2018 Ford Transit Technical Service Bulletins

192 technical service bulletins (TSBs) are on record for the 2018 Ford Transit. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10162076Jun 3, 2019Visibility (wipers, defrost, mirrors), Electrical system. Some 2015-2019 Transit vehicles may exhibit inoperative power door locks and/or power windows due to water intrusion in the door to body harness connector C339 (left) or C340 (right). If corrosion is found, service pigtails JU2Z-14S411-RA (gray) and JU2Z-14S411-PA (black) are released to service the body harness (female) side of the connector, without replacing the entire 14401 body harness.
• 10160940May 23, 2019Exterior lighting. 2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01.
• 10160931May 10, 2019Transmission and drivetrain. On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter…
• 10159494Apr 26, 2019Engine. SSM 47948 - 2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded parts.
• 10159489Apr 26, 2019Equipment, Electrical system. Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the proper diagnosis of this compressor, the EVDC control valve tester has been developed and is available from Rotunda (339-EVDC100). A tester has been provided to each U.S.
• 10159461Apr 17, 2019Body and structure. Some 2015-2019 Transit High-Roof Bus/Passenger Wagon vehicles may experience a loose or unseated headliner at the C and/or C 1/2 pillar(s) causing visible gaps. This may be due to a lack of retention capability of the headliner locator tabs to the pillar block pins. To correct the condition, install repair coupons to the headliner and replace the headliner A/C vent foam gaskets.
• 10159507Apr 11, 2019Electrical system, Fuel system. SSM 47926 - 2018-2019 F-150/Expedition/Navigator/Transit/Explorer - Illuminated MalfunctionIndicator Lamp (MIL) With Diagnostic Trouble Code (DTC) P025A Some 2018-2019 F-150, Expedition, Navigator, Transit and Explorer vehicles may exhibit an illuminated MIL with DTC P025A stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harnessto the fuel pump driver…
• 10159501Apr 1, 2019Transmission and drivetrain. SSM 47903 - 2018-2019 F-150/F-Super Duty/Transit - Rear Axle Pinion Seal Fluid Leak/Seepage Some 2018-2019 F-150, F-Super Duty, and Transit vehicles may exhibit the appearance of a fluid leak or seepage from the rear axle pinion seal. The appearance of a fluid leak or seepage on a vehicle with less than 500 miles or less than 3 months in service may not be due to a failed rear axle pinion seal.
• 10159456Apr 1, 2019Engine cooling. Some 2015-2019 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant becoming trapped in the heater core. To correct the condition, flush the cooling system and replace the heater core.
• 10156525Mar 25, 2019Engine, Transmission and drivetrain. Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195, P2198, P2196, P2197, P0171, P0172, P0174, P0175, P0131 and/or P162F stored in the powertrain control module (PCM). This may be due to undesired water entry into the engine…
• 10156593Mar 18, 2019Suspension, Body and structure. When removing and installing a 2015-2019 Transit front subframe, the cage nuts located in the body of the vehicle may become damaged. If the nut spins in its cage when removing or installing the attachment bolts, the nut can be held with a socket through an access hole in the vehicles frame member. It may be necessary to bend the tabs of the cage up and away from the nut to allow socket placement. The cage nut has…
• 10156566Mar 7, 2019Equipment. Some 2015-2019 Transit High Roof Bus/Passenger Wagon vehicles may have a headliner that does not stay seated at the C and/or C and half pillar hard trim. A permanent repair solution for the existing headliners has been developed and is expected to be available via TSB by late 2nd quarter 2019. Continue to monitor OASIS for updates.
• 10156503Mar 4, 2019Transmission and drivetrain, Engine. Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit Drive To Clean maintenance messages and/or an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2459, P2463, and/or P246C. Vehicles may also exhibit frequent automatic exhaust regeneration attempts. This may be due to vehicles being used in stationary or off-highway, low speed applications.
• 10156887Feb 22, 2019Electrical system. Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool may display an error 232: Key Table Not Allocated. If this error message is encountered, the Body Control Module (BCM) is internally faulted and requires replacement.
• 10155575Feb 22, 2019Electrical system. Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool may display an error 232: Key Table Not Allocated. If this error message is encountered, the Body Control Module (BCM) is internally faulted and requires replacement.
• 10156865Feb 15, 2019Electrical system, Fuel system. Some 2016-2019 Transit vehicles equipped with a 3.2L diesel engine built on or before 7-Feb-2019 may exhibit an illuminated malfunction indicator lamp (MIL) with only diagnostic trouble code (DTC) P054E stored in the powertrain control module (PCM). This may be due to the PCM software. Update the PCM software to resolve the condition.
• 10155553Feb 15, 2019Transmission and drivetrain. Some 2016-2019 Transit vehicles equipped with a 3.2L diesel engine built on or before 7-Feb-2019 may exhibit an illuminated malfunction indicator lamp (MIL) with only diagnostic trouble code (DTC) P054E stored in the powertrain control module (PCM). This may be due to the PCM software. Update the PCM software to resolve the condition.
