2007 GMC Sierra 3500 Technical Service Bulletins

556 technical service bulletins (TSBs) are on record for the 2007 GMC Sierra 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10021673Jun 15, 2007Interior lighting. Ipc backlighting inoperative tbc 2a fuse open.
• 10022477Jun 1, 2007Body and structure. Hood flutter, shake or vibration at highway speeds. (apply flexible adhesive sealer between inner and outer panels).
• 10022470Jun 1, 2007Brakes. Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground).
• 10022369Jun 1, 2007Fuel system. Service update for inventory and customer vehicles e85 virtual flex fuel sensor (vffs) update- reprogram ecm.
• 10022536May 1, 2007Other or unknown. Service update for inventory and customer vehicles. Incorrect gvwr and capacity information.
• 10021853May 1, 2007Other or unknown. Installation instructions for e85 flex fuel emblems and yellow colored fuel caps in support of the e85 ethanol marketing program.
• 10021852May 1, 2007Body and structure. Door trim gap at rearof door.
• 10021841May 1, 2007Engine cooling. Chuggle, surge or hesitation may be felt with active fuel management system cylinder deactivation transition from v8 mode to v4 mode.
• 10021395Apr 24, 2007Brakes. Adding aftermarket trailer brake controller with integrated trailer brake controller.
• 10021394Apr 24, 2007Engine cooling. Harsh tcc apply or tcc cycling.
• 10021287Mar 29, 2007Body and structure. Creaking noise from body.
• 10021133Mar 13, 2007Brakes. Service brake booster message.
• 10021106Mar 1, 2007Engine cooling. Lbz, lly, engine with rough idle, poor performance, black/white exhaust smoke, mil/ses light on and one or more of the following dtc's p003a, p060b, p0230, p0403, p0401, p0606, p2146, p2149, p2152, p2155. (reprogram ecm and replace egr motor or egr valve. *kb updated 04-27-07. *kb updated.
• 10021076Mar 1, 2007Engine cooling. Loss of power when driving in extreme winter weather.
• 10021075Mar 1, 2007Tires. Unable to program tire size in ebcm/vses.
• 10021023Feb 22, 2007Engine cooling. Whine howl noise from the rear differential on vehicles equipped with an 8.6 rear axle.
• 10021021Feb 22, 2007Engine cooling. Service vme. Supplement to 00-02-35-003l. Update on new I-shaft.
• 10021020Feb 22, 2007Tires. Bridgestone duravis tire chip and tear issue.
• 10021019Feb 22, 2007Transmission and drivetrain. Slip condition in 2nd, 3rd, or 4th. Damaged 2-4 or 3-4 clutch. *kb updated 10/31/07.
• 10021016Feb 22, 2007Air bags. Dual stage passenger air bag used in single stage application.
• 10021015Feb 22, 2007Electrical system. Unable to locate emergency light relay and/or blunt cut wires.
• 10021014Feb 22, 2007Steering. Power steering pump leak/ incorrect mounting bolt.
• 10021010Feb 22, 2007Tires. Bridgestone dueler product information update.
• 10021337Feb 1, 2007Air bags. Air bag light on, dtc b0081, set (clear dtc using specific procedure).
• 10021335Feb 1, 2007Visibility (wipers, defrost, mirrors). Front windshield glass optical distortion or stress cracks.
• 10021333Feb 1, 2007Exterior lighting. Turn signals have increased flash rate (reprogram bcm).
• 10012089Feb 1, 2007Steering. Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated.
• 10020917Jan 30, 2007Electrical system. Instrument panel controls (ipc) hard to read.
• 10020887Jan 26, 2007Exterior lighting. Turn signal flashes fast.
• 10020882Jan 26, 2007Tires. Rubber valve stem pressure release learn method.
• 10021118Jan 1, 2007Engine cooling. Humming or buzzing from rear of vehicle and/or possible dead battery. (check fuel pump relay and replace, if necessary).
• 10021116Jan 1, 2007Suspension. Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns.
• 10021101Dec 1, 2006Tires. Information on recognizing tire pressure monitoring (tpm). Avoid damage to the tpm sensor during tire/wheel service.
• 10011126Dec 1, 2006Engine cooling. Various intermittent driveability conditions - hesitation, lack of power, etc.
• 10020895Nov 1, 2006Electrical system. Rear door locks/rear windows/courtesy lamps/rear speakers inoperative, blown fuse, sir dtc codes.
• 10020894Nov 1, 2006Electrical system. Ignition switch diagnostic tips - dtc codes c0561, p1629, p1682, u0101, u0121, u0155 and/or no crank/no start, hvac, radio, on star, power adjustable pedals, and other electrical components inoperative.
• 10020892Nov 1, 2006Brakes. Information on reprogramming ebcm if tech 2 data for rear wheel speed sensors is reversed.
• 10017373Nov 1, 2006Equipment. Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated
• 10020967Oct 19, 2006Electrical system. Delayed or extended cranking dtc p1682.
• 10021011Oct 11, 2006Suspension. Torsion bar front suspension on c1500 models.
• 10020929Oct 11, 2006Brakes. Rear brake pulsation check drum to axle clearance, with rpo jf3 or jf7.
• 10020927Oct 11, 2006Transmission and drivetrain. Allison transmission equipped vehicles setting diagnostic trouble code (dtc) p0877. Vehicles equipped with allison lct1000 mw7 transmission.
• 10021167Oct 9, 2006Fuel system. Diesel fuel system engineering investigation.
• 10020965Oct 5, 2006Engine cooling. Transfer case control module investigation.
• 10020963Oct 4, 2006Electrical system. No crank no start no communication on low speed gmlam. Abs brake fuel gauge oil sir speedo tach temperature u0140, u0151, u0168, u0170, u0172, u0184, u0199, u0200, u0214, volt wheel wire.
• 10011755Oct 4, 2006Body and structure. Tailgate cable slack. This includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated.
• 10020956Oct 1, 2006Suspension. Information to relearn tpm sensors when the drivers information center (dic) displays dashes for all tire pressure.
• 10020948Oct 1, 2006Engine cooling. Diagnostic information on battery draw no start - body control module, bcm power timer.
• 10012561Oct 1, 2006Engine cooling. Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07.
• 10021018Sep 28, 2006Transmission and drivetrain. No movement when the shift lever is moved to d4 or d3. Normal operation when moved to d2 d1 or reverse. *kb updated.

← All problems reported for the 2007 GMC Sierra 3500