2016 Ford Taurus Technical Service Bulletins

111 technical service bulletins (TSBs) are on record for the 2016 Ford Taurus. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10143103Jun 22, 2018Equipment, Electrical system. Some 2016-2018 Ford and Lincoln vehicles with SYNC 3 may exhibit an intermittent blue or black screen. Check for SYNC software update under the OASIS Tab SYNC selection. If update is available refer to WSM, Section 415-00 and update APIM software. After Installation Complete pop-up appears, remove USB flash drive and install into IDS tool to update Ford database. Perform a complete ignition cycle by turning the key…
• 10143102Jun 22, 2018Equipment, Electrical system. Various 2016-2018 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the vehicle is at version 2.2 please update the module to the latest software level. After the software is updated make sure you shut the vehicle off, open the door for 2 minutes, then…
• 10137131Apr 11, 2018Equipment, Engine cooling. Some 2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Police Interceptor Sedan/Explorer/Police Interceptor Utility vehicles equipped with AWD and built on or before 30-Jun-2016 may exhibit a propane or natural gas odor during idle or low speed driving. This may be due to break down of the power transfer unit (PTU) fluid caused by excessive heat. If the source of the odor is identified as originating from the PTU, an…
• 10137118Apr 11, 2018Body and structure. Some 2014-2018 Taurus vehicles may exhibit the gearshift selector lever bezel door binding, skewed and/or not latching. This may be due to the door post becoming detached from the trim panel door pivot linkage. Follow the Service Procedure steps to correct the condition.
• 10137126Apr 4, 2018Electrical system. Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 version 2.2 software may exhibit a blank screen after attempting to exit Valet mode. SYNC software updates are now available under the OASIS Tab SYNC selection. If update is available, refer to WSM Section 415-00 and update APIM software. For claiming, use causal part 14G371 and applicable labor operations in section 10 of the SLTS manual.
• 10137113Mar 30, 2018Equipment. Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10137075Mar 22, 2018Body and structure. Some 2011-2017 Taurus/Police Interceptor Sedan vehicles may exhibit a loose and/or sagging headliner near the high mounted stoplamp. This may be caused by the headliner mounting bracket separating from the headliner. Follow the Service Procedure steps to correct the condition.
• 10137102Mar 21, 2018Equipment. Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 and connected to an iPhone recently upgraded to iOS 11.2.5 may exhibit functional concerns where USB audio playback and App Link will not operate. This may also include, under certain conditions, no Bluetooth streaming. Apple has released iOS 11.2.6 to address this concern. Advise the customer to update the device to iOS 11.2.6 and re-evaluate before…
• 10137100Mar 19, 2018Electrical system. Various 2016-2017 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the vehicle is at version 2.2 please update the module to the latest software level. After the software is updated make sure you shut the vehicle off, open the door for 2 minutes, then…
• 10136611Feb 21, 2018Equipment. Some 2016-2018 Ford and Lincoln Vehicle equipped with SYNC 3 and connected to an iPhone recently upgraded to iOS 11.2.5 may exhibit a concern where USB Audio playback and App Link applications will not function properly. This may also include, under certain conditions, no Bluetooth Streaming. Apple is aware of the issue and is working on a resolution with a future iOS release. No repairs should be performed at this…
• 10136597Feb 14, 2018Equipment. 2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
• 10140332Jan 29, 2018Electrical system, Equipment. Various 2016-2017 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the vehicle is at version 2.2 please update the module to the latest software level. After the software is updated make sure you shut the vehicle off, open the door for 2 minutes, then…
• 10138533Jan 29, 2018Equipment. Various 2016-2017 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the vehicle is at version 2.2 please update the module to the latest software level. After the software is updated make sure you shut the vehicle off, open the door for 2 minutes, then…
• 10140323Jan 10, 2018Equipment. The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access.
• 10138524Jan 10, 2018Equipment. The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access.