• 10156859Feb 11, 2019Electrical system, Engine, Fuel system. Some 2016-2018 Transit vehicles equipped with a 3.2L Duratorq diesel engine and built on or before 13-Feb-2018 may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P24A0 and/or P26A0 in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
• 10155447Feb 11, 2019Electrical system, Fuel system. Some 2016-2018 Transit vehicles equipped with a 3.2L Duratorq diesel engine and built on or before 13-Feb-2018 may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P24A0 and/or P26A0 in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
• 10156872Feb 4, 2019Suspension, Brakes. Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the front wheel speed sensor (WSS). Refer to Workshop Manual (WSM), Section 206-09. Using a shop rag, clean any debris from the sensor body as well as the back side of the bearing.
• 10155560Feb 4, 2019Wheels. Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the front wheel speed sensor (WSS). Refer to Workshop Manual (WSM), Section 206-09. Using a shop rag, clean any debris from the sensor body as well as the back side of the bearing.
• 10153969Jan 17, 2019Equipment. Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford are not reimbursable through the Ford Motor Company warranty system. Please see the Warranty and Policy Manual for further information on Ford Licensed Accessories.
• 10153927Jan 15, 2019Steering. Some 2015-2019 Transit vehicles may exhibit a power steering fluid leak at the steering pump or gear. This may be due to a cut or damaged O-ring on the power steering line connection. To repair, refer to parts catalog call out 3334 for service kit BK2Z-3F886-A which contains all four O-rings utilized on the line assembly connections.
• 10153952Dec 19, 2018Seat belts. Some 2015-2019 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front seats and cargo area has been added to the vehicle. Fasteners or holes in the lower b-pillar are indicators that the seat belt retractor mechanism could have been compromised.
• 10153951Dec 19, 2018Equipment, Electrical system. Some 2018-2019 Escape, Transit Connect and EcoSport vehicles equipped with a keyed ignition and a factory invoiced accessory (FIA) VSS may exhibit intermittent alarm activation with lights flashing and the horn sounding after a loud noise and/or shockwave near the vehicle (ex. large truck passing, garage door slamming closed). The root cause of this concern may be an incorrect shock sensor sensitivity adjustment on…
• 10153949Dec 14, 2018Engine cooling, Fuel system. Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Review of repair data supports that P206C is often the result of incorrect diesel exhaust fluid (DEF)…
• 10153948Dec 14, 2018Electrical system. Some 2016-2019 Ford and Lincoln vehicles equipped with SYNC 3 and a 6, 8 or 10 inch screen may show a pop-up message every key cycle that states 'SYNC can check for updates when connected to a WiFi network'. To remove the inconvenience of the pop-up the customer can either connect to a trusted WiFi network to complete the setup process or turn off WiFi in the WiFi settings located under the Settings menu. Adjusting…
• 10152483Nov 28, 2018Seats. 2018-2019 Transit vehicles built on or after 30-April 2018 no longer have front seat track covers on the ends of the seat rails. The vehicle is not misbuilt. The addition of any parts would not be considered a warrantable repair. Do not submit a claim for this condition.
• 10152477Nov 19, 2018Electrical system. Some 2016-2019 Transit vehicles equipped with a 3.2L diesel may indicate a blank PCM when connected to the Ford diagnostic scan tool. Do not replace the PCM. As a work around to access the PCM, remove the key from the ignition for 1 minute. Then remove the PCM relay in the battery junction box. Reinstall the PCM power relay, then put the key in the ignition and turn to on and attempt to access the PCM. Engineering…
• 10152475Nov 19, 2018Electrical system. For 2015-2019 Transit vehicles, multiple fuse assemblies for the high current battery junction box are available for service. Do not replace the high current battery junction box assembly/wire harness to service an open fuse. Use part number BK2Z-14526-A for the 40 amp/100 amp/470 amp assembly, BK2Z-14526-B for the 2x60 amp/2x80 amp/3x100 amp/200 amp assembly, and BK2Z-14S411-A for the 60 amp MIDIù fuses on the…
• 10152473Nov 14, 2018Engine cooling. For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded parts. For all turbocharged engine applications, the turbocharger oil supply filter (6C683 gas engine/6L625 connector style or 6A968 diesel engine) must be replaced whenever the…
• 10154156Nov 2, 2018Transmission and drivetrain. Technical Service Bulletin informing customers of XL Hybrid 130" wheel base Ford Transit vehicles that the front drive shaft of vehicles should be lubricated immediately with grease and then every 6,000 miles subsequently.
• 10152467Nov 1, 2018Engine cooling. Some 2011-2019 F-Super Duty, 2015-2019 Transit, 2016-2019 F-650/F-750 and 2018 F-150 vehicles equipped with a 6.7L, 3.2L or 3.0L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P207F, P20EE, P229F, P2201 and/or P24AE. This may be a result of using aftermarket cleaning liquids or tools for the exhaust gas recirculation (EGR) cooler or intake.
