2023 Jeep Gladiator Technical Service Bulletins

378 technical service bulletins (TSBs) are on record for the 2023 Jeep Gladiator. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11014264Feb 11, 2025Electrical system. Cluster Warning Lamp is on, Service 4WD Message
• 11014231Feb 10, 2025Engine. "3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left…
• 11014094Feb 8, 2025Transmission and drivetrain. Clutch Overheat, And/Or Service Transmission Illuminated. Diagnostic Trouble Code (DTC) P08A6 – Gear Lever Position Sensor System – Multiple Sensor Correlation, Set Only In 4Low.
• 11014844Feb 5, 2025Body and structure. HINGE - DOOR
• 11013597Feb 1, 2025Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ●…
• 11013638Jan 29, 2025Transmission and drivetrain. Shifter - transmission
• 11013171Jan 25, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11013625Jan 21, 2025Other or unknown. Evaporator - air conditioning
• 11013003Jan 17, 2025Fuel system. FUEL VAPOR CANISTER FILTER EVAP Fuel Filters are to be checked for restriction / blockage on a regular schedule. If the Filter is restricted or blocked then replace the part.
• 11012925Jan 17, 2025Steering. Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19 - Steering / Diagnosis and Testing (IN SERVICE LIBRARY). PLEASE REFER 19 - Steering / Linkage / END, Tie Rod / Diagnosis and Testing IF YOU HAVE BALL JOINT LOOSENESS CONCERN. PLEASE DO NOT REPLACE DRAG LINK AND TIE ROD UNLESS PART HAS VISIABLE DAMAGE OR FREE PLAY EXCEEDS SPECS.
• 11013016Jan 15, 2025Transmission and drivetrain. D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. **Customers may also comment on one or more of the following: ●…
• 11027741Jan 12, 2025Transmission and drivetrain. We have observed that some JL/JT rear axle shafts are leaking oil. Replace axle shaft and seal together. Do not replace seal only. Keep original seal and axle shaft and send the parts as fast track.
• 11012777Jan 7, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11012196Dec 21, 2024Fuel system, Electrical system. "Fuel Delivery Module Inspection And Fuel Tank Replacement Customers may experience the following: ● Fuel gage reading incorrectly at 7/8 full after refueling. This bulletin involves replacing the fuel tank and possibly the fuel delivery module"
• 11012188Dec 19, 2024Body and structure. "B-Pillar Water Leak When Vehicle Is Parked On A Hill Customers may experience one or more of the following: ● The vehicle will leak water from the top of the B-pillar when the vehicle is parked on a downward incline. ● Water on door trim or carpet. ● Water drips down the inside door and panel This bulletin includes performing a water test and possibly adding foam pads to both Freedom Panels."
• 11012293Dec 16, 2024Other or unknown. FILTER - AIR
• 11012292Dec 16, 2024Other or unknown. FILTER - AIR
• 11011921Dec 14, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch"
• 11011895Dec 14, 2024Electrical system. Jeep Bluetooth Speaker Does Not Charge
• 11011901Dec 11, 2024Other or unknown. Warranty Bulletin ID-23-03 Rev. H 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11011898Dec 11, 2024Other or unknown. Warranty Bulletin D-23-04 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11011505Dec 4, 2024Body and structure. Buzz Squeak Rattle (BSR) From Speaker Sound Bar At High Volume Level.
• 11011504Dec 4, 2024Body and structure. Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.
• 11011150Nov 20, 2024Body and structure. COVER KIT - HOOD
• 11011171Nov 12, 2024Steering. DAMPER - NONE
• 11010511Nov 8, 2024Electrical system, Wheels. Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
• 11010481Nov 7, 2024Steering, Electrical system. Heated Steering Wheel Jl/JT Heating Steering Wheel INOP or not warm enough The purpose of this document is to help dealerships root cause or diagnose the issue of the heated steering wheel system. Before replacing or ordering replacement parts (steering wheel, switches and wire harness) because of Heated Steering Wheel Inoperative And Or Not Hot Enough concern please review Star On Line S2423000045 for further…
• 11010259Nov 2, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11009540Oct 31, 2024Steering, Electrical system. Heated Steering Wheel Inoperative And Or Not Hot Enough.
• 11008973Oct 16, 2024Engine. FCA Caribbean Warranty Bulletin ID-23-03 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11008972Oct 16, 2024Engine. Warranty Bulletin D-23-04 Rev. F 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11009027Oct 15, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch. "
• 11008913Oct 10, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11009561Oct 3, 2024Electrical system. Switch - headlamp
• 11008707Oct 2, 2024Electrical system. Switch - headlamp
• 11008697Oct 2, 2024Body and structure, Engine. FCA Caribbean Warranty Bulletin ID-23-03 Rev. F 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11008356Oct 2, 2024Body and structure, Engine. Warranty Bulletin D-23--04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11008200Sep 25, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11007984Sep 20, 2024Wheels. Low Tire Pressure. Tire Valve Stem And Tire Pressure Monitor (TPM) Sensor Service.
• 11007954Sep 17, 2024Electrical system. Battery Drain Suspected or "Identified" From USB or Media Hub
• 11007649Sep 6, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11006622Aug 23, 2024Suspension. Click Noise From Front End While Driving And Or Turning.
• 11006887Aug 8, 2024Wheels. WHEEL - STEEL
• 11006254Aug 7, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch."
• 11006241Aug 7, 2024Body and structure, Electrical system. "Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses."
• 11006237Aug 7, 2024Body and structure, Other or unknown. WARRANTY BULLETIN D-23-04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. D)
• 11006192Aug 7, 2024Other or unknown, Body and structure. FCA Caribbean Warranty Bulletin ID-23-03 Rev. E adds 2024 model year vehicles and updates the Collision Service Bulletin number
• 11006240Aug 6, 2024Transmission and drivetrain. Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph).
• 11005725Aug 4, 2024Other or unknown, Suspension. "Noise From Front End While Driving Customers may experience the following: ● Noise (rattle/thump/clunk noise) coming from the front end of the vehicle. This bulletin involves inspecting and possibly replacing the Active Stabilizer Bar System (ASBS). "
• 11005356Jul 24, 2024Transmission and drivetrain. Carrier – planetary & shaft kit - output

← All problems reported for the 2023 Jeep Gladiator