2020 Jeep Gladiator Technical Service Bulletins

685 technical service bulletins (TSBs) are on record for the 2020 Jeep Gladiator. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11014532Feb 19, 2025Body and structure. Exterior Rear View Mirror Stained And Will Not Clean.
• 11014408Feb 18, 2025Engine. Engine Rattle Noise
• 11014266Feb 14, 2025Body and structure, Electrical system. Defogger Is Not Working. Terminal Detached From The Glass.
• 11014337Feb 11, 2025Electrical system. Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)
• 11014264Feb 11, 2025Electrical system. Cluster Warning Lamp is on, Service 4WD Message
• 11014231Feb 10, 2025Engine. "3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left…
• 11014094Feb 8, 2025Transmission and drivetrain. Clutch Overheat, And/Or Service Transmission Illuminated. Diagnostic Trouble Code (DTC) P08A6 – Gear Lever Position Sensor System – Multiple Sensor Correlation, Set Only In 4Low.
• 11013597Feb 1, 2025Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ●…
• 11013171Jan 25, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11013625Jan 21, 2025Other or unknown. Evaporator - air conditioning
• 11013003Jan 17, 2025Fuel system. FUEL VAPOR CANISTER FILTER EVAP Fuel Filters are to be checked for restriction / blockage on a regular schedule. If the Filter is restricted or blocked then replace the part.
• 11013016Jan 15, 2025Transmission and drivetrain. D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. **Customers may also comment on one or more of the following: ●…
• 11012777Jan 7, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11012293Dec 16, 2024Other or unknown. FILTER - AIR
• 11012292Dec 16, 2024Other or unknown. FILTER - AIR
• 11011921Dec 14, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch"
• 11011895Dec 14, 2024Electrical system. Jeep Bluetooth Speaker Does Not Charge
• 11011901Dec 11, 2024Other or unknown. Warranty Bulletin ID-23-03 Rev. H 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11011898Dec 11, 2024Other or unknown. Warranty Bulletin D-23-04 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11011505Dec 4, 2024Body and structure. Buzz Squeak Rattle (BSR) From Speaker Sound Bar At High Volume Level.
• 11011504Dec 4, 2024Body and structure. Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.
• 11011150Nov 20, 2024Body and structure. COVER KIT - HOOD
• 11011171Nov 12, 2024Steering. DAMPER - NONE
• 11010487Nov 9, 2024Steering. FCA Caribbean Warranty Bulletin ID-23-10 Rev. A (XF1) Steering Damper – Select 2018 - 2020 Jeep Wrangler (JL), 2020 Jeep Gladiator (JT) and 2018 Jeep Wrangler (JK)
• 11010476Nov 9, 2024Steering. "Air Trapped in Steering Damper Warranty Extension XF1 A shimmy in the steering wheel after hitting an irregularity on the road surface (symptom is more prevalent in cold temperatures). This bulletin involves replacing the steering damper."
• 11010511Nov 8, 2024Electrical system, Wheels. Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
• 11010496Nov 8, 2024Steering. Warranty Bulletin D-23-09 Rev. A (XF1) Steering Damper – Select 2018 - 2020 Jeep Wrangler (JL), 2020 Jeep Gladiator (JT) and 2018 Jeep Wrangler (JK)
• 11010473Nov 7, 2024Steering. "Air Trapped in Steering Damper Warranty Extension XF1 A shimmy in the steering wheel after hitting an irregularity on the road surface (symptom is more prevalent in cold temperatures). This bulletin involves replacing the steering damper."
• 11010259Nov 2, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11009540Oct 31, 2024Steering, Electrical system. Heated Steering Wheel Inoperative And Or Not Hot Enough.
• 11008973Oct 16, 2024Engine. FCA Caribbean Warranty Bulletin ID-23-03 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11008972Oct 16, 2024Engine. Warranty Bulletin D-23-04 Rev. F 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11009027Oct 15, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch. "
• 11008913Oct 10, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11009561Oct 3, 2024Electrical system. Switch - headlamp
• 11008707Oct 2, 2024Electrical system. Switch - headlamp
• 11008697Oct 2, 2024Body and structure, Engine. FCA Caribbean Warranty Bulletin ID-23-03 Rev. F 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11008356Oct 2, 2024Body and structure, Engine. Warranty Bulletin D-23--04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11008200Sep 25, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11007954Sep 17, 2024Electrical system. Battery Drain Suspected or "Identified" From USB or Media Hub
• 11007649Sep 6, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11006622Aug 23, 2024Suspension. Click Noise From Front End While Driving And Or Turning.
• 11006887Aug 8, 2024Wheels. WHEEL - STEEL
• 11006254Aug 7, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11006237Aug 7, 2024Body and structure, Other or unknown. WARRANTY BULLETIN D-23-04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. D)
• 11006192Aug 7, 2024Other or unknown, Body and structure. FCA Caribbean Warranty Bulletin ID-23-03 Rev. E adds 2024 model year vehicles and updates the Collision Service Bulletin number
• 11006240Aug 6, 2024Transmission and drivetrain. Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph).
• 11005356Jul 24, 2024Transmission and drivetrain. Carrier – planetary & shaft kit - output
• 11005320Jul 24, 2024Body and structure. "Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market.
• 11004939Jul 17, 2024Transmission and drivetrain. D Clutch Repair Kit TSB 21-039-24 REV A - D-Clutch repair kit missing Carrier Output Shaft Seals It has been identified the Carrier Output Shaft is missing 2 seals for some of the kits delivered to dealers. These seals are not available individually. MOPAR is working to get the parts. Do not rebuild the transmission without these seals otherwise the vehicle will not have reverse.

← All problems reported for the 2020 Jeep Gladiator