2004 GMC Sierra Suspension Problems
- Complaints
- 3about this part
- Share
- 2%of 188 total for the year
- Median mileage
- 13,996miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 3 complaints about the suspension of the 2004 GMC Sierra, 2% of the 188 complaints for this model year. Where a mileage was given, the median is 13,996 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“While driving at 5 MPH or greater,and when turning left, there was a loud popping noise in the front suspension. Owner took the vehicle to the dealer, and was informed that the front torsion bar, and the left control arm came out of place. Also, the front cross member brace came loose.”
NHTSA complaint #10113686, filed 2005-03, 5,400 miles“Dt: the contact stated the front brake lines were rubbing against the caliper, causing a hole/loss of fluid, and failure in the brakes. The vehicle was taken to a dealership, where they replaced the brake line, and placed a rubber boot where the wearing occurred. The dealership said defect was a result of the suspension modification to the vehicle. The contact took the vehicle to another mechanic, who stated the rubber boot would not stop the wearing, and the modification could not have caused the problem.”
NHTSA complaint #10145605, filed 2005-12, 13,996 milesRelated service bulletins
- 10108599Jul 17, 2017This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
- 10112519Oct 29, 2012This Preliminary Information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. Technician should not replace…
- 10021013May 1, 2008Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08.
- 10024345Feb 1, 2008Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008.
- 10021116Jan 1, 2007Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns.
- 10021100Dec 1, 2006Rear drive axle whine noise (replace slip yoke assembly).
- 10020874Sep 23, 2006Left front axle shaft difficult to remove. Axle differential leak seal shaft.
- 10019852Mar 1, 2006Revised upper control arm replacement.
- 10017308Nov 2, 2005Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005).
Suspension: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2017 | 2 | 3% |
| 2016 | 1 | 17% |
| 2015 | 1 | 2% |
| 2014 | 5 | 5% |
| 2012 | 2 | 7% |
| 2011 | 1 | 2% |
| 2010 | 1 | 3% |
| 2009 | 1 | 3% |
| 2008 | 1 | 1% |
| 2007 | 2 | 3% |
| 2006 | 6 | 11% |
| 2005 | 9 | 8% |
| 2004 | 3 | 2% |
| 2003 | 6 | 3% |
| 2002 | 12 | 5% |
| 2001 | 15 | 6% |
| 2000 | 25 | 6% |
| 1999 | 39 | 7% |
| 1998 | 11 | 6% |
| 1997 | 11 | 5% |
| 1996 | 4 | 2% |
| 1995 | 2 | 1% |
| 1994 | 2 | 1% |
| 1993 | 1 | 1% |
| 1990 | 2 | 11% |
| 1988 | 1 | 17% |
Other parts of the 2004 GMC Sierra
74 complaintsElectrical system
39 complaintsTransmission and drivetrain
18 complaintsSteering
14 complaintsBody and structure
9 complaintsFuel system
8 complaintsVehicle speed control
8 complaintsVisibility (wipers, defrost, mirrors)
7 complaintsAir bags
5 complaintsEngine
5 complaintsEngine cooling
4 complaintsTires
4 complaints
← All problems reported for the 2004 GMC Sierra
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology