2005 Ford Five Hundred Recalls
NHTSA lists 2 recall campaigns for the 2005 Ford Five Hundred. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Latches/locks/linkages › Doors › LatchCovers: Ford Five Hundred 2005, Freestyle 2005–2006, Mercury Montego 2005
Reported issue: On certain passenger vehicles currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, utah, vermont, west virginia, wisconsin, and wyoming. The side door…
Possible consequence: As a result, the door latch pawl may not return to the latch position when the door is closed, and the door could open while the vehicle is moving.
Remedy: Dealers will install a shield over the front latches; seal a drain hole in the rear window trim molding on the freestyle rear side doors; and apply grease to all front and rear side-door latch mechanisms free of charge. The recall began on november 8, 2006. Owners may contact ford at 1-800-392-3673.
- Fuel system, gasoline › Storage › Tank assembly › MountingCovers: Ford Five Hundred 2005, Freestyle 2005, Mercury Montego 2005
Reported issue: On certain passenger vehicles, the straps that secure the fuel tank to the vehicle body may break, causing the fuel tank and fuel tank heat shield to drop on the driveshaft (all wheel drive vehicles) or exhaust system (front wheel drive vehicles).
Possible consequence: If this happens, drivers may notice a noise or a fuel leak. A fuel leak in the presence of an ignition source could result in a fire.
Remedy: Dealers will replace both fuel tank straps. The recall began on december 1, 2005. Owners may contact ford at 1-800-392-3673.
NHTSA investigations
← All problems reported for the 2005 Ford Five Hundred
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.