2007 GMC Sierra 3500 Technical Service Bulletins

556 technical service bulletins (TSBs) are on record for the 2007 GMC Sierra 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10118619Oct 5, 2012Equipment. This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
• 10253172Oct 1, 2012Transmission and drivetrain. Vibration On Dry Pavement.
• 10253171Oct 1, 2012Transmission and drivetrain. NQG 4WD Models With Noise Vibration On Dry Pavement
• 10247742Oct 1, 2012Electrical system. Computer-Controlled Cranking System (Bump Start) Inoperative.
• 10247741Oct 1, 2012Vehicle speed control, Steering. Various Concerns Related To The IP Backlighting Cruise Control Steering Wheel Controls Horn.
• 10247087Oct 1, 2012Engine cooling. Computer-Controlled Cranking System (Bump Start) Inoperative.
• 10247086Oct 1, 2012Steering, Vehicle speed control. Various Concerns Related To The IP Backlighting Cruise Control Steering Wheel Controls Horn.
• 10246951Oct 1, 2012Equipment. Programming And Activation Of Replacement OnStar Modules.
• 10023423Oct 1, 2012Vehicle speed control. Cruise control inoperative - keywords abs b3894 brake cylinder ebcm inop master module pressure sensor switch trailer. With rpo jl1. *nj models 2007-2013 avalanche, silverado, suburban, tahoe sierra, yukon, yukon denali, yukon xl, yukon denali xl. Updated 12/10/12.
• 10247720Sep 1, 2012Brakes. Stabilitrak/Traction Control OFF With Red Brake Warning Lamp
• 10247704Sep 1, 2012Suspension. Rattle Squeak Clunk Bump Noise From Front Suspension.
• 10247649Sep 1, 2012Electronic stability control. Unwanted Stability Activation And/Or C0710.
• 10247085Sep 1, 2012Equipment. Radio Button Backlighting Inoperative.
• 10247065Sep 1, 2012Suspension. Stabilitrak/Traction Control OFF With Red Brake Warning Lamp
• 10245343Sep 1, 2012Suspension. Rattle Squeak Clunk Bump Noise From Front Suspension.
• 10245288Sep 1, 2012Electronic stability control. Unwanted Stability Activation And/Or C0710.
• 10037570Apr 1, 2012Body and structure. Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012.
• 10022691Feb 1, 2012Brakes. Gmc: unable to communicate with the ebcm dtc u0121. *nj vehicles equipped with jl4. Updated 9/30/08. *pe updated 6/27/11. *pe updated 4/6/12.
• 10043504Jan 1, 2012Electrical system. Gmc/chevrolet: see docuemtn search button for owner letter. Auxiliary battery feed may cause fusible link to melt and open circuit to prevent damage or fire in wiring harness, due to electrical over load.
• 10032332Dec 1, 2011Electrical system. Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). *pe updated 3/26/10. *pe updated 6/6/11. *pe updated 3/12/12.
• 10037184Oct 1, 2011Seat belts. Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11.
• 10022693Jun 1, 2011Electronic stability control. Service stability lamp dtc c0131. *nj updated 4/1/08. *nj updated 6/26/08. *nj updated 12/18/08. *pe updated 8/1/11.
• 10038984Apr 1, 2011Transmission and drivetrain. Gm: some vehicles may have transmission fluid leaking from the coolant lines in cold temperatures.
• 10024522Apr 1, 2011Transmission and drivetrain. Transfer case will not shift possible dtc's c0387 and/or c0569. On vehicles equipped with a magna transfer case rpo nqf. *nj updated 3/15/10. *pe updated on 6/27/2011.
• 10021022Nov 1, 2010Tires. P245/70r17 general ameritrac tire wear vibration. *kb updated 12/13/07. *nj updated 1/30/08. *nj updated 5/25/11.
• 10037129Oct 1, 2010Brakes. Gm: during brake inspections there have been some hairline cracks on the brake pads.
• 10022692Jul 1, 2010Electronic stability control. Service stability lamp dtc c0710. *nj updated 3/25/11.
• 10024625Jun 1, 2010Electrical system. [check trailer wiring] message displayed on dic. With rpo jl1. *nj updated 3/28/11.
• 10024526Jun 1, 2010Electrical system. Service trailer brake message with dtc c1114 and/or c1112. With rpo jl1. *nj updated 3/28/11.
• 10034364Jan 1, 2010Engine cooling. Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined).