• 10127426Nov 29, 2017Equipment, Electrical system. Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 version 2.2 software may exhibit a blank screen after attempting to exit Valet mode. SYNC software updates are now available under the OASIS Tab SYNC selection. If update is available, refer to WSM Section 415-00 and update APIM software. For claiming, use causal part 14G371 and applicable labor operations in section 10 of the SLTS manual.
• 10127425Nov 29, 2017Equipment, Electrical system. Some owners of 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 may experience inoperative mobile device navigation applications. Mobile device navigation via AppLink requires SYNC 3 version 2.3 or higher for Apple iOS users. Mobile device navigation via AppLink is not currently available for Android users. SYNC software updates are now available under the OASIS Tab SYNC selection. If an update is available…
• 10127424Nov 29, 2017Electrical system, Lane departure, Equipment, Back-over prevention (rear camera). Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may intermittently display an overhead image of a vehicle in the center of the SYNC touchscreen with no obstacle detection grids or warning chimes. SYNC may appear unresponsive when the overhead vehicle image is displayed. The vehicle image may intermittently display after shifting out of reverse or turning the vehicle off when in reverse. SYNC software updates…
• 10127417Nov 22, 2017Equipment. Some 2016-2018 Ford or Lincoln vehicles equipped with SYNC 3 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is due to the power saving features enabled while in transport mode and is beneficial for battery life to keep the vehicle in transport mode until the vehicle is prepped for sale.
• 10127405Nov 2, 2017Electrical system, Transmission and drivetrain. Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the…
• 10125062Oct 10, 2017Transmission and drivetrain. Some 2016-1017 Taurus Police Interceptor vehicles equipped with a 3.5L/3.7L Twin Independent Variable Camshaft Timing (TiVCT) engine may exhibit an inoperative police option accessory that requires a hardwired vehicle speed signal. Follow the Service Procedure steps to correct the condition.
• 10125079Oct 6, 2017Equipment. Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may intermittently display an overhead image of a vehicle in the center of the SYNC touchscreen with no obstacle detection grids or warning chimes. SYNC may appear unresponsive when the overhead vehicle image is displayed. The vehicle image may intermittently display after shifting out of reverse or turning the vehicle off when in reverse.
• 10125078Oct 6, 2017Equipment. Some 2016-2018 Ford or Lincoln vehicles equipped with SYNC 3 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is due to the power saving features enabled while in transport mode and is beneficial for battery life to keep the vehicle in transport mode until the vehicle is prepped for sale.
• 10119684Sep 28, 2017Electrical system. Some owners of 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 may experience inoperative mobile device navigation applications. Mobile device navigation via AppLink requires SYNC 3 version 2.3 or higher for Apple iOS users. Mobile device navigation via AppLink is not currently available for Android users. SYNC 3 software upgrades to support these apps are not currently available, do not attempt any…
• 10119678Sep 21, 2017Electrical system. Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may exhibit an intermittent blue or black screen. Check for SYNC software update under the OASIS Tab SYNC selection. If update is available refer to WSM, Section 415-00 and update APIM software. After Installation Complete pop-up appears, remove USB flash drive and install into IDS tool to update Ford database. Perform a complete ignition cycle by turning the key…
• 10119669Sep 13, 2017Electrical system. Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 version 2.2 software may exhibit a blank screen after attempting to exit Valet mode. To recover the screen, perform a complete ignition cycle (key off, open and close the driver's door then wait 5 minutes). The SYNC software version of the vehicle can be confirmed via OASIS. Do not attempt any repairs at this time. Engineering is investigating; Monitor…
• 10109001Apr 18, 2017Back-over prevention (rear camera), Equipment. Some 2016-2017 Edge, Escape, Expedition, Fiesta, Flex, MKC, MKT, MKX, Mustang, Navigator and Taurus or 2017 Explorer and Super Duty vehicles equipped with SYNC 3 and built on 1-Jul-2015 and through 31-Dec-2016 may exhibit a SYNC display message of Please check your surroundings for safety along with no rear view camera image when in reverse gear. This will occur only at ambient temperatures ranging from -5 Å'C to 5…
• 10109012Apr 12, 2017Equipment, Engine cooling. 2013-2017 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Taurus Police/Explorer/Explorer Police/Continental vehicles equipped with a 3.5L or 3.7L engine, all wheel drive (AWD) and a power transfer unit (PTU) that is being repaired or replaced for an internal failure must also have the vent hose replaced due to contamination in the hose.
