Skip to content
Forest River XLR ToyhaulerModel year report

2022 Forest River XLR Toyhauler Problems

Complaints
7filed with NHTSA
Median mileage
—no mileage reported
Recalls
6campaigns on record
Trend
Not enough dataFewer than 15 complaints, too few for a reliable trend.

Sources: NHTSA records for the 2022 Forest River XLR Toyhauler (complaints, recalls, investigations). Report an error

NHTSA recorded 7 consumer complaints for the 2022 Forest River XLR Toyhauler. The part named most often is electrical system, with 3 complaints (43% of the total), followed by equipment (3) and other or unknown (2). Of all complaints, 2 a fire, 1 an injury, according to the filers. NHTSA lists 6 recall campaigns and 3 technical service bulletins for this model year. Electrical system complaints overlap with 1 recall campaign covering the inverter and 1 technical service bulletin filed under the same part. Equipment complaints overlap with 5 recall campaigns covering the lines and fittings and 1 technical service bulletin filed under the same part.

This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.

Which parts are reported most

Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.

Example complaints

Electrical system: “On 10/17/2025 while parked at Bethpage Campground in Urbanna, VA, the roof of our RV caught fire. The fire alarms did not sound the only indication was smoke filling the RV. Thankful this was during the day and we were awake. I felt the walls finding nothing hot then went outside and discovered the roof was on fire. I grab the fire extinguisher and climbed the ladder onto the roof and began putting out the fire. Attached are the pictures that show that there are screws/nails and a metal piece that goes through the wiring which caused the fire. …”

NHTSA complaint #11711346, filed 2026-01

Equipment: “My fuel station was not pumping fuel only air because the fuel pump line and fill neck vent hose line on the fuel station where installed from the manufacturer backwards not allowing the fuel to be picked up from the tank to the transfer pump. In an email from the fuel station manufacturer “Your particular unit came from Forest River Plant #79 and had a batch of these units where they installed the lines incorrect, not allowing the pump to pull any fuel.””

NHTSA complaint #11678288, filed 2025-08

Other or unknown: “Electrical breakers continue to trip. Trim issues throughout along with floor bulking in kitchen. Both slides on on right side of camper leak when it rains. First trip out landing jacks did not work to level unit and one of the back glasses in the toy hauler scattered going down the road which was replaced with warranty. We have been trying to get the slide issue looked into for a couple of months but no luck getting a forest river tech to come assess and fix with the additional warranty purchased along with this unit. …”

NHTSA complaint #11464889, filed 2022-05

Brakes: “The failure involves the trailer brake wiring system. The brake wiring harness near the rear bathroom plumbing exit is improperly routed and installed in direct proximity to moving suspension components. This has resulted in repeated abrasion and damage to the brake wiring, causing intermittent and reduced braking capability. The affected components are available for inspection upon request. This condition presents a serious safety hazard. The trailer (approx. …”

NHTSA complaint #11728171, filed 2026-03

Complaints by year filed

Fewer than 15 complaints, too few for a reliable trend.

20222023320252026
Complaints by year the complaint was filed with NHTSA. Red bars: the last 3 full calendar years used for the trend. The current year (2026) is partial.

Recalls and investigations

Recall details for the 2022 Forest River XLR Toyhauler → · Check a VIN at nhtsa.gov/recalls

Technical service bulletins

TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 3 on record; the latest 3 are shown.

Other model years of the Forest River XLR Toyhauler

YearComplaintsMedian miRecallsCrash ★MPGScore (50 = typical)Trend
20227—6———Not enough data
2021111,9004———Not enough data

All Forest River XLR Toyhauler model years

Frequently asked questions

How many NHTSA complaints does the 2022 Forest River XLR Toyhauler have?

NHTSA recorded 7 consumer complaints for the 2022 Forest River XLR Toyhauler as of Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

What part of the 2022 Forest River XLR Toyhauler is reported most often?

Electrical system is named most often, in 3 complaints (43% of the total), followed by equipment with 3.

Has the 2022 Forest River XLR Toyhauler been recalled?

NHTSA lists 6 recall campaigns for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.

About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.