• 10152464Nov 1, 2018Electrical system. When connecting the Vehicle Communication Module (VCM) and Integrated Diagnostic System (IDS) or Ford Diagnosis and Repair System (FDRS) to the DLC located on the driver side under the steering column at the GWM, make sure that the ignition is off before connecting the VCM. If the ignition is on or the engine is running during the connection, it can result in various warning lights being illuminated with diagnostic…
• 10148734Oct 25, 2018Engine. Some 2018-2019 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTC P054E. If DTC P054E is set with any other DTCs, diagnose and repair those DTCs first. If DTC P054E is the only DTC, do not attempt to repair or replace any components, Engineering is investigating. To assist with the investigation, while IDS is open, access Powertrain > OBD Test Modes > Mode 9. Once open, log the…
• 10148711Oct 23, 2018Engine, Transmission and drivetrain, Electrical system. Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195, P2198, P2196, P2197, P0171, P0172, P0174, P0175, P0131 and/or P162F stored in the powertrain control module (PCM). This may be due to undesired water entry into the engine…
• 10148732Oct 22, 2018Equipment. Some 2018-2019 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTC P054E. If DTC P054E is set with any other DTCs, diagnose and repair those DTCs first. If DTC P054E is the only DTC, do not attempt to repair or replace any components, Engineering is investigating. To assist with the investigation use the Report a Vehicle Concern link at the bottom of the OASIS report and fill out…
• 10148703Oct 9, 2018Engine cooling. Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Follow the Service Procedure steps to correct the condition.
• 10149775Sep 24, 2018Exterior lighting. 2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01.
• 10149770Sep 21, 2018Electrical system. Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 may exhibit the Android Auto Preference menu selection is not present after an update to version 3.0 software. In prior versions of SYNC 3 software this menu was present, however in version 3.0 software the Android Auto Preference menu will only show up once an Android Phone has been initially connected to SYNC.
• 10149764Sep 19, 2018Engine cooling. Some 2015-2019 Transit vehicles may have unique accessory drive noise characteristics. Engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during on-vehicle evaluations with warranty returned tensioners. Before attempting a repair for an accessory drive system noise, compare the sound to a like Transit vehicle in similar…
• 10144941Aug 15, 2018Fuel system. 2018 Transit vehicles equipped with 3.7L engine and built on or after 10-Aug-2018 will no longer have foam NVH covers on the fuel rails. This was a running production change, do not submit as mis-build or warranty to change back to the previous model design.
• 10144940Aug 15, 2018Wheels. Some 2015-2018 Transit may exhibit a front wheel bearing type noise or DTCs C0031 and/or C034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the front wheel speed sensor (WSS). Refer to Workshop Manual (WSM), Section 206-09. Using a shop rag, clean any debris from the sensor body as well as the back side of the bearing.
• 10144930Aug 2, 2018Electrical system. Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 not at the latest software level may exhibit Various Performance Related concerns such as Display Operation, Navigation, Voice Recognition, Phone Pairing, Applink, Travel Link, Slow System Response, etc. Check for SYNC software update under the OASIS Tab SYNC selection. If an update is available refer to WSM, Section 415-00 and update the APIM software.
• 10144196Jul 24, 2018Engine cooling, Fuel system, Electrical system. Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit frequent automatic exhaust regeneration attempts. This may be due to vehicles being used in a stationary or off-highway, low speed applications.
• 10144212Jul 20, 2018Equipment, Fuel system. Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Refer to Workshop Manual (WSM), Section 303-04C removal and installation fuel injection pump and disregard align the sprocket key wording.
• 10144201Jul 6, 2018Equipment. Some 2015-2018 Transit vehicles equipped with the Auxiliary Heater / A/C Prep Package 62C are built specifically for A/C system modification. This can be identified on the Professional Technician Society (PTS) website by using vehicle identification number (VIN) > OASIS tab > Vehicle Information > Additional information will be shown as: GZBAC - heater/A/C prep pack.
• 10144181Jul 4, 2018Seats, Equipment. This article supersedes TSB 18-2084 to update the Service Procedure. Some 2013-2018 Transit Connect vehicles built on 1-Jan-2013 and through 5-Jan-2018 may exhibit a condition where either section of the second row seat is stuck or difficult to fold or unfold. This may be due to a misrouted cable or a cable that is in need of adjustment. It may be necessary to reduce the cable end fitting length. It is not…
• 10144184Jul 3, 2018Engine cooling, Fuel system, Equipment. Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit frequent automatic exhaust regeneration attempts. This may be due to vehicles being used in a stationary or off-highway, low speed applications.
• 10144199Jul 2, 2018Engine, Electrical system. Some 2016-2018 Escape/Focus/Transit Connect vehicles equipped with a remote start system may exhibit an immediate engine shut off with or without diagnostic trouble code (DTC) P1594 stored in the BCM after using the remote start function to start the engine. If using FordPass, the app will indicate that the vehicle started successfully, but the engine may not have started or may start and then immediately shut off…

← All problems reported for the 2018 Ford Transit