2024 GMC Sierra 3500 Engine Problems
- Complaints
- 8about this part
- Share
- 16%of 51 total for the year
- Median mileage
- 100,000miles
- Trend
- Too newThis model year is less than 4 years old, so a trend is not meaningful yet.
NHTSA recorded 8 complaints about the engine of the 2024 GMC Sierra 3500, 16% of the 51 complaints for this model year. Where a mileage was given, the median is 100,000 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“This 2024 GMC Sierra Heavy Duty has experienced a continuous pattern of major mechanical and electrical failures since early ownership. The vehicle required a complete engine replacement under warranty at approximately 43,626 miles. Since that time, the vehicle has continued to experience repeated injector failures, control module faults, communication errors, and voltage-related system issues. …”
NHTSA complaint #11718551, filed 2026-02“Vehicle lost power, seemed to slip while pulling hills, Exhaust brake didn't seem to work. Dealer determined cause by DTC P209. Tested injector circuit, found loose terminal tension at injector number 6 connector. Replaced Cylinder # 6 injector connector. Did have multiple warning lights. Also submitting because Service Bulletin 23-NA+027 covered up to 2023. Believe it's an ongoing issue since vehicle is a 2024.”
NHTSA complaint #11767003, filed 2026-09“The engine oil drained into the radiator from a flaw in there design in which outrageously high labor cost for the owner of the vehicle they put a rubber house in the radiator in which leaked without any warning indicating that there was a problem with the oil nor the radiator coolant system. …”
NHTSA complaint #11700192, filed 2025-11“The contact owns a 2024 GMC Sierra 3500. The contact stated that while driving at various speeds, there was an abnormal knocking sound coming from the vehicle. There were no warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed; however, the cause of the failure was not yet determined. The contact was advised by the local dealer that the engine might need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.”
NHTSA complaint #11658087, filed 2025-05, 100,000 miles“First incident we were driving on the interstate towing a fifth wheel RV, and several warning lights illuminated before everything just shut down. Manage to get to the side of the road. Vehicle finally restarted and the rest of the trip was uneventful. Second incident, vehicle had not run for two days, got in and while the starter cranks, the engine will not start or run. Engine/Transmission service and fuel system service messages showing on app and on email from OnStar. Vehicle requires towing to dealer.”
NHTSA complaint #11622920, filed 2024-10Related service bulletins
- 11025492Nov 6, 2025Under Field Actions N252494000, N252494001, the service procedure includes performing a PICO test on vehicle engines within the identified suspect VIN population. If the engine…
- 11024330Sep 6, 2025This technical bulletin provides a procedure to replace the camshaft actuator magnet to correct customer concerns of engine related shudder.
- 11026101Jun 5, 2025This bulletin provides a procedure to check and replace the oil cooler seals before just replacing the oil cooler, for an oil leak.
- 11026017Jun 5, 2025This service bulletin provides information on replacing the intake manifold when the engine is replaced after severe internal engine damage.
- 11024486May 16, 2025This bulletin advises the tech to inspect deeper into what may be to main cause of an engine failure.
- 11024485May 15, 2025The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the…
- 11020254May 7, 2025This service bulletin provides information to dealership personnel for new vehicles with less than 1,000 miles that may not pass California smog inspection or smog inspection in…
Engine: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 2 | 12% |
| 2024 | 8 | 16% |
| 2023 | 3 | 11% |
| 2022 | 3 | 9% |
| 2021 | 3 | 15% |
| 2020 | 6 | 12% |
| 2019 | 2 | 15% |
| 2018 | 1 | 7% |
| 2017 | 2 | 15% |
| 2016 | 5 | 26% |
| 2015 | 4 | 13% |
| 2014 | 1 | 14% |
| 2013 | 2 | 14% |
| 2012 | 3 | 33% |
| 2011 | 1 | 5% |
| 2008 | 1 | 4% |
| 2007 | 2 | 13% |
| 2005 | 1 | 4% |
| 2002 | 1 | 5% |
| 2001 | 2 | 6% |
Other parts of the 2024 GMC Sierra 3500
16 complaintsTransmission and drivetrain
13 complaintsBrakes
11 complaintsOther or unknown
7 complaintsFuel system
5 complaintsSteering
5 complaintsBody and structure
4 complaintsLatches, locks and linkages
2 complaintsVehicle speed control
2 complaintsWheels
2 complaintsAir bags
1 complaintsBack-over prevention (rear camera)
1 complaints
← All problems reported for the 2024 GMC Sierra 3500
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology