Skip to content
GMC Envoy XL 370Model year report

2004 GMC Envoy XL 370 Problems

Complaints
7filed with NHTSA
Median mileage
98,000miles, 5 complaints with mileage
Recalls
0campaigns on record
Trend
Not enough dataFewer than 15 complaints, too few for a reliable trend.

Sources: NHTSA records for the 2004 GMC Envoy XL 370 (complaints, recalls, investigations). Report an error

NHTSA recorded 7 consumer complaints for the 2004 GMC Envoy XL 370. The part named most often is electrical system, with 3 complaints (43% of the total), followed by exterior lighting (2) and fuel system (2). 5 of the complaints include a mileage, and 0% of those were filed for vehicles with under 50,000 miles; the median is 98,000 miles. NHTSA lists 0 recall campaigns and 83 technical service bulletins for this model year. Electrical system complaints overlap with 13 technical service bulletins filed under the same part. Exterior lighting complaints overlap with 2 technical service bulletins filed under the same part.

This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.

Which parts are reported most

Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.

Example complaints

Electrical system: “The contact owns a 2004 Gmc ENVOY XL 370. The contact stated that all the gauges on the instrument panel failed to provide a reading level. The vehicle was taken to the dealer where it was diagnosed that the instrument cluster needed to be replaced. The vehicle was not repaired. The failure mileage was 73,000.”

NHTSA complaint #10704442, filed 2015-04, 73,000 miles

Exterior lighting: “The contact owns a 2004 Gmc ENVOY XL 370. While driving at various speeds, the left turn signal, headlights, and tail lights failed to operate. In addition, the fuel pump made an abnormal noise after the vehicle was started. The failure recurred numerous times. The contact stated that the trunk door failed to close. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failures. The approximate failure mileage was 177,687.”

NHTSA complaint #10854328, filed 2016-04, 177,687 miles

Engine cooling: “While driving with passengers in car, smoke started to come from the floor area in the back seat area. Immediately drove car to a car service shop to have inspected to determine where smoke was coming from. The car technician was unable to determine where the smoke was coming from other than from the floor area in the back. Have been replacing a radiator because the engine keeps running hot. Had a new radiator installed. Then began to have problems with the anti-freeze disappearing from the radiator and the reservoir. Took car in and had a pressure test performed. …”

NHTSA complaint #10626947, filed 2014-08

Mileage when problems were reported

0% of the 5 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 73,000 and 120,000 miles.

0%0–100%10–250%25–5040%50–7520%75–10020%100–15020%150+
Share of complaints by mileage when the problem was reported, in thousands of miles (5 complaints with mileage). Red bars: under 50,000 miles. Bucket widths differ. Median: 98,000 miles.

Complaints by year filed

Fewer than 15 complaints, too few for a reliable trend.

20082014201532016
Complaints by year the complaint was filed with NHTSA. Red bars: the last 3 full calendar years used for the trend. The current year (2026) is partial.

Recalls and investigations

NHTSA lists no recall campaigns for the 2004 GMC Envoy XL 370 in the data used here. A recall can apply to some vehicles of a model year and not others, so check a specific vehicle by VIN at nhtsa.gov/recalls.

Technical service bulletins

TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 83 on record; the latest 10 are shown.

See all 83 bulletins →

Other model years of the GMC Envoy XL 370

YearComplaintsMedian miRecallsCrash ★MPGScore (50 = typical)Trend
20065116,1400———Not enough data
200510468,0000——Not compared (before 2008)Stable
2004798,0000———Not enough data
20037143,0000———Not enough data

All GMC Envoy XL 370 model years

Frequently asked questions

How many NHTSA complaints does the 2004 GMC Envoy XL 370 have?

NHTSA recorded 7 consumer complaints for the 2004 GMC Envoy XL 370 as of Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

What part of the 2004 GMC Envoy XL 370 is reported most often?

Electrical system is named most often, in 3 complaints (43% of the total), followed by exterior lighting with 2.

Has the 2004 GMC Envoy XL 370 been recalled?

NHTSA lists no recall campaigns for this model year in the data used here. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.

At what mileage are problems with the 2004 GMC Envoy XL 370 reported?

Among the 5 complaints that include a mileage, the median is 98,000 miles and the middle half falls between 73,000 and 120,000 miles; 0% were filed for vehicles with under 50,000 miles.

About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.