2017 Jeep Grand Cherokee Technical Service Bulletins

352 technical service bulletins (TSBs) are on record for the 2017 Jeep Grand Cherokee. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10138863Jun 21, 2017Engine cooling. Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block Interface leaks. Using dye will assist in determining source of leak. Ensure OFA Cap Oring is seated in the proper groove in the cap and not damaged or cut. Engineering is seeking…
• 10138859Jun 21, 2017Fuel system. Fuel Tank Before replacing this part due to Hard to Fill condition, check the Fuel Filler Tube for restriction after the second door of the capless unit. Replace the Fuel Filler Tube if the second door of the capless unit does not open properly. Contact Sylvia Lopez at (248) 520-9734 if a Tank needs to be replaced.
• 10219831Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10138856Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10219882Jun 9, 2017Transmission and drivetrain. Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. The following software enhancements are available:Allow the throttle body to be cycled while the engine is off, for diagnostic purposes. Improved vehicle acceleration at low speed while towing. Allows transmission gear shifting while in limp-in mode…
• 10219881Jun 9, 2017Transmission and drivetrain. Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation, a technician may find the following Diagnostic Trouble Code (DTC) stored in the TCM memory:P1DCD-00 - TCM Monitoring Processor Performance…
• 10138907Jun 9, 2017Transmission and drivetrain. Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. The following software enhancements are available:Allow the throttle body to be cycled while the engine is off, for diagnostic purposes. Improved vehicle acceleration at low speed while towing. Allows transmission gear shifting while in limp-in mode…
• 10138906Jun 9, 2017Transmission and drivetrain, Electrical system. Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation, a technician may find the following Diagnostic Trouble Code (DTC) stored in the TCM memory:P1DCD-00 - TCM Monitoring Processor Performance…
• 10219830Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10219828Jun 7, 2017Back-over prevention (rear camera). Rear View Camera In the case for inoperative camera, radio screen is blue or black in reverse mode. Before proceeding with the normal procedure call Ali Ikram at (248) 576-9265 Mon- Fri between 8 am- 4pm. If you do not get a response within 15 minutes continue with the repair. Make sure that connector is inserted properly. If there is a need to replace camera. In case of bad wire harness. Replace the harness and…
• 10219826Jun 7, 2017Brakes. Brake Pedal Sensor For vehicles with DTC's P0572 or C0042, or complaints of brake lights staying on or cruise control not setting, please use wiTech to check the Brake Pedal Home Position setting and actual pedal resting position under brake pedal status in the ABS module. Before replacing the Brake Pedal Position Sensor, please call Rick Gordon at Cell (248) 630-6281. If no response within 15 minutes, proceed with…
• 10219825Jun 7, 2017Electrical system, Back-over prevention (rear camera). Blind Spot Detection Sensor If you are replacing this part due to a customer complaint of "Blind spot alert unavailable - wipe rear bumper", please read the following instructions before proceeding. 1) Verify that the rear bumper is clear of any obstructions. The process to clear the blockage message involves first cycling the ignition. 2) The vehicle must be driven on the road and pass/be passed by vehicles on…
• 10138855Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10138853Jun 7, 2017Equipment. Rear View Camera In the case for inoperative camera, radio screen is blue or black in reverse mode. Before proceeding with the normal procedure call Ali Ikram at (248) 576-9265 Mon- Fri between 8 am- 4pm. If you do not get a response within 15 minutes continue with the repair. Make sure that connector is inserted properly. If there is a need to replace camera. In case of bad wire harness. Replace the harness and…
• 10138851Jun 7, 2017Brakes. Brake Pedal Sensor For vehicles with DTC's P0572 or C0042, or complaints of brake lights staying on or cruise control not setting, please use wiTech to check the Brake Pedal Home Position setting and actual pedal resting position under brake pedal status in the ABS module. Before replacing the Brake Pedal Position Sensor, please call Rick Gordon at Cell (248) 630-6281. If no response within 15 minutes, proceed with…
• 10138850Jun 7, 2017Lane departure. Blind Spot Detection Sensor If you are replacing this part due to a customer complaint of "Blind spot alert unavailable - wipe rear bumper", please read the following instructions before proceeding. 1) Verify that the rear bumper is clear of any obstructions. The process to clear the blockage message involves first cycling the ignition. 2) The vehicle must be driven on the road and pass/be passed by vehicles on…
• 10217587Mar 31, 2017Transmission and drivetrain, Electrical system. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Some customers may experience the following condition: During an engine limp mode condition, the transmission remains in a fixed gear.The following software enhancement is also available: Transmission shift quality enhancement.
