2005 GMC Sierra Suspension Problems
- Complaints
- 9about this part
- Share
- 8%of 117 total for the year
- Median mileage
- 60,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 9 complaints about the suspension of the 2005 GMC Sierra, 8% of the 117 complaints for this model year. Where a mileage was given, the median is 60,000 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“I have issues with my alignment, dealership can not fix the problem it has been in service 9 times for the alignment. I also have knocking noise and a steering shaft problem again dealership has not resolved the issue.”
NHTSA complaint #10184347, filed 2007-03, 2,100 miles“The rear upper frame mount for the shock absorber failed due to corrosion. The non-paint rubberized coating placed on the entire frame of this vehicle is flaking off and exposing the bare steel to the elements. The frame of this vehicle has more rust than should be expected on a 50 year-old truck but it is less than eight years old. The truck is well taken care of and the body shows no signs of rust. The failure of the non-paint rubberized frame coating has rendered this 2005 Sierra un-drivable.”
NHTSA complaint #10519909, filed 2013-06, 106,000 miles“Front driver side and passenger side wheel bearings and ABS sensors went bad. I have spoke to other owners of similar vehicles and they also had trouble.”
NHTSA complaint #10254385, filed 2009-01, 43,000 miles“The contact owns a 2005 Gmc Sierra. While driving 45 MPH the left front driver side tire had begun to wobble. Moments later, the tire had suddenly locked, which caused the vehicle to come to a complete stop. A mechanic stated that the wheel bearing needed to be replaced. The current and failure mileages were 60000.”
NHTSA complaint #10294930, filed 2009-12, 60,000 miles“The contact owns a 2005 Gmc Sierra 2500hd. The contact stated that when attempting to brake at low speeds, the front end would shake and the braking distance would increase. The contact also stated that the vehicle would pull toward the right when the failure occurred. An authorized dealer stated that this was a known failure, but this year, make and model was not recalled. The failure and current mileages were 72,000. Updated 02/09/12 the front wheel bearing assembly and sensor were replaced. Updated 02/13/12”
NHTSA complaint #10442566, filed 2012-01, 72,000 milesRelated service bulletins
- 10108599Jul 17, 2017This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
- 10112519Oct 29, 2012This Preliminary Information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. Technician should not replace…
- 10021013May 1, 2008Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08.
- 10024345Feb 1, 2008Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008.
- 10021116Jan 1, 2007Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns.
- 10021100Dec 1, 2006Rear drive axle whine noise (replace slip yoke assembly).
- 10020874Sep 23, 2006Left front axle shaft difficult to remove. Axle differential leak seal shaft.
- 10019852Mar 1, 2006Revised upper control arm replacement.
- 10019513Feb 1, 2006Information on p245/75r16 goodyear wrangler st tire usage/identification.
- 10017308Nov 2, 2005Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005).
Suspension: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2017 | 2 | 3% |
| 2016 | 1 | 17% |
| 2015 | 1 | 2% |
| 2014 | 5 | 5% |
| 2012 | 2 | 7% |
| 2011 | 1 | 2% |
| 2010 | 1 | 3% |
| 2009 | 1 | 3% |
| 2008 | 1 | 1% |
| 2007 | 2 | 3% |
| 2006 | 6 | 11% |
| 2005 | 9 | 8% |
| 2004 | 3 | 2% |
| 2003 | 6 | 3% |
| 2002 | 12 | 5% |
| 2001 | 15 | 6% |
| 2000 | 25 | 6% |
| 1999 | 39 | 7% |
| 1998 | 11 | 6% |
| 1997 | 11 | 5% |
| 1996 | 4 | 2% |
| 1995 | 2 | 1% |
| 1994 | 2 | 1% |
| 1993 | 1 | 1% |
| 1990 | 2 | 11% |
| 1988 | 1 | 17% |
Other parts of the 2005 GMC Sierra
37 complaintsElectrical system
23 complaintsSteering
11 complaintsTransmission and drivetrain
11 complaintsEngine cooling
9 complaintsEngine
8 complaintsBody and structure
7 complaintsAir bags
6 complaintsVehicle speed control
6 complaintsFuel system
5 complaintsTires
4 complaintsVisibility (wipers, defrost, mirrors)
3 complaints
← All problems reported for the 2005 GMC Sierra
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology