2016 Jeep Compass Technical Service Bulletins

145 technical service bulletins (TSBs) are on record for the 2016 Jeep Compass. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10224022Nov 5, 2020Transmission and drivetrain. (Rev. A) Power Inverter Load Ratings
• 10184699Nov 5, 2020Electrical system, Equipment. (Rev. A) Power Inverter Load Ratings
• 10184399Nov 5, 2020Electrical system. (Rev. A) Power Inverter Load Ratings
• 10223512Jun 24, 2020Fuel system. THROTTLE BODY For clarification, only use 68414676A$ on 2010 & earlier vehicles as supply is limited.
• 10177457Jun 24, 2020Engine. THROTTLE BODY For clarification, only use 68414676A$ on 2010 & earlier vehicles as supply is limited.
• 10223509Jun 17, 2020Transmission and drivetrain. TRANSMISSION, 5 Speed On replacing OE transmission 05106567A$/68042567A$ with reman transmission R8142074A$ replace with new Hydraulic Clutch Tube 05273429A$ to avoid interference with shift lever
• 10223508Jun 17, 2020Transmission and drivetrain. TRANSMISSION, 5 Speed Replacing OE transmission 05106789A$/68042789A$ with reman transmission R8142073A$ replace with new Hydraulic Clutch Tube 05273429A$ to avoid interference with shift lever
• 10177454Jun 17, 2020Transmission and drivetrain. TRANSMISSION, 5 Speed On replacing OE transmission 05106567A$/68042567A$ with reman transmission R8142074A$ replace with new Hydraulic Clutch Tube 05273429A$ to avoid interference with shift lever
• 10177453Jun 17, 2020Transmission and drivetrain. TRANSMISSION, 5 Speed Replacing OE transmission 05106789A$/68042789A$ with reman transmission R8142073A$ replace with new Hydraulic Clutch Tube 05273429A$ to avoid interference with shift lever
• 10223532Jun 5, 2020Transmission and drivetrain. Service 4wd Light On, Message AWD System Service Required
• 10175743Apr 30, 2020Equipment, Body and structure. Disinfectant Solution Recommended for COVID-19
• 10175735Apr 22, 2020Equipment, Electrical system. Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
• 10175733Apr 21, 2020Fuel system. Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
• 10175674Apr 17, 2020Steering. Hands On Steering Wheel Message In EVIC
• 10175501Mar 27, 2020Vehicle speed control. Speed Control Operates Intermittently
• 10175088Mar 27, 2020Vehicle speed control. Speed Control Operates Intermittently
• 10174168Mar 27, 2020Electrical system, Equipment. Speed Control Operates Intermittently
• 10173328Feb 26, 2020Electrical system, Equipment. Key Programming, Security Pin Request, Pin Invalid
• 10170408Dec 19, 2019Electrical system. No Start After Powertrain Control Module (PCM) Replacement and/or Reprogramming
• 10170314Dec 11, 2019Suspension. Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Replace only the part deemed failed by the diagnostics performed.
• 10220101Nov 20, 2019Body and structure. Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10220099Nov 20, 2019Body and structure. Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10220098Nov 20, 2019Visibility (wipers, defrost, mirrors). Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass.
• 10220097Nov 20, 2019Equipment, Body and structure. Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10169249Nov 20, 2019Equipment, Body and structure. Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10169247Nov 20, 2019Equipment. Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10169246Nov 20, 2019Visibility (wipers, defrost, mirrors). Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass.
• 10169245Nov 20, 2019Body and structure. Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10220071Nov 1, 2019Engine cooling. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10169219Nov 1, 2019Fuel system, Engine. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10166537Aug 7, 2019Equipment. RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10223711Jul 12, 2017Transmission and drivetrain, Air bags, Electrical system. Electronic Shifter Module (ESM) Special Notes below from previous Techtips; NOTE 1: If mismatch between shifter NIK and PRNDM occur, it may appear that the PRNDM will not light up the first time the shifter is woken up via CAN. Please wait 2 minutes 15 seconds for the PRNDM lights to come back on. This is due to a software update feature of the Shifter lower (04670682A$). During PRNDM software update, the shifter…
• 10138863Jun 21, 2017Engine cooling. Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block Interface leaks. Using dye will assist in determining source of leak. Ensure OFA Cap Oring is seated in the proper groove in the cap and not damaged or cut. Engineering is seeking…
• 10219831Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10138856Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10219830Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10138855Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10217524Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10139992Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10217521Mar 15, 2017Fuel system. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121845Nov 30, 2016Electrical system. Hands Free Module - Convergence Telematics Module (CTM) Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state…
• 10121844Nov 30, 2016Electrical system. RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features. Please reference; 8T - Navigation/Telecommunication…
• 10121862Nov 10, 2016Transmission and drivetrain. Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: P0335 - Crankshaft Position Sensor Circuit…
• 10121825Nov 2, 2016Electrical system. Rear Differential If you are diagnosing 2016 model year vehicle with a shudder issue while the vehicle is turning complete the following diagnostics.~ Drive the vehicle forward approximately 15 feet.~ Bring the vehicle to a complete stop.~ Turn the steering wheel approximately 270 degrees, either direction will be fine. Apply light throttle to move the vehicle into the turn.~ If the shudder is felt repeat the steps…
• 10223865Sep 21, 2016Engine cooling. Radiator Hose, Radiator Cap This GPOP is for two issues: 1) Part Number 05058172A. Look for folded hose at the clamped end of the hose 2) Part Number 4596198. If leak is coming from the cap, change only the cap and retest.~ For any questions about this TechTip call Sergio Santi. cell phone: (248) 613-1978 If no response in 15 minutes, please continue with repair.~
• 10223830Sep 14, 2016Wheels. Incorrect Wheel Certification Label This bulletin involves installing new wheel rim size overlay labels. Incorrect wheel rim size printed on certification label.
• 10223855Sep 7, 2016Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has…

← All problems reported for the 2016 Jeep Compass