• 10100508Mar 23, 2017Electrical system. Some 2016-2017 ford or lincoln vehicles equipped with sync 3 may exhibit a blank screen or other various sync symptoms only when the vehicle is in transport mode. This is considered normal due to the power saving features enabled while in transport mode. It is beneficial for battery life to keep the vehicle in transport mode until the vehicle is prepped for sale.
• 10099451Mar 8, 2017Equipment. Some 2016-2017 f150, edge, mkx, escape, focus, mkc, fusion, mkz, taurus and 2017 continental vehicles equipped with 2.0l, 2.7l or 3.0l gasoline turbocharged direct injection(gtdi) ecoboost engines may exhibit malfunction indicator light(mil) on with diagnostic trouble codes(dtc) p1013, p1015 and/or p1016 stored in powertrain control module(pcm). Check turbocharger wastegate control hoses for water/ice restrictions…
• 10095858Feb 27, 2017Transmission and drivetrain, Equipment. Some 2007-2016 edge/mkx/flex/mkt/mkz/mks/taurus/taurus police/explorer/explorer police equipped with all wheel drive (awd) and built on or before 30-jun-2016 may exhibit a ticking and/or knocking noise coming from the driveline area. To identify this noise, refer to workshop manual (wsm), section 100-04, and follow the symptom chart. If the source of the noise is identified as the ptu and/or internal to the ptu…
• 10095624Feb 2, 2017Transmission and drivetrain. Multiple 2014-2016 vehicles equipped with 6f35 transmission and built on 1-jan-2014 and through 31-dec-2015 may exhibit harsh reverse engagement and harsh/delayed 3rd and 5th gear up/down shifts with no dtcs present. This may be due to a mechanically binding shift solenoid b (ssb). Verify harsh reverse and 3rd and 5th gear shift events are present. Using ids, identify the band number of ssb for use when ordering…
• 10095184Jan 24, 2017Equipment. Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or lincoln vehicle. Only approved genuine ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10095154Jan 10, 2017Engine. To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye is available. Workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. The new white fluorescent dye provides a distinct white glow to identify engine oil leaks. The new white fluorescent dye requires a pure uv diagnostic inspection lamp. The white-colored…
• 10094646Dec 22, 2016Equipment. Some owners of 2016 ford and lincoln mkx vehicles equipped with sync 3 may inquire about upgrading to apple carplay and android auto. This upgrade is not currently available for those vehicles. Apple carplay and android auto are currently available only on vehicles equipped with sync 3 v2.0 or later. This upgrade for 2016 ford and lincoln mkx vehicles will be available in 2017. The sync version can be confirmed via…
• 10095995Nov 17, 2016Steering. Some 2010-2016 epas equipped vehicles may exhibit steering related noises. The workshop manual (wsm) diagnostic procedures have been updated in section 211-02. When diagnosing and repairing epas steering noises use the updated procedures.
• 10095989Nov 11, 2016Equipment. 2017 explorer and 2016 taurus vehicles built on or after 9-jun-2016 no longer have the fuel filler pipe information bezel attached to the fuel filler pipe. The bezel was removed to comply with fuel pump vapor recovery equipment requirements and should not be considered missing. The addition of the information bezel to units built on or after 9-jun-2016 should not be done.
