2005 Ford F Super Duty Technical Service Bulletins

18 technical service bulletins (TSBs) are on record for the 2005 Ford F Super Duty. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10143079Jun 1, 2018Engine, Equipment. Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the…
• 10109021Apr 24, 2017Electrical system. When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The updated 'brown' spark plug boots are longer than the black boots to accommodate a running change in the spark plug length. The ignition coil bodies and spring/resistor are transferable…
• 10109070Sep 21, 2016Engine cooling, Engine. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes…
• 10045340Jul 10, 2012Engine. Ford/lincoln/mercury: if battery was disconnected or dead, vehicles/trucks may experience hard starts and engine idle rpm fluctuation and exhibit diagnostic trouble codes (dtcs) p0505, p0506, p2111 and p2112.
• 10034573Jun 22, 2010Transmission and drivetrain. Ford: some motorhome chassis vehicles equipped with a 6.8l engine may exhibit hesitation, loss of rpm and/or low idle rpm driveability concerns. Reprogram the powertrain control module (pcm) to the latest calibration using ids release 67.04 and higher.
• 10034571Jun 11, 2010Fuel system. Ford: runs rough, lacks power, hard start, no start. Some vehicles and trucks equipped with 6.0l engine may exhibit a runs rough, lacks power, hard to start, no start concern with or without diagnostic trouble code (dtc) p0611 code or various injector circuit codes.
• 10030839Aug 19, 2009Equipment, Transmission and drivetrain. Ford: certain vehicles with ambulance prep package ambulance class action settlement; pcm part number inspection. Awareness communication dated 4/20/09.
• 10030838Aug 19, 2009Equipment. Ford: certain vehicles, e series and f super duty, with ambulance prep package ambulance class action settlement-6.0l diesel engine replacement warranty extension. Awareness communication dated 4/20/09.
• 10030837Aug 19, 2009Equipment. Ford: certain vehicles with ambulance prep package ambulance class action settlement; specific component warranty extension. Awareness communication, dated 4/20/09.
• 10030836Aug 1, 2009Transmission and drivetrain. Ford: multiple vehicles with a torq shift transmission intermittent clunk when shifting between drive, reverse and park and/or during 2-3 upshift. Models f super duty; e series; excursion; f53 motorhome chassis and low cab forward.
• 10029205Jun 1, 2009Engine cooling, Transmission and drivetrain. Ford/mercury/lincoln: vehicles may exhibit one or more of the following symptoms: drive away hesitation, loss of rpm on deceleration, difficulty starting, and/or idle rpm less than desired. The f53 motorhome chassis is included.
• 10028826Jun 1, 2009Engine cooling, Fuel system. Ford: some vehicles with diesel engines may experience no starts, hard starts or rough running when cold and may be accompanied with diagnostic trouble codes (dtcs) p0611, p1378 and/or all 8 injector circuit codes.
• 10028730May 1, 2009Engine cooling. Ford: some vehicles equipped with 6.0l diesel engine may exhibit any one or combination of the following concerns-lack of power, white/black smoke or a surge.
• 10028284Mar 20, 2009Engine cooling. Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. There are several potential causes for these symptoms.
• 10028125Mar 4, 2009Engine cooling. Ford: vehicles may exhibit fuel in the engine coolant, due to leaks in the cylinder head fuel injector area. Symptoms may include fuel in engine coolant and coolant expulsion from the degas bottle. *pe updated 3/20/09.
• 10026387Oct 23, 2008Engine cooling. Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
• 10027985Sep 1, 2008Engine cooling. Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp).
• 10026321May 26, 2008Transmission and drivetrain, Engine cooling. Ford: vehicles mistakenly charged $100 powertrain warranty deductible for fuel injector repair or repairs. No model or model years provided. *pe econoline, excursion and f-series super duty vehicles, model years 2002-2005. Updated 10/24/08. *pe csc letter was received. Updated 10/27/08.

← All problems reported for the 2005 Ford F Super Duty