2021 Jeep Gladiator Technical Service Bulletins

700 technical service bulletins (TSBs) are on record for the 2021 Jeep Gladiator. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11006622Aug 23, 2024Suspension. Click Noise From Front End While Driving And Or Turning.
• 11006887Aug 8, 2024Wheels. WHEEL - STEEL
• 11006254Aug 7, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11006241Aug 7, 2024Electrical system, Body and structure. "Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses."
• 11006237Aug 7, 2024Body and structure, Other or unknown. WARRANTY BULLETIN D-23-04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. D)
• 11006192Aug 7, 2024Body and structure, Other or unknown. FCA Caribbean Warranty Bulletin ID-23-03 Rev. E adds 2024 model year vehicles and updates the Collision Service Bulletin number
• 11006240Aug 6, 2024Transmission and drivetrain. Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph).
• 11005356Jul 24, 2024Transmission and drivetrain. Carrier – planetary & shaft kit - output
• 11005320Jul 24, 2024Body and structure. "Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market.
• 11004939Jul 17, 2024Transmission and drivetrain. D Clutch Repair Kit TSB 21-039-24 REV A - D-Clutch repair kit missing Carrier Output Shaft Seals It has been identified the Carrier Output Shaft is missing 2 seals for some of the kits delivered to dealers. These seals are not available individually. MOPAR is working to get the parts. Do not rebuild the transmission without these seals otherwise the vehicle will not have reverse.
• 11004944Jul 16, 2024Transmission and drivetrain. No Reverse And/Or Forward Gear After D-Clutch Repair.
• 11004940Jul 15, 2024Transmission and drivetrain. D Clutch Repair Kit TSB 21-039-24 REV A - D-Clutch repair kit missing Carrier Output Shaft Seals It has been identified the Carrier Output Shaft is missing 2 seals for some of the kits delivered to dealers. These seals are not available individually. MOPAR is working to get the parts. Do not rebuild the transmission without these seals otherwise the vehicle will not have reverse.
• 11004839Jul 13, 2024Other or unknown. "Management Procedure for Customer Issues in Connected Services Customers may experience the following: ● Various Connected Services issues. The purpose of this informative Technical Service Bulletin (TSB) is to support the Network on the following topics: ● Discern the different kinds of connected service issues (onboard / offboard). ● Support the customer in his journey to open a request via Customer Care.
• 11004840Jul 10, 2024Transmission and drivetrain. "Flash: Powertrain Control Module (PCM) Updates **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P2463 - Particulate Filter Restriction - Soot Accumulation Bank 1. (EE Market Only)** ● P016F - Closed Loop Fuel Pressure Control At Limit - Pressure Too Low. ● P025C - Fuel Pump Module Control…
• 11003796Jul 1, 2024Body and structure. Water Leak From Front Door. Water On Front Floor.
• 11002796Jun 27, 2024Electrical system. "12V Battery Low Level Charge Notification On Customer’s Mobile Application Vehicle's 12V battery Low Level Charge notification on customer’s mobile application."
• 11002810Jun 26, 2024Other or unknown. Saftey Recall 19A 2021 Model Year only
• 11002828Jun 25, 2024Engine, Electrical system. "Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "
• 11002019Jun 21, 2024Body and structure, Electrical system. SWITCH Power Window Before replacing the window switch, please follow these steps: 1.- Review the master window Switch for any physical issue (Button stuck, broke). If not, physical issue is found move to next step 2.- Make sure all the switches harness are properly connected, disconnect the switch and reconnect it, and reverify the issue. If after performing these steps the switch remains faulty, please replace…
• 11002424Jun 20, 2024Visibility (wipers, defrost, mirrors). Wiperunit - windshield wiper, blade - front wiper
• 11002315Jun 20, 2024Body and structure. Wiperunit - windshield wiper, blade - front wiper
• 11002314Jun 20, 2024Body and structure. Wiperunit - windshield wiper, blade - front wiper.
