2004 Honda CBR600RR Problems
- Complaints
- 7filed with NHTSA
- Median mileage
- 2,274miles, 3 complaints with mileage
- Recalls
- 1campaigns on record
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
Sources: NHTSA records for the 2004 Honda CBR600RR (complaints, recalls, investigations). Report an error
NHTSA recorded 7 consumer complaints for the 2004 Honda CBR600RR. The part named most often is brakes, with 6 complaints (86% of the total), followed by electrical system (1). 3 of the complaints include a mileage, and 100% of those were filed for vehicles with under 50,000 miles; the median is 2,274 miles. Of all complaints, 4 involved a crash, 1 an injury, according to the filers. NHTSA lists 1 recall campaign and 6 technical service bulletins for this model year. Brakes complaints overlap with 1 recall campaign filed under the same part. Electrical system complaints overlap with 1 technical service bulletin filed under the same part.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Brakes6 86%
- Electrical system1 14%
Example complaints
Brakes: “After complaining about the brakes while driving at 30 MPH the brakes locked up and the motorcycle slid into a vehicle. Consumer later received recall 04v387000.”
NHTSA complaint #10097619, filed 2004-10, 2,274 milesElectrical system: “Dt:when turning on bright light switch while driving the engine dies and the lights go out, this intermittent in nature. Did contact manufacturer, who not concerned, told consumer to take to dealer. Consumer took vehicle to the dealer, who said they did not have to replace part because this was a ground wire problem after being originally diagnosed as a battery issue which was replaced and did not remedy problem. Dealer agreed to fix problem which consumer had to pay for, but has not had any problems since repair.”
NHTSA complaint #10128902, filed 2005-08, 650 milesMileage when problems were reported
100% of the 3 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 650 and 4,000 miles.
Complaints by year filed
Fewer than 15 complaints, too few for a reliable trend.
Recalls and investigations
- 04V387000Aug 5, 2004Service brakes, hydraulic › Pedals and linkagesCovers: Honda CBR600RR 2003–2004
On certain motorcycles, the rear brake linkage is susceptible to corrosion which can cause binding and rough brake operation. As corrosion increases, it can cause a sticking pedal or require high brake pedal effort.
Recall details for the 2004 Honda CBR600RR → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 6 on record; the latest 6 are shown.
- 10128531Aug 6, 2014Air bags. Dealer message - On Monday, June 23, 2014, American Honda announced three recalls for various 2001-11 Honda models. As of August 4, 2014, affected VINs have been identified, and VIN status inquiry…
- 10128559Jul 23, 2014Air bags. Dealer message - On Monday, June 23, 2014, American Honda announced three recalls for various 2001-11 Honda models. As of July 23, 2014, affected VINs have been identified, and service bulletins…
- 10128872Jul 3, 2014Seats. Honda technician newsletter - Rider Seat InstallationWhen installing the rider seat on NM4, be sure to insert the front two prongs (one on each side) into their respective stays. If these prongs are…
- 10025523May 31, 2008Equipment. Load carrying capacity reduced label for all honda vehicles.
- 10032953May 9, 2008Electrical system. Honda: warranty extension-vehicle warranty mileage. Class action lawsuit alleging that the odometers on certain 2002-2006 honda models were overstating mileage. Federal court provided final approval…
- 10013898May 1, 2004Equipment. Service manual correction.
Other model years of the Honda CBR600RR
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 2026 | 7 | 900 | 1 | — | — | — | Too new |
| 2004 | 7 | 2,274 | 1 | — | — | — | Not enough data |
All Honda CBR600RR model years
Frequently asked questions
How many NHTSA complaints does the 2004 Honda CBR600RR have?
NHTSA recorded 7 consumer complaints for the 2004 Honda CBR600RR as of Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 2004 Honda CBR600RR is reported most often?
Brakes is named most often, in 6 complaints (86% of the total), followed by electrical system with 1.
Has the 2004 Honda CBR600RR been recalled?
NHTSA lists 1 recall campaign for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 2004 Honda CBR600RR reported?
Among the 3 complaints that include a mileage, the median is 2,274 miles and the middle half falls between 650 and 4,000 miles; 100% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.