• 10091139Oct 27, 2016Equipment. Certain 2015 model year edge, 2015-2016 model year f-150, mkt, and police interceptor sedan, and 2016 model year escape, explorer, flex, fusion, mkx, mustang, police interceptor utility, taurus, and transit vehicles - electronic throttle body replacement
• 10091127Oct 27, 2016Engine. Some 2016 explorer, flex, mkt, taurus, mks and transit vehicles equipped with a 3.5l gtdi engine may exhibit an illuminated malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p2096, p2097, p2098 and/or p2099 in the powertrain control module (pcm) memory. This may be due to incorrect calibration values setting a system dtc instead of a circuit fault dtc.
• 10091003Oct 26, 2016Tires. Setting the correct tire inflation pressure is an important step in the pre-delivery process and during routine maintenance intervals. Recent customer clinics revealed that most every vehicle in the clinics had the tire pressures set incorrectly. Tire pressures from the factory are not set to the correct specification. Maintaining the correct tire pressure is key to the ride characteristics of the vehicle and…
• 10091151Oct 17, 2016Brakes. Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps…
• 10090681Oct 17, 2016Brakes. Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps…
• 10090671Oct 14, 2016Electrical system. Some 2013-2016 fusion/escape/mkt/flex/mks/taurus, 2015-2016 mkz/mkc/edge and 2016 mkx vehicles may exhibit various radio concerns including: speaker static with key-off, no audio after vehicle is first started with diagnostic trouble code (dtc) u0184, no volume control, or a stuck cd with no slot blockage. Prior to starting normal diagnosis for any of these conditions, verify the acm is at the latest calibration…
• 10090505Oct 10, 2016Engine. Some 2015-2016 f-150, c-max, edge, mks, taurus, and flex and 2016 expedition, explorer, escape, fusion, mustang, mkz, mkx, navigator, transit and transit connect vehicles equipped with a 2.0l, 2.5l, 3.5l or 3.7l gasoline engine and built on or before 31-may-2016 may exhibit an intermittent loss of power and/or an illuminated powertrain malfunction (wrench) lamp with diagnostic trouble codes (dtcs) p2111, p2112…
• 10109079Sep 30, 2016Seat belts. Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
• 10109070Sep 21, 2016Engine cooling, Engine. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes…
• 10109067Sep 19, 2016Electrical system, Equipment. Some 2016-2017 Escape, MKC, Fiesta, F150, Expedition, Navigator, Mustang, Transit, Focus, C-Max, MKX, Taurus, MKS, Flex, MKT, and Edge and 2017 Explorer, Fusion, MKZ, Super Duty, Transit Connect and Continental vehicles equipped with SYNC 3 might exhibit a blank screen or other various SYNC symptoms only when the vehicle is in Transport mode. Engineering is aware of this possibility and it is considered normal due…
• 10109063Sep 16, 2016Transmission and drivetrain. Some 2015-2016 vehicles equipped with 6F50/6F55 transmission Built On 11/2/2015 And Through 2/1/2016 may exhibit no reverse, 3rd and 5th gear and/or DTCs P0715, P0717, P0756 and/or P2701. This may be caused by the direct clutch snap ring out of position and/or damage to the direct clutch hub. The cause of the failure is the Tone Wheel surface putting uneven load on the snap ring.
• 10109085Sep 14, 2016Vehicle speed control. Certain 2015 Model Year Edge, 2015-2016 Model Year F-150, MKT, and Police Interceptor Sedan, and 2016 Model Year Escape, Explorer, Flex, Fusion, MKX, Mustang, Police Interceptor Utility, Taurus, and Transit Vehicles - Electronic Throttle Body Repair
• 10109054Sep 2, 2016Electrical system, Engine cooling. Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 may have DTCs U3000:04, B108E:12 and/or U1A00:87 present in the APIM. If these DTCs are present and no other symptoms are reported by the customer, then clear the DTCs and retest. If the DTC(s) do not return then no further repairs should be attempted. If one or more DTCs return as current faults and/or the customer reports other symptoms, then refer to…

← All problems reported for the 2016 Ford Taurus