• 10217586Mar 31, 2017Exterior lighting, Back-over prevention (rear camera), Air bags, Engine…. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs set in the PCM memory: U1424 - Implausible Engine Torque Signal Received (2017 MY Only). P2681…
• 10140055Mar 31, 2017Transmission and drivetrain, Electrical system. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Some customers may experience the following condition: During an engine limp mode condition, the transmission remains in a fixed gear.The following software enhancement is also available: Transmission shift quality enhancement.
• 10140054Mar 31, 2017Engine cooling, Electrical system. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs set in the PCM memory: U1424 - Implausible Engine Torque Signal Received (2017 MY Only). P2681…
• 10217530Mar 29, 2017Wheels. Trans Pan or Gasket If your repair requires replacing one of the two part numbers for a leak, prior to the repair please call Enzo Piazza at cell (248) 467-9163. If you cannot reach Enzo within 15 minutes proceed with the repair. Enzo needs to know the location of the leak, if the bolts were torqued, if there is sealer skip, or anything that may be pertinent to the cause of the leak. Photos would be very helpful…
• 10217527Mar 29, 2017Back-over prevention (rear camera), Steering, Transmission and drivetrain. Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear: C2217-00, C15C1-00 (EPS Mechanical Performance) or C15DB-00 (Latch Active) otherwise perform the following; 1) Electrical, Communication or DTC (other then above) issue please contact: Terry Gavit @ cell (248) 882-6108 [email protected] Engineering is requesting a copy of Vehicle Scan Report (VSR) to be…
• 10217524Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10139998Mar 29, 2017Engine cooling. Trans Pan or Gasket If your repair requires replacing one of the two part numbers for a leak, prior to the repair please call Enzo Piazza at cell (248) 467-9163. If you cannot reach Enzo within 15 minutes proceed with the repair. Enzo needs to know the location of the leak, if the bolts were torqued, if there is sealer skip, or anything that may be pertinent to the cause of the leak. Photos would be very helpful…
• 10139995Mar 29, 2017Steering. Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear: C2217-00, C15C1-00 (EPS Mechanical Performance) or C15DB-00 (Latch Active) otherwise perform the following; 1) Electrical, Communication or DTC (other then above) issue please contact: Terry Gavit @ cell (248) 882-6108 [email protected] Engineering is requesting a copy of Vehicle Scan Report (VSR) to be…
• 10139992Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10217565Mar 15, 2017Fuel system, Transmission and drivetrain. Poor Vehicle Acceleration This bulletin involves test driving the vehicle and if required, replacing the fuel pump module. The customer may notice the vehicle has poor acceleration and/or the transmission will not upshift under Wide Open Throttle (WOT). This can be caused by low fuel flow from the fuel pump module.
• 10217523Mar 15, 2017Suspension. Rear Shock Absorber Customer complains of noise; this may be due to contact between shock body and the dirt shield. Please check dirt shield, if it is creating a rub mark remove but do not disassemble. Please call Robert Beckwith cell (248)-727-3689. If you don?t receive a response within 15 minutes, please continue with normal repair procedure.
• 10217521Mar 15, 2017Fuel system. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10140033Mar 15, 2017Fuel system, Transmission and drivetrain. Poor Vehicle Acceleration This bulletin involves test driving the vehicle and if required, replacing the fuel pump module. The customer may notice the vehicle has poor acceleration and/or the transmission will not upshift under Wide Open Throttle (WOT). This can be caused by low fuel flow from the fuel pump module.
• 10139991Mar 15, 2017Suspension. Rear Shock Absorber Customer complains of noise; this may be due to contact between shock body and the dirt shield. Please check dirt shield, if it is creating a rub mark remove but do not disassemble. Please call Robert Beckwith cell (248)-727-3689. If you don?t receive a response within 15 minutes, please continue with normal repair procedure.