• 11001771Jun 15, 2024Transmission and drivetrain. "D Clutch Repair Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D…
• 11001383Jun 6, 2024Body and structure. Freedom Panel Underside Rough And Or White Coating Flaking
• 11001026May 29, 2024Body and structure. Water Leaking Near Front Bulkhead Or Cowl Area On Driver’s Side.
• 11001310May 25, 2024Transmission and drivetrain. "D Clutch Repair Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D…
• 11000824May 21, 2024Engine. "GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c.
• 11000801May 15, 2024Transmission and drivetrain. "Axle Assembly Do not replace the Axle for Axle Locker Sensor failure. The parts kit (SENSOR KIT, Axle: 68544629A$) must be used to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Internal axle components are serviceable. Complete axle assemblies should not be replaced unless necessary due to damaged housing. Over repairs may be subject to chargeback."
• 11000168May 6, 2024Electrical system. HEADLAMP
• 11001198May 5, 2024Engine. Suspected Engine Coolant Leak
• 11000862May 3, 2024Steering. "Loss Of Power Steering Assist. U0131 Lost Communication With Electro Hydraulic Power Steering Control Module (EHPS)."
• 11001051May 2, 2024Engine. "fca caribbean warranty operations newsletter volume 10, issue 4"
• 11001050May 2, 2024Engine. Warranty Newsletter – Volume 10, Issue 4
• 10251875Jan 30, 2024Electrical system. Radio Over The Air Update from QR39.82F to QR40.12 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a…
• 10251797Jan 29, 2024Body and structure. Rear Cab Silencer Trim Panel Servicing.
• 10251795Jan 26, 2024Equipment. Radio Black Screen, Freezing, Reset, Cutting Out Or Inoperative Intermittently
• 10251870Jan 25, 2024Electrical system. Radio Over The Air Update from QR39.5 to QR40.11 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a…
• 10251867Jan 24, 2024Electrical system. Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will…
• 10251863Jan 23, 2024Exterior lighting, Back-over prevention (rear camera). Front and Rear Axle Sensor Kit **Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ? C1451-11 - Service Axle Locker System** Customers may also comment on a Service Axle Locker message displayed in the Electronic Vehicle Information Center (EVIC) for this condition.
• 10251767Jan 18, 2024Equipment. Thermostat Assy For 2022-2024MY 3.6L Pentastar Upgrade with P0128 failure code. PRIOR TO PERFORMING ANY THERMOSTAT REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2309000014
• 10251854Jan 17, 2024Exterior lighting. Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.
• 10251786Jan 17, 2024Tires. Tire Pressure Warning Lamp is on Steady, or Flashing
• 10251845Jan 13, 2024Electrical system, Equipment. Floor Console USB Inoperative Customers may comment on the following: ? Customer states the Apple Carplay/Android Auto? does not work or is intermittently working when their device is plugged into the center console bin USB port. This replacing the center console USB cable.
• 10251783Jan 10, 2024Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 10248941Nov 21, 2023Electrical system, Equipment, Other or unknown. Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer…
• 10248848Nov 17, 2023Equipment. Spring Front Upr - Isolator Before replacing this part. Please contact FCA REDACTED CONTENT. ~ If no response in 15 minutes, proceed with repair.
• 10248877Nov 16, 2023Transmission and drivetrain. Verifying Camshaft Diagnosis
• 10248856Nov 1, 2023Transmission and drivetrain. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P0341 ? Camshaft Position Sensor Performance ? Bank 1 Sensor 1, Set.
• 10247410Oct 23, 2023Vehicle speed control. FRT DOOR HINGE - DOOR CHECK If the front door check strap physically breaks or cracks, please call FCA Redacted Content. If no response in 15 minutes, proceed with repair. Please take pictures of the broken part and email the pictures to FCA Redacted Content.
• 10247445Oct 21, 2023Equipment. 4.5 Inch Premium Bar Speaker Static, Rattles, Buzzing

← All problems reported for the 2021 Jeep Gladiator