2025 Jeep Gladiator Technical Service Bulletins

195 technical service bulletins (TSBs) are on record for the 2025 Jeep Gladiator. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11015810Mar 17, 2025Other or unknown. "CANISTER Vapor -If an issue is detected with the Evaporative System Integrity Module (ESIM) Detector and not the Vapor Canister, only replace the ESIM Detector. -Before replacing the Vapor Canister due to Hard to Fill condition, replicate the condition at the Gas Station.
• 11015602Mar 12, 2025Electrical system. Horn Sound Is Weak, Off Tone, Inoperative, Or Intermittent.
• 11015307Mar 4, 2025Electrical system. Apple CarPlay Does Not Complete The First Initial Wireless Connection.
• 11015297Mar 4, 2025Engine. Engine Noise
• 11015033Feb 28, 2025Body and structure. Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot.
• 11015065Feb 25, 2025Engine. 3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left…
• 11014538Feb 22, 2025Electrical system. Uconnect Box Require Service Message
• 11014529Feb 20, 2025Electrical system. Touchscreen For all infotainment system repairs (touchscreens, radios, etc.), refurbished parts may be available. Follow the Infotainment Ordering guide available under the "Parts" section of Dealer Connect: DealerCONNECT> Parts> News& Information> Audio & Electronic Products Exchange Process
• 11014532Feb 19, 2025Body and structure. Exterior Rear View Mirror Stained And Will Not Clean.
• 11014408Feb 18, 2025Engine. Engine Rattle Noise
• 11014375Feb 15, 2025Engine. "Oil Leaking From Oil Filter Area Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● P06DD - Engine Oil Pressure Control Circuit Stuck Off. Customers may comment on the following: ● Oil found on the ground beneath the vehicle. "
• 11014385Feb 14, 2025Body and structure, Electrical system. "Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses. "
• 11014266Feb 14, 2025Body and structure, Electrical system. Defogger Is Not Working. Terminal Detached From The Glass.
• 11014337Feb 11, 2025Electrical system. Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)
• 11014231Feb 10, 2025Engine. "3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left…
• 11013597Feb 1, 2025Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ●…
• 11013638Jan 29, 2025Transmission and drivetrain. Shifter - transmission
• 11013171Jan 25, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11013625Jan 21, 2025Other or unknown. Evaporator - air conditioning
• 11013003Jan 17, 2025Fuel system. FUEL VAPOR CANISTER FILTER EVAP Fuel Filters are to be checked for restriction / blockage on a regular schedule. If the Filter is restricted or blocked then replace the part.
• 11012925Jan 17, 2025Steering. Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19 - Steering / Diagnosis and Testing (IN SERVICE LIBRARY). PLEASE REFER 19 - Steering / Linkage / END, Tie Rod / Diagnosis and Testing IF YOU HAVE BALL JOINT LOOSENESS CONCERN. PLEASE DO NOT REPLACE DRAG LINK AND TIE ROD UNLESS PART HAS VISIABLE DAMAGE OR FREE PLAY EXCEEDS SPECS.
• 11013016Jan 15, 2025Transmission and drivetrain. D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. **Customers may also comment on one or more of the following: ●…
• 11027741Jan 12, 2025Transmission and drivetrain. We have observed that some JL/JT rear axle shafts are leaking oil. Replace axle shaft and seal together. Do not replace seal only. Keep original seal and axle shaft and send the parts as fast track.
• 11012777Jan 7, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11012188Dec 19, 2024Body and structure. "B-Pillar Water Leak When Vehicle Is Parked On A Hill Customers may experience one or more of the following: ● The vehicle will leak water from the top of the B-pillar when the vehicle is parked on a downward incline. ● Water on door trim or carpet. ● Water drips down the inside door and panel This bulletin includes performing a water test and possibly adding foam pads to both Freedom Panels."
• 11012293Dec 16, 2024Other or unknown. FILTER - AIR
• 11012292Dec 16, 2024Other or unknown. FILTER - AIR
• 11011921Dec 14, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch"
• 11011150Nov 20, 2024Body and structure. COVER KIT - HOOD
• 11011174Nov 19, 2024Body and structure, Electrical system. Grille - instrument panel speaker
• 11011171Nov 12, 2024Steering. DAMPER - NONE
• 11010511Nov 8, 2024Electrical system, Wheels. Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
• 11009540Oct 31, 2024Steering, Electrical system. Heated Steering Wheel Inoperative And Or Not Hot Enough.
• 11009561Oct 3, 2024Electrical system. Switch - headlamp
• 11008707Oct 2, 2024Electrical system. Switch - headlamp
• 11007984Sep 20, 2024Wheels. Low Tire Pressure. Tire Valve Stem And Tire Pressure Monitor (TPM) Sensor Service.
• 11007954Sep 17, 2024Electrical system. Battery Drain Suspected or "Identified" From USB or Media Hub
• 11006622Aug 23, 2024Suspension. Click Noise From Front End While Driving And Or Turning.
• 11006886Aug 21, 2024Electrical system, Body and structure. Bezel - instrument panel
• 11006869Aug 21, 2024Body and structure. Glove box - instrument panel
• 11006887Aug 8, 2024Wheels. WHEEL - STEEL
• 11005356Jul 24, 2024Transmission and drivetrain. Carrier – planetary & shaft kit - output
• 11005199Jul 22, 2024Electrical system. CAN Star Block Connector Customer finds MIL light on and technician finds DTC for loss of communication on one or more modules. In repair procedure the dealerships are replacing the CAN star block connector during their root cause process with returned parts showing no trouble found.
• 11002531Jun 28, 2024Electrical system. Drained Battery, Low System Voltage, Battery Not Charging, High System Voltage
• 11002828Jun 25, 2024Electrical system, Engine. "Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "

← All problems reported for the 2025 Jeep Gladiator