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10217507Mar 8, 2017Visibility (wipers, defrost, mirrors). Cleaner For A/C Evaporator Before using deodorizer to remove HVAC or evaporator odor, call Ken Deneau at cell (248) 765-0288. If no response in 15 minutes, please continue with repair
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139975Mar 8, 2017Equipment. Cleaner For A/C Evaporator Before using deodorizer to remove HVAC or evaporator odor, call Ken Deneau at cell (248) 765-0288. If no response in 15 minutes, please continue with repair
• 10217592Mar 3, 2017Electrical system, Transmission and drivetrain. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Some customers may experience the following condition: · During an engine limp mode condition, the transmission remains in a fixed gear. The following software enhancement is also available: · Transmission shift quality enhancement.
• 10217590Mar 3, 2017Transmission and drivetrain, Engine cooling, Electrical system. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs set in the PCM memory: U1424 - Implausible Engine Torque Signal Received (2017 MY 3.0L and…
• 10140060Mar 3, 2017Electrical system, Transmission and drivetrain. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Some customers may experience the following condition: · During an engine limp mode condition, the transmission remains in a fixed gear. The following software enhancement is also available: · Transmission shift quality enhancement.
• 10140058Mar 3, 2017Electrical system, Engine cooling. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs set in the PCM memory: U1424 - Implausible Engine Torque Signal Received (2017 MY 3.0L and…
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121835Nov 30, 2016Electrical system. Variable Valve Timing (VVT) Solenoid, Variable Valve Timing (VVT) Phaser For a 2016/2017 MY 6.4L SRT with less than 12,000 miles that have either a P0016 CRANKSHAFT/CAMSHAFT TIMING MISALIGNMENT - BANK 1 SENSOR 1 or P000B BANK 1 CAMSHAFT 2 POSITION SLOW RESPONSE fault codes active and fault code diagnostics lead to replacing a Variable Valve Timing (VVT) Solenoid and/or a Variable Valve Timing (VVT) Phaser, prior to…
• 10121881Nov 22, 2016Transmission and drivetrain. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs set in the PCM memory: P2681 - Engine Coolant Bypass Valve Control Circuit Open (3.6L Only)…
• 10121875Nov 18, 2016Lane departure. Flash: Blind Spot Monitor System Improvements This bulletin involves updating the Left and Right Blind Spot Sensor (LBSS/RBSS) software. The customer may experience the blind spot monitor indicator may not chime alerting them that there is an object next to the vehicle.
• 10121831Nov 16, 2016Equipment. License Lamp If vehicle comes in for license plate bulb replacement, you will need to determine the version of the bulbs that you have. ~ ~ If you have clear lenses with lines on them, you will need PN 68225282AA. If none are available, you will need to order PN 68360246AA (Non-Camera) or 68360247AA (Camera).~ ~ If you have opaque lenses, you will only need PN 68228927AA
• 10121828Nov 16, 2016Engine cooling. Water Pump Dealers are replacing water pumps because of a coolant leak. Water pumps are found TNF but the water pump bypass o-ring was pinched resulting in a coolant leak that looks like a failed pump. Please inspect the bypass o-ring before replacing the pump as it is available separate for service.
• 10223848Sep 28, 2016Body and structure, Exterior lighting. Incorrect Gap Tolerance Between The Liftgate And Left Tail Lamp This bulletin involves removing excess sealant from the body behind the tail lamp to open the gap clearance between the left tail lamp and the liftgate. .1 - Gap Clearance Too Close (Left Side)1 - Proper Gap Clearance (Right Side)
• 10220469Sep 28, 2016Body and structure. Incorrect gap tolerance between the liftgate and left tail lamp.
• 10191440Sep 28, 2016Exterior lighting. Incorrect gap tolerance between the liftgate and left tail lamp.
• 10223855Sep 7, 2016Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has…
• 10224869Aug 24, 2016Back-over prevention (rear camera). PSU Exhaust Phaser 05048043AB If replacing the Exhaust Phaser for the following codes: P0340 Cam Missing/Camshaft Sensor Circuit and/or P0345 Cam Missing/Camshaft Sensor Circuit Engineering is requesting that all three Valve Timing components (Phaser, Actuator, OCV) be replaced.~ Please label the components of which bank they came from prior to parts return.

← All problems reported for the 2017 Jeep Grand Cherokee