• 10028753Feb 1, 2009Air bags, Transmission and drivetrain. General motors: engine running with key off, continuous run; sensing diagnostic module (sdm), no communication, service air bag light illuminated (install diode to solenoid/relay).
• 10023656Feb 1, 2009Transmission and drivetrain. Chevrolet gmc service campaign: see document search button for owner letter. Transmission overheat in extreme cold ambient temperatures - reprogram tcm. Located in alaska and minnesota; canadian yukon and northwest territories only. *nj csc was received. Updated 3/13/08. *nj updated 4/24/08. *nj updated 7/8/09. Csc letter was received.
• 10028485Nov 1, 2008Fuel system. General motors: the fuel gauge being inaccurate and the ses mil illuminated. Could be caused by the rear tank sender float arm contacting the side of the fuel tank or fuel filler spud inside the tank. (chassis cab)
• 10025303Oct 1, 2008Engine cooling. Chevrolet service campaign: see document search button for owner letter. Ecm eeprom - reprogram ecm. All 2007 and certain 2008 cheverolet silverado and express and gmc sierra and savana equipped with 6.6l duramax va diesel (rpo lmm - vin 6) engine. Csc was received. *pe updated 5/5/09. Csc letter was received.
• 10022694Sep 1, 2008Brakes. Service brakes soon message dtc c0299. *nj updated 5/13/08. *nj updated 12/5/08. No hybrids vehicles.
• 10026149Aug 1, 2008Transmission and drivetrain. Gmc: flare and or harsh 2-3 shifts. This condition may be caused by leaking 1-2-3-4 and 3-5-r clutch fluid seal rings (230). Models cadillacs, chevrolets, gmc, hummers, pontiacs. Equipped with 6l80 (rpo myc) or 6l90 (rpo myd) automatic transmission.
• 10023752Aug 1, 2008Electronic stability control. Unwanted stability activation and/or c0710 with lift/lower kits-different tires/wheel. With rpo jl4. *nj updated 12/18/08.
• 10020883Jul 1, 2008Brakes, Equipment. Service stability lamp diagnostic trouble code (dtc) c0561. *kb updated 9/30/08.
• 10026794Jun 1, 2008Fuel system. Gmc: ses mil with dtc p1682. If normal diagnostic does not lead to correction, this concern could be caused by the rear fuel tank sender assembly being mispositioned. It could give an improper fuel level reading to the ecm. *pe updated 3/19/09.
• 10021415Jun 1, 2008Electrical system. Fuel gauge erratic in freezing temperatures p0463. *kb with one of the following engine rpo's: ly2, ly5, ly6. Lh6, l76, l92. Updated 1/30/08. *nj updated 12/5/08.
• 10024527May 1, 2008Exterior lighting. Turn signals flash fast after factory box removed. *nj updated 8/25/08.
• 10021013May 1, 2008Suspension. Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08.
• 10020722May 1, 2008Air bags. Passenger side airbag door does not flush with dash pad/warped. (reposition locking tabs on airbag panel). *kb updated 10/5/07. *nj updated 9/12/08.
• 10024712Apr 1, 2008Engine cooling. Duramax diesel dpf regeneration changes - vehicles equipped with the 6.6 duramax diesel engine rpo code lmm.
• 10023740Apr 1, 2008Engine cooling. Ses light on due to dtc p0101 and/or p0106 - inspect air filter and/or map sensor . With 6.6l diesel engine (rpo, lbz, lly, or lmm). *nj updated 5/13/08.
• 10024793Mar 1, 2008Electrical system. Left or right power outside mirror inoperative (inspect wire harness).
• 10024785Mar 1, 2008Brakes. Diagnostic information on mil/ses with dtc p0171 (fuel trim system lean bank 1) and/or p0174 (fuel trim system lean bank 2) after brake master cylinder replacement.
• 10024601Mar 1, 2008Transmission and drivetrain. Dtc u0101, no engine crank and no tech ii communication with tcm. Equipped with allison lct1000 (rpo-mw7) automatic transmission.
• 10023654Mar 1, 2008Transmission and drivetrain. Chevrolet gmc service campaign: see document search button for owner letter. Front axle vent tube kinked - fluid leak. *nj csc was received. Updated 4/24/08.
• 10024345Feb 1, 2008Transmission and drivetrain, Suspension. Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008.

← All problems reported for the 2007 GMC Sierra 3500