certain trucks equipped with a 6.4l diesel engine, excessive temperatures in the diesel particulate filter in the exhaust system may result from excess hydrocarbons in the exhaust.
Possible consequence: Lack of power or rough operation, unusual noises from the engine or exhaust, white smoke from the exhaust, and potentially a visible flame out the tailpipe can occur.
Remedy: Dealers will reprogram the power train control module. The recall began on april 3, 2007. Owners may contact ford at 1-800-392-3673.
- Electrical system › 12v/24v/48v batteryCovers: Ford F-250 2008, F-550 SD 2008, F-350 2008 +1 more
Reported issue: On certain trucks equipped with a 6.4l diesel engine, insufficient clearance of the battery positive (b+) wire to the right hand splash shield bolt may result in the battery b+ wire contacting the splash shield bolt.
Possible consequence: Long term contact could cause wire chafe, resulting in copper wire being exposed. If this condition occurs, the battery b+ wire could short to ground increasing the risk of a fire.
Remedy: Dealers will inspect the battery b+ wire location and, if necessary, reposition the wire. The recall began on april 3, 2007. Owners may contact ford at 1-800-392-3673.
NHTSA investigations
- PE13014Alleged Loss of SteeringClosed · May 7, 2013
← All problems reported for the 2008 Ford